Beruflich Dokumente
Kultur Dokumente
A. Part No 9
B. Part No 7
C. Part No 8
D. Part No 10
2. On which part of this pneumatic transmitter does the pressure of the process
(steam,oil,water) act ?
a. Item No 1
b. Item No 3
c. Item No 2
d. Item No 4
A. part No 10.
B. part No 9.
C. part No 15.
D.
part No 11.
4. From this drawing of a pneumatic pressure transmitter, what is the Proportional Band
setting ?
a. Proportional Band more than 100 %, amplification K less than 1
b. Proportional Band less than 100 %, amplification K more than 1
c. Proportional Band = 100 %, amplification K = 1
d. Proportional Band 0%, amplification infinitive
5. For which type of controller are these the input (left) and the response (right)
characteristics ?
a. A pneumatic integrator
b. A pressure integrating controller
c. A pneumatic inverter
d. A proportional integrating controller
integrating controller ?
a. R2
b. Rf
c. R1
d. R3
8. Fitting a restriction RI in the supply to the proportional feedback of this PID controller
ensures that for an initial small variation on the input, the initial response on the output
will be .....
a. proportional
b. zero
c. very weak
d. strong
9. For which control instrument are these
the input (left) and the output or
response (right) characteristics ?
10. For this PID controller to act only as a P (proportional) controller, what should be the
arrangement of restricting values R1 and R2 ?
12. In the output characteristics (right) of this controller, which response lines are clearly shown
?
A. By C and RL
B. By C and RL
C. By C and R3
D. By C and R2
A. With item No 3
B. With item No 2
C. With item No 1
D. With items 1, 2 and 3.
18. The three conductor system used by Wheatstone Bridge lay-outs is intended to
provide........
20. The resistance characteristic of Platinum is linear. The resistance characteristic of Nickel
is non-linear. How can the characteristic of Nickel be made linear ?
a. By fitting a compensation cable
b. By fitting another resistance in parallel
c. By using a three-wire system Wheatstone Bridge
d. By fitting another resistance in series