Beruflich Dokumente
Kultur Dokumente
1 3 18-12
SUBJECT DATE
Installation of the Supply Fuel Temperature Sensor March 2012
Install as follows:
1. Install the sensor and new seal on the fuel filter module; tighten the sensor using the appropriate wrench on the hex end
of the sensor. Torque sensor to 30-35 N·m (22-25 lb·ft).
2. Install the harness connector onto the sensor and push the gray tab to the up position.
3. Seat the secondary lock on the electrical connector.
4. Prime the fuel system. Refer to section "Priming of the Fuel System Using ESOC 350 Fuel Priming Pump" .