Beruflich Dokumente
Kultur Dokumente
QUALITY CERTIFIED
SOLENOID VALVES
w
ww
.t
w
.s
m
hako.co
SAFETY NOTICE & CAUTION FOR
ISO-9001
SOLENOID VALVE QUALITY CERTIFIED
Please read the safety notice carefully before using and pay attention to the safety cautions of this product. • When using manifold to secure the solenoid valve, take Caution of service and maintenance
care proper position of the manifold packing, and then
Caution of this product Caution for installation tighten at both sides evenly to prevent leakage.
• Avoid lengthy distance between solenoid valve and piping; Warning
Warning Warning long pipeline will affect the activation effect and response.
• Shut off the power switch and air source properly before
• While designing the circuit, make thorough understanding • Caution for manner of installation: for the complex moving
service and maintenance, confirm that there is no residue
to the characteristic of the compressed air and the and three position model, please install horizontally. Caution pressure in the pipeline and start work after confirming
application of this product. • Don't use if the vibration of the mounting position exceed
the status is safe.
• The air in use is compressed, please note that expandable 50m/s2; for the place with low vibration, install with the • Connection of DIN terminal box
• The manual device of solenoid valve must be retumed to
and unstable pressure may fly out, burst out or leak. solenoid valve perpendicularly to direction of vibration DIN terminal box is class IP65 water proof: please positioned
home (initial position) and confirm that all are reset, and
• Beware of the fluid temperature, please follow the range to prevent loosen. and slot firmly when installing, use screw for fixing.
then start the normal operation is allowed, because if the
defined by Specification Table (0~60℃) • Prevent entrance of debris and dust foreign object into
solenoid valve before pipe laying in order to prevent power is turning on before confirming for reset to home
• While designing and selecting the machine model, please
failure and error action. Screw will cause abnormal action and lead to hazard.
consider the incorrect shift of the driven object caused by
• Prevent debris and leak proof tape residue from entering • The assembly and disassembly of solenoid valve should
emergency or transient power interruption which may Rubber sleeve
the pipe while pipe laying and assembling the connector. be carried by personnel who is familiar with structure of
impair safety. When choosing the machine model, please
Reserve 1~1.5 thread not wound with tape seal while Note:can circle the product and know well the internal structure and
have the competence of controlling model, and the fixed Gasket
winding. around 180° principle, avoid error disassembly and cause safety
position or automatic shift model during power interruption
concern on operation and application.
under consideration. Nut
Lock
• Excessive water in the pipeline will cause malfunction liquid
10
10
SOLENOID VALVES
SOLENOID VALVES
4.0
7.0 7.0
7.5
4.0
7.5
strict quality control provide a
long durability.
31
31
*Quick acting, low starting pressure.
*Low power consumption 0.65W.
38.2 47.6
51.2 73.6
How to order 64 99.2
3-M3xP0.5 3-M3xP0.5
PM521 A F M3 S 9 LED
7.0
7.0 7.0
10mm Valve type Manifold Port size Solenoid Voltage LED 7.0
valves series A
A Body ported Blank Standard (W/O manifold) S Single solenoid 6 6VDC Blank
PM521B-M5-S PM521B-M5-D
5/2 way a b
B Base mounted F01 W/I single sub base (B type) D Double solenoid 7 12VDC (W/O LED)
Fxx xx stations manifold (B type) 9 24VDC 2-φ1.7 2-φ1.7
M02 2 stations manifold (A type)
10.0
7.5
Mxx xx stations manifold (A type)
7.5
7.0 7.0
How to order manifold
PM521 A 02
31
31
M5
10mm Manifold type Port size Stations 38.2
valves series 51.2 47.6
64 73.6
A For body ported valve 02 2 stations 99.2
5/2 way
B For base mounted valve 03 3 stations
XX XX stations
Specifications
L2=(N-1)x10.5+23.5
L1=(N-1)x10.5+16.5
2 22
3.
