Sie sind auf Seite 1von 3

1. 3rd world countries mean.

2. Human blood pH is 7.4


3. Afghanistan is buffer state of Asia.
4. Canada is in North America.
5. the world's largest station by platforms is Grand Central Terminal in New York
City with 44 platforms.
6. First world war started in 28 July 1914.
7. UNO established in 24 October 1945.
8. Wheel is symbol of progress.
9. 102 to 204 cm rainfall
10. Smallest boundary of Pakistan is with China.
11. Barometer is used to measure the pressure.
12. Pakistan is in south Asia.
13. Hmmas is radical group of Palestine.
14. VIBGYOR rainbow color.
15. Sun shines twice in year on Equator.
16. On 1949 ceasefire b/w Pak and India took place
17. Europe does not have any “Desert”.

Technical Portion
18. Low resistance measuring device is Kelvin Bridge.
19. The shunt winding of motor has a resistance of 85 ohm at 22 degree when the motor runs at full
load, its resistance increases to 100 ohm. The resistance temperature coefficient of winding per
0 degree is 0.004. The rising temperature of winding will be? Ans is 70 degree.
20. A 100V bulb has a resistance of 500 ohm. The number of hours it can work per every KWh of
energy consumed will be ? 50 hours.
21. Main feature of crystal oscillator is stability. (2 Times repeated)
22. In class A, conduction angle is 360 degree.
23. For pre amplification, which Power amplifiers are used for linearity purpose? Class A, Class B,
Class C, Class A-B.
24. In metals, electrons revolve in the metal because of (constant V, sinusoidal, square, triangular,
non periodic).
25. Moderator used in Nuclear is graphite.
26. In alternator, if p.f load is unity, then armature flux will be?
cross magnetizing.
27. State variables are used in which models? All of above.
28. LTI system can be completely recognized by impulse response of the system.
29. Stray Voltage is small voltage (less than 10) which can be measured between two points.
30. At resonance, Current is ? Reactance is zero, and one’s answer is none of above. (3 MCQS)
31. Stepper motor, speed depends upon frequency.
32. There are two types of overload protection: instantaneous overcurrent and time overcurrent
(TOC).
33. In motor which O.L protection is used ? Thermal O.L relay.
34. Vrms*Irms=Apparent Power
35. Power against Inductance is reactive power.
36. Power against resistance is active power.
37. If all conductors are grounded to the same grounding system, what is the probability of shock?
(Minimum ? Zero? What?)
38. CMMR =
39. CMMR should be (low, maximum, high, zero) for better OPAM operation.
40. Uranium-235 is an isotope of uranium making up about 0.72% of natural uranium
41. Thermal to K.E is converted in the Rocket.
42. Moving iron type Ammeter has few turns of thick wire so that its resistance is less.
43. The advantage of permanent magnet ammeter is all of above. (effective eddy current damping,
low hysteresis loss, low power consumption, uniform scale, very sensitive to current.)
44. If height of transmission tower is increased, Capacitance will decrease and inductance remain
same.
45. For current amplification, CC & CE are used.
46. VI characteristics of UJT is similar to ?
47. CB is similar to Common gate of FET.
48. TRIAC is bidirectional device.
49. Solid grounding is used below 660V.
50. In submarine power is transmitter through which cables (
51. Which is least reliable source of energy? (wind)
52. High gain DC-DC convertor applications are ? (All of above)
53. Which principle is used to analyzing the fault? (Thev, nort, Superposition, Jordon).
54. Q-point operating point of transistor model analysis.
55. Negative resistance is of Tunnel diode.
56. Inverse of p.f is Q factor.
57. Roll off rate of operational amplifier is usually is -20 dB decades.
58. Channel is in b/w Drain and Source of FET.
59. Which current flows due to minority charge carriers? (Hole current, reverse leakage current,
forward leakage current, all of the above.)
60. Transformer rating is given in KVA instead of KW why? (Customary, loss depends upon V&I,
power factor is not known, All of above).
61. In Transformer ratio 20:1 means
62. Stator appears to be stationary and rotor freely moves which is rotating transformer is
equivalent to induction motor.
63. Transformer has maximum efficiency when Cu losses becomes equal to Fe losses.
64. In transformer leakage flux is proportional to current which indicates (leakage flux in core some
sort of MCQs)
65. Transformer has different no. of primary & secondary turns.
66. Which op amp converts high impedance to low impedance (inverting, non inverting, follower,
summing point)
67. On reverse biasing of FET, what happens? (Channel resistance increase? Or Capacitance?)
68. SCR goes into saturation when (gate to cathode voltage forward biased?)
69. CE amplifies (V, I, P, all of above)
70. DC motor has high torque.
71. Accumulative motor adds the series and shunt magneto motive force.
72. Control system is used for? (remote control, power application, disturbance control, all of
above)
73. Which does not use external source ( Oscillator)
74. OP AMP optimum operating voltages are ( +_18, +_15, etc)
75. LC Tuned oscillator stability is dependent upon (Q factor, L, C, transistor).
76. Light is produced in electric discharge lamp due to (heating effect, magnetic effect, ionization in
a gas / vapor).
77. What is produced by superconductor (V, temp, Press, magnetic field)
78. In superconductors what happens ( repulsion of magnetic, absorbing of magnetic field,
absorbing of electric field, repulsion of electric field)
79. Which engine has highest air fuel ratio?
80. Diode is used for rectification.
81. Diode limiters are used for limiting positive and negative cycles both.
82. In Bridge s, ripple frequency of output wave is twice of input.
83. Voltage controlled oscillators:
84. Lead acid batteries are storage batteries
85. Output variables are (Dependent, independent so, so) dependent.
86. Current leads by 90 and voltage lags by 90 to current is in ©
87. If poles lie in left half plane, system is stable.
88. Which power system requires 4 wires? (star, delta, interconnected, none of above)
89. Current in transmission lines is …….(3 phase)
90. DC two wire system require least conductor material.
91. 3 phase 4 wire system has two types of voltages

Das könnte Ihnen auch gefallen