2 10
L1=(N-1)x10.5+18.0
L2=(N-1)x10.5+25.0
Fluid Compressed air
Sectional area 1.0mm 2
Acting Internal pilot
Operating pressure range 1.0 ~7 kgf/cm 2
PM521A-M3-D
Cycle rate 500 cpm
Proof pressure 8.0 kgf/cm 2
4.5
(45.2)
(51.7)
Ambient temperature -10℃ ~ 60℃
Duty cycle 100% ED
10
20
B B
10
JPC plug connector 6-M5xP0.8
Electrical connection 6-M5xP0.8 A A
5.0
20 10 2N-M5xP0.8xL4.0 13
13.5
5.0
Protection class IP65(DIN 40 050) 28 12 10.5 28
Insulation class F
Voltage tolerance ±10% Number of station (N) 2 3 4 5 6 7 8 9 10
Standard voltage 6VDC, 12VDC, 24VDC (The other voltage is optional) L1 28.5 39.0 49.5 60.0 70.5 81.0 91.5 102.0 112.5
Net weight 35g 48g L2 35.5 46.0 56.5 67.0 77.5 88.0 98.5 109.0 119.5
2-2 Shako Co., Ltd. www.shako.com.tw Shako Co., Ltd. www.shako.com.tw 2-3
5/2 WAY PILOT SOLENOID VALVE VM5252 series
ISO-9001
QUALITY CERTIFIED
Features Dimensions
A
*Quick acting agile response. VM5252-01-S VM5252-01-D
*Plug with standard JPC design (with LED).
Built-in surge protection and nonpolarity 96.5 128.5
design efficiently reduce possibility of 36 36
SOLENOID VALVES
16 16
SOLENOID VALVES
short circuit.
*Low power consumption 0.٨W.
11.6
11.6
2-G1/8 2-φ3.2 2-G1/8 2-φ3.2
32.3
32.3
32.5
32.5
23
23
How to order
16.6
16.6
5/2 way Port size Thread Solenoid Voltage
15
0.8
0.8
01 1/8" Blank G S Single solenoid 7 12VDC
0.8
0.8
15
N NPT D Double solenoid 9 24VDC
R Rc
16.7
16.7
How to order manifold
VM5252M 02 N 02 2-M3x0.5xL3.5
22.6 2-M3x0.5xL3.5
5/2 way Port size Thread Stations
02 1/4" Blank G 02 2 stations VM5252M-0102
(P & R Ports) N NPT 03 3 stations 4-φ4.5 20
R Rc XX XX stations VM5252-01S
Specifications
L2=(N-1)x16+24 10
L1=(N-1)x16+44
Model VM5252-01-S VM5252-01-D
16
Port size 1/8" (A & B Ports)
Body material Aluminum alloy
Fluid Compressed air VM5252-01D
Sectional area 8.8mm 2
Acting Internal pilot
Operating pressure range 1.5 ~7 kgf/cm 2 1 ~7 kgf/cm 2
Cycle rate 5Hz
Proof pressure 8.0 kgf/cm 2
(58.2)
(47.0)
Ambient temperature -10℃ ~ 50℃
34.4
25.7
Duty cycle 100% ED
13
Electrical connection JPC plug connector 6-G1/4 21.5 21.5
Protection class Dust proof 60
Installation Free direction
Voltage tolerance ±10% Number of station (N) 2 3 4 5 6 7 8 9 10
Standard voltage(power) 12VDC, 24VDC(0.8W with LED) L1 60 76 92 108 124 140 156 172 188
Net weight 72g 93g L2 40 56 72 88 104 120 136 152 168
2-4 Shako Co., Ltd. www.shako.com.tw Shako Co., Ltd. www.shako.com.tw 2-5
3/2 WAY MINIATURE DIRECT
SOLENOID VALVE ISO-9001
QUALITY CERTIFIED
Features
*Miniature and compact size, quick response,
lubricant free.
*Plug with standard JPC design (with LED).
*Built-in surge protection and nonpolarity
SOLENOID VALVES
SOLENOID VALVES
VM320 9 VM302M M5 02
3/2 way Voltage 3/2 way Port size Stations
7 12VDC 02 2 stations
9 24VDC 03 3 stations
XX XX stations
Specifications Dimensions
Dust proof 10
Protection class
Voltage tolerance ±10%
Standard voltage(power) 12VDC, 24VDC VM320M
Net weight 10g
L2 2-φ3.5
cross hole
38.3
N-M5xP0.8
w
ww
26.8
Depth=5
.t
w
13
.s
Number
m
5
of station 2 3 4 5 6 7 8 9 10
(N)
hako.co
7.7
2-6 Shako Co., Ltd. www.shako.com.tw Shako Co., Ltd. www.shako.com.tw 2-7
M5, 5/2 WAY PILOT SOLENOID VALVE PU521 series
15mm width ISO-9001
QUALITY CERTIFIED
15.0
15.0
Features Dimensions
11.0
11.0
FRL COMBINATIONS
FRL COMBINATIONS
2-φ2.6 2-φ2.6
6.0
*Miniature and Compact size, PU521A-M5-S PU521B-M5-S
15mm width, large flow rate (0.25Cv). 11.0
19.0 19.0
*Manual override design for
easy test and operation. 2-φ3.2
60.8
*Anodized aluminum body and
4.0
24.0
strict quality control provide a long durability.
11.0 21 56.5
*Quick acting, low starting pressure.
75.5 75.5
106.8 106.8
7.0
21.6 5-M5xP0.8 11.0
21.6
15.0
11.0
15.0
11.0
2-φ2.6 2-φ2.6
6.0
PU521 A F M5 S 2 D LED
11.0
15mm Valve type Voltage Coil type 19.0
Manifold Port size Solenoid LED 19.0
valves series
2-φ3.2
A Body Blank Standard (W/O manifold) M5 M5 S Single solenoid 1 110VAC Blank Lead wire Blank
5/2 way ported
60.8
F01 W/I single sub base (B type) D Double solenoid 2 220VAC D DIN (W/O LED)
4.0
Base
B 2 stations manifold (B type)
mounted F02 9 24VDC
Fxx xx stations manifold (B type) 11.0
M02 2 stations manifold (A type) How to order manifold 60.0 60.0
xx stations manifold (A type) 98.0 98.0
Mxx
A M5 02
160.6 160.6
MF521
7.0
15mm Manifold type Stations
valves series
A For body ported valve 02 2 stations 5-M5xP0.8 11.0
5/2 way 21.6 21.6
Specifications B For base mounted valve 03 3 stations
XX XX stations MF521A-M504 4-φ4.5 MF521B-M502
Model PU521A-M5-S(D) PU521B-M5-S(D) 60.5 4-φ4.5
L1=(N-1)x17+30
L2=(N-1)x17+42
PU521A-M5-D
L2=(N-1)x17+42
Port size M5 Flow chart
L1=(N-1)x17+30
PU521A-M5-S
Body material Aluminum alloy
Model: PU521A-M5-S(D)
Fluid Compressed air
6
Pressure (kgf/cm2)
1
Sectional area 3.5mm 2 0 2N-G 1/8
0 100 200 300 400 500 600
14.2
Cycle rate 120 cpm
14.2
56.0
Flow (l/min) R P R
B B
8.4
43.0
6-G 1/8 A A
Duty cycle 100% ED Model: PU521B-M5-S(D) 17.0 17.0
7.3
Coil type Lead wire(Standard), DIN(Option) 6 34.0 16.0
2-16.5
Pressure (kgf/cm2)
5 16.75
Protection class IP65(DIN 40 050) 4 50.0 6-G 1/8 L2=(N-1)x17+42
Insulation class F 3
2
Voltage tolerance ±10% 1
Number of station (N) 2 3 4 5 6 7 8 9 10
Standard voltage 220VAC, 110VAC, 24VDC (The other voltage is optional) 0
0 100 200 300 400 500 600 L1 47.0 64.0 81.0 98.0 115.0 132.0 149.0 166.0 183.0
Net weight 96g 106g Flow (l/min) L2 59.0 76.0 93.0 110.0 127.0 144.0 161.0 178.0 195.0
2-8 Shako Co., Ltd. www.shako.com.tw Shako Co., Ltd. www.shako.com.tw 2-9
5/2, 5/3 WAY PILOT SOLENOID VALVE AM520 series
18mm width ISO-9001
QUALITY CERTIFIED
Features Dimensions
*Medium and compact size, AM520-01-S AM520-01-D AM530(X)(Y)-01-D
18mm width solenoid valve.
*Manual override design
for easy test and operation. 2-6.0 2-φ3.2 2-6.0 2-φ3.2 2-6.0 2-φ3.2
SOLENOID VALVES
SOLENOID VALVES
2.6 12.8
2.6 12.8
2.6 12.8
and strict quality control 30.0 30.0 30.0
18.0
18.0
18.0
provide a long durability. 98.5 138.0 150.0
*Coil nut is available, please refer
16.0 5-G 1/8 16.0 5-G 1/8 16.0 5-G 1/8
to page 7-5. 2-φ3.2 2-φ3.2 2-φ3.2
34.5
34.5
34.5
3.5
27.0
14.0 14.0 14.0
3.5
3.5
15.5 28.0 55.0 28.0 61.0 28.0
How to order
AM520 B X 01 N S 2 D LED AM520B-01-S AM520B-01-D AM530(X)(Y)B-01-D
18mm Valve type Acting style Port size Thread Solenoid Voltage Coil type LED
valves series
12.8
12.8
12.8
2-6.0 2-φ3.2 2-6.0 2-φ3.2 2-6.0 2-φ3.2
Body Blank Standard 01 1/8" Blank G S Single solenoid 1 110VAC Blank Lead wire Blank
52 5/2 way Blank ported
(W/O LED)
18.0
18.0
18.0
X Exhaust center N NPT D Double solenoid 2 220VAC D DIN
53 5/3 way Base
B Y Pressurized center R Rc 9 24VDC 30.0 30.0 30.0
mounted
2.6
2.6
2.6
98.5 138.0 150.0
How to order manifold How to order manifold (B type)
MF520 01 N 02 SF520 01 N 02
34.5
34.5
34.5
18mm Port size Thread Stations 18mm Port size Thread Stations
valves series valves series 5-φ3.2 5-φ3.2
5-φ3.2
01 1/8" Blank G 02 2 stations 01 1/8" Blank G 02 2 stations
7.4
7.4
For body
7.4
For base
ported valve N NPT 03 3 stations mounted valve N NPT 03 3 stations 14.0 14.0
14.0
R Rc XX XX stations XX XX stations 28.0 28.0
15.5 28.0
Port size 5
L2=(N-1)x19+46
L1=(N-1)x19+34
4 L1=(N-1)x19+30
Body material Aluminum alloy 3
2
SA520-01S SA520-01D SA530-01D 25.0
Fluid Compressed air 1
0 13.2
0 100 200 300 400 500 600
Acting Internal pilot Flow (l/min) 4-φ4.3 9.0
43.0
30.0
58.0
40.6
Operating pressure range 1.5~8 kgf/cm 2 2~7 kgf/cm 2 6
Pressure (kgf/cm2)
13.4
4
20.0
3
2N-G 1/8
Ambient temperature -10℃ ~ 50℃ 2
B
31.8
1
12.8 6-G 1/4
Duty cycle 100% ED
0
0 100 200 300 400 500 600 A 6-G 1/8
Flow (l/min)
17.6
Coil type Lead wire (Standard), DIN (Option) 17.3 16 34
Model: AM530-01D AM520-01S AM520-01D AM530-01D 28.7 19 19 60.5
Protection class IP65 (DIN 40 050) 7
Pressure (kgf/cm2)
6
Insulation class F 5
Number
4 Number
Voltage tolerance ±10% 3
of station
(N)
2 3 4 5 6 7 8 9 10 of station
(N)
2 3 4 5 6 7 8 9 10
2
2-10 Shako Co., Ltd. www.shako.com.tw Shako Co., Ltd. www.shako.com.tw 2-11
5/2, 5/3 WAY PILOT SOLENOID VALVE SM520 series
18mm width ISO-9001
QUALITY CERTIFIED
Features Dimensions
*Medium and compact size, SM520-01-S SM520-01-D
18mm width solenoid valve.
*Manual override design
for easy test and operation. 2-φ3.2 2-6.0
SOLENOID VALVES
SOLENOID VALVES
13.0
*Anodized aluminum body
3.0
and strict quality control provide a long durability.
18.0
*The mounting position is
2.5
identical to the counter product from SMC. 17.0
*Coil nut is available, please refer to page 7-5. 26.0 35.0 35.0 26.0
102.5 142.0
How to order
SM520 X 01 N S 2 D LED
2-φ3.2 5-G 1/8 2-φ3.2 5-G 1/8
18mm Acting style Port size Thread Solenoid Voltage Coil type LED
valves series
6.5
34.5
27.0
6.5
34.5
Blank Standard 01 1/8" Blank G S Single solenoid 1 110VAC BlankLead wire Blank
52 5/2 way
5/3 way N NPT D Double solenoid 2 220VAC D DIN (W/O LED)
53 5/3 way
X Exhaust center R Rc 9 24VDC 27.2 27.2
Y Pressurized center 41.5 10.7 41.5 50.25
102.5 142.0
How to order manifold
MF52S 01 N 03
SM530(X)(Y)-01-D MF52S-0103
Model number Port size Thread Stations
5
Specifications 4
1/8"
0
Port size 0 100 200 300 400 500 600
Flow (l/min)
Body material Aluminum alloy
Fluid Compressed air Model: SM520B-01S 5-G 1/8
Acting Internal pilot 6
Pressure (kgf/cm2)
3
Operating pressure range 1.5~8 kgf/cm 2 2~7 kgf/cm 2 2
6-G 1/4
Proof pressure 9.9 kgf/cm 2 1
0
0 100 200 300 400 500 600
Ambient temperature -10℃ ~ 50℃ Flow (l/min)
Duty cycle 100% ED
Coil type Lead wire (Standard), DIN (Option) Model: SM530-01D
7
Protection class IP65 (DIN 40 050)
Pressure (kgf/cm2)
6
5
Insulation class F 4
Number of station
Voltage tolerance ±10%
3
2 (N) 2 3 4 5 6 7 8 9 10
1
2-12 Shako Co., Ltd. www.shako.com.tw Shako Co., Ltd. www.shako.com.tw 2-13
5/2, 5/3 WAY PILOT SOLENOID VALVE BM520 series
22mm width ISO-9001
QUALITY CERTIFIED
Features Dimensions
FRL COMBINATIONS
FRL COMBINATIONS
17.0
17.0
2-6.0 2-φ3.2 2-6.0 2-φ3.2
*Anodized aluminum body and strict
22.0
22.0
quality control provide a long
2.5
durability.
2.5
38.0 38.0
66.0
66.0
35.0
7.0
BM520 X 02 N S 2 LED E1
BM series Acting style Port size Thread Solenoid Voltage LED Coil type 20.0 20.0
2-G 1/8 2-G 1/8
520 5/2 way Blank Standard 02 1/4" Blank G S Single solenoid 1 110VAC Blank Blank DIN 36.0 36.0 66.7
2-φ4.3 2-φ4.3
530 5/3 way X Exhaust center N NPT D Double solenoid 2 220VAC (W/O LED) F Lead wire
Y Pressurized center R Rc 9 24VDC E1 EX-proof 22mm width 130.0 197.0
E2 EX-proof 30mm width
E3 EX-proof CSA standard
How to order manifold * Please refer to page P7-8 for the details of ex-proof coil.
BM530(X)(Y)-02-D MFB520-0206
MFB520 02 N 02
22mm Port size Thread Stations
valves series Flow chart
1/4" Blank G 02 2 stations
N NPT 03 3 stations Model: BM520-02-S
R Rc XX XX stations
Pressure (kgf/cm2)
Specifications 6
5
4
7 3-G 1/4
Sectional area 18mm 2 14mm 2 6
5
6-G 1/4
4
Operating pressure range 1.5~8 kgf/cm 2 2~8 kgf/cm 2 3
2
Proof pressure 9.9 kgf/cm 2
1
0
20 30 40 60 80 1000 1200 1400
Ambient temperature -10℃ ~ 50℃ Flow (l/min) 2-G 1/8
Duty cycle 100% ED
Coil type DIN (Standard) Model: BM530-02-D
7
Protection class IP65 (DIN 40 050)
Pressure (kgf/cm2)
6
5
Insulation class F 4
Number of station
Voltage tolerance ±10%
3
2 (N) 2 3 4 5 6 7 8 9 10
1
2-14 Shako Co., Ltd. www.shako.com.tw Shako Co., Ltd. www.shako.com.tw 2-15
5/2, 5/3 WAY PU520 series
PU SERIES PILOT SOLENOID VALVE ISO-9001
QUALITY CERTIFIED
Features Flow chart
*Medium size and large flow rate. Model: PU520-02-S Model: PU520-02-D Model: PU530-02-D
*Lockable manual override for 6
Pressure (kgf/cm2)
Pressure (kgf/cm2)
Pressure (kgf/cm2)
7 7 5
easy operation. 6 6
4
5 5
*Aluminum body with surface 4 4 3
SOLENOID VALVES
SOLENOID VALVES
3 3 2
anodizing treatment and 2 2 1
1 1 0
strict quality control for long 0 200 300 400 600 800 1000 1200 1400 0 200 300 400 600 800 1000 1200 1400 0 100 200 300 400 500 600 700 800
durability. Flow (l/min) Flow (l/min) Flow (l/min)
*Coil nut is available, please refer to page 7-4.
*Ex-proof coil is available, please refer to page 7-8.
Model: PU520-03-S Model: PU520-03-D Model: PU530-03-D
6 6 6
Pressure (kgf/cm2)
Pressure (kgf/cm2)
Pressure (kgf/cm2)
5 5 5
4 4 4
3 3 3
How to order 2 2 2
1 1 1
PU520 X 02 N S 2 LED E1 0
0 500 1000 1500 2000
0
0 500 1000 1500 2000
0
0 500 1000 1500 2000
Acting style Voltage Coil type Flow (l/min) Flow (l/min) Flow (l/min)
PU series Port size Thread Solenoid LED
520 5/2 way Blank Standard 02 1/4" Blank G S Single solenoid 1 110VAC Blank Blank DIN
530 5/3 way 5/3 way 03 3/8" N NPT D Double solenoid 2 220VAC (W/O LED) F Lead wire
Model: PU520-04-S Model: PU520-04-D Model: PU530-04-D
X Exhaust center 04 1/2" R Rc 5/3 way valve is only 9 24VDC E1 EX-proof 22mm width
4.5 4.5 4.5
Y Pressurized center available for double E2 EX-proof 30mm width
Pressure (kgf/cm2)
4
Pressure (kgf/cm2)
Pressure (kgf/cm2)
4 4
solenoid E3 EX-proof CSA standard 3.5 3.5 3.5
3 3 3
2.5 2.5 2.5
* Please refer to page P7-8 for the details of ex-proof coil. 2
How to order manifold 2
1.5
2
1.5 1.5
1
1 1
0.5 0.5 0.5
N 02
0
MF520 02
0 0 0 500 1000 1500 2000 2500 3000
0 500 1000 1500 2000 2500 3000 3500 0 500 1000 1500 2000 2500 3000 3500
Flow (l/min) Flow (l/min) Flow (l/min)
22.7
2-7.0 2-φ4.3 2-7.0 2φ
-4.3 2-7.0
Body material Aluminum alloy
34.0
30.0
22.7
1
19.0
26.0
Fluid Compressed air
0
Sectional area 18mm 2 2 35mm 2 32mm 2 70mm 2 54mm 2
14mm
4.0
10.0 13.4 16.0
3.6
3.5
Acting Internal pilot 130.0 158.0 204.5
Operating pressure range 1.5~8 kgf/cm2 2~8 kgf/cm2 1.5~8 kgf/cm2 2~8 kgf/cm2
Proof pressure 9.9 kgf/cm 2
71.5
73.5
46.0
Protection class IP65 (DIN 40 050)
35.0
4.5
4.0
50.0
Insulation class F
Voltage tolerance ±10% 2-G 1/8 21.0 26.0 36.0
6.0
Standard voltage 220VAC, 110VAC, 24VDC (The other voltage is optional) 2-φ4.3 37.0 13.0 2-φ4.3 52.0 19.0 2-φ4.3 71.5 30.7
Net weight 270g / 335g 475g 430g / 525g 715g 665g / 770g 1045g 130.0 158.0 204.5
2-16 Shako Co., Ltd. www.shako.com.tw Shako Co., Ltd. www.shako.com.tw 2-17
5/2, 5/3 WAY PU520 series
PU SERIES PILOT SOLENOID VALVE ISO-9001
QUALITY CERTIFIED
Dimensions Dimensions
PU520-02-D PU520-03-D PU520-04-D MF520-0206
L2=(N-1)x27.0+54.0
L1=(N-1)x27.0+40.0
22.7
26.0
19.0
2-7.0 2-φ4.3 2-7.0 2-φ4.3 2-7.0 2-φ4.3 SK530-01D/02D
Number
SOLENOID VALVES
SOLENOID VALVES
SK520-01D/02D
L1 L2
34.0
30.0
26.0
of station (N)
1
1
SK520-01S/02S
0
0
SK320-01S/02S
10.0 13.4 16.0 25.7 2 67.0 81.0
4.0
3.7
3.5
4-φ4.3 13.7
197.0 226.0 275.5 3 94.0 108.0
4 121.0 135.0
22.0
43
60
3-G 1/4 5-G 3/8 5-G 1/2
5 148.0 162.0
23.0 30.0 42.0
10.0
6 175.0 189.0
66.0
71.5
73.5
6.0
4.5
4.0
19.0
6-G 1/4 7 202.0 216.0
2-G 1/8 21.0 26.0 36.0 8 229.0 243.0
2-φ4.3 37.0 66.0 2-φ4.3 52.0 73.5 2-φ4.3 71.5 88.5 9 256.0 270.0
PU520-02S PU520-02D PU530-02D
197.0 226.0 275.5 10 283.0 297.0
MF520-0306
PU530(X)(Y)-02D PU530(X)(Y)-03D PU530(X)(Y)-04D L2=(N-1)x31.0+62.0
L1=(N-1)x31.0+46.0
SK530-03D
Number
26.0
34.0
26.0
30.0
22.7
SK520-03D
19.0
0
11.5 2 77.0 93.0
0
1
4-φ4.3
10.0 13.4 16.0 3 108.0 124.0
3.5
3.7
4.0
13.4
216.0 249.0 284.5 4 139.0 155.0
27.0
52
80
5 170.0 186.0
3-G 1/4 5-G 3/8 5-G 1/2
23.0 30.0 42.0 6 201.0 217.0
66.0
7
71.5
232.0 248.0
73.5
4.0
6-G 3/8
22.7 8 263.0 279.0
2-G 1/8 21.0 26.0 36.0 9 294.0 310.0
6.0
4.5
2-φ4.3 37.0 85.0 2-φ4.3 52.0 94.8 2-φ4.3 71.5 124.5 PU520-03S PU520-03D PU530-03D
10 325.0 341.0
216.0 249.0 284.5
MF520-0407
L2=(N-1)x35.0+70.0
Explosion L1=(N-1)x35.0+50.2
35
Coil nut SK530-04D Number
SK520-04D of station (N) L1 L2
15.5
SK520-04S
Seal 0
1
Connector
5 190.2 210.0
105.0
Armature
30.0
125
Piston base
68
Spool 6 225.2 245.0
7 260.2 280.0
8 295.2 315.0
Aluminum body
1 0 1 0
0 1 0
9 330.2 350.0
26.0
Piston base PU530-04D
10 365.2 385.0
Coil Nut Coil PU520-04S PU520-04D
2-18 Shako Co., Ltd. www.shako.com.tw Shako Co., Ltd. www.shako.com.tw 2-19
5/2 WAY 5/2, 5/3 WAY
EXTERNAL PILOT SOLENOID VALVE "SANDWITCH" SHUT-OFF BLOCK
Features Features
*Medium size, 26mm width, large flow rate.
*Lockable manual override for easy *The shut-off block allows a
operation. valve to be removed without
*Anodized aluminum body and strict
quality control provide a long durability. switching off other solenoid
SOLENOID VALVES
SOLENOID VALVES
PU520 A 02 N S 2 LED E1
PU 26mm Acting Port size Thread Solenoid Voltage LED Coil type
width series
A Front pilot 02 1/4" Blank G S Single solenoid 1 110VAC Blank Blank DIN
5/2 way AB Front & Rear pilot N NPT D Double solenoid 2 220VAC (W/O LED) F Lead wire How to order
R Rc 9 24VDC E1 EX-proof 22mm width
SOB52 02
E2 EX-proof 30mm width
* Please refer to page P7-8 for the details of ex-proof coil. E3 EX-proof CSA standard
Connector
Dimensions
Screws
Shut-off block Port size
PU520A-02-S PU520AB-02-S *5/2 way external pilot solenoid valve
M5.0xP0.8xL7.0 2-7.0 2-φ4.3 2-M5.0xP0.8xL7.0 2-7.0 2-φ4.3 Pilot specifications: 1.Front pilot 02 1/4" Aluminum body
2.Rear pilot M5 M5 Coil
Orifice: M5
26.0
26.0
1
10.0 10.0 Inlet pilot at least 1kg higher than Piston base
19.0
19.0
3.5
3.5
137.0 140.3
external pilot pressure. Installation Spring
Piston
23.0 3-G 1/4 23.0 3-G 1/4
End plate
66.0
66.0
Front pilot
Spool Screws
4.0
35.0
4.0
35.0
Rear pilot
2-G1/8 21.0 2-G 1/8 21.0
2-φ4.3 37.0 13.0 2-φ4.3 37.0 16.6 Exhaust port
137.0 140.3
Shut-off block
Shut-off block
Supply port
Specifications Exhaust port Gasket
2-20 Shako Co., Ltd. www.shako.com.tw Shako Co., Ltd. www.shako.com.tw 2-21
5/2 WAY SUS316 SERIES PILOT SPU520 series
SOLENOID VALVE ISO-9001
QUALITY CERTIFIED
SUS316 stainless steel body
Features Dimensions
*Stainless steel SUS316 SPU520-02, 03, 04S SPU520-02, 03, 04D
body for corrosion resistance.
*Coil nut is available, please refer
72.0 72.0
to page 7-4.
SOLENOID VALVES
SOLENOID VALVES
30.0 30.0
*Ex-proof coil is available, please
refer to page 7-8.
23.0
23.0
30.0
30.0
5.0
5.0
3.5
3.5
171.0 155.0
3-P.A.B 3-P.A.B
How to order
70.0
70.0
SPU520 04 N S 1 LED E1
46.0
46.0
SUS316 series Port size Thread Solenoid Voltage LED Coil type
2-R 29.0 2-R 29.0
7.0
7.0
5/2 way 02 1/4" Blank G S Single solenoid Blank Blank DIN
1 110VAC
(W/O LED) 2φ
-4.5 58.0 21.5 2φ
-4.5 58.0 91.5
03 3/8" N NPT D Double solenoid F Lead wire
2 220VAC
04 1/2" E1 EX-proof 22mm width
9 24VDC 171.0 240.5
E2 EX-proof 30mm width
* Please refer to page P7-8 for the details of ex-proof coil.
Flow chart E3 EX-proof CSA standard
Model: SPU520-02, 03, 04S Model: SPU520-02, 03, 04D Model A B P R
4.0 4.0
Pressure (kgf/cm2)
Pressure (kgf/cm2)
3.5
3.0
3.5
3.0
SPU520-02 1/4 1/4 1/4 1/4
2.5
2.0
2.5
2.0 SPU520-03 3/8 3/8 3/8 3/8
1.5 1.5
1.0
0.5
1.0
0.5
SPU520-04 1/2 1/2 1/2 3/8
0.0 0.0
0 500 1000 1500 2000 2500 3000 3500 0 500 1000 1500 2000 2500 3000 3500
2-22 Shako Co., Ltd. www.shako.com.tw Shako Co., Ltd. www.shako.com.tw 2-23
ISO SERIES SOLENOID VALVES PS520F series
ISO-9001
QUALITY CERTIFIED
Features Dimensions
*ISO 1, ISO 2 solenoid PS520F-02-S PS520F-02-D
valve.
(120) (175)
*Aluminum alloy body. 83.4 99.0
*With single sub base 36.0 36.0
SOLENOID VALVES
SOLENOID VALVES
which is identical to
28.0
35.0
28.0
35.0
ISO 1 & ISO 2 standard.
*Coil nut is available, please refer 4-φ5.2 4-φ5.2
18.0 18.0
to page 7-4.
*Ex-proof coil is available, please
(95.0)
refer to page 7-8.
(95.0)
26.0
26.0
How to order
PS520 F 02 N S 2 LED E1
PS520 series Sub Base Port size Thread Solenoid Voltage LED Coil type PS520F-03-S PS520F-03-D
5/2 way Blank W/O base 02 1/4" ISO 1 Blank G S Single solenoid 1 110VAC Blank Blank DIN (165) (216.3)
F W/I base 03 3/8" ISO 2 N NPT D Double solenoid 2 220VAC (W/O LED) F Lead wire 129.0 145.0
04 1/2" ISO 2 R Rc 9 24VDC E1 EX-proof 22mm width 48.0 48.0
E2 EX-proof 30mm width
* Please refer to page P7-8 for the details of ex-proof coil. E3 EX-proof CSA standard
How to order sub base
38.0
50.0
50.0
38.0
ZESF 02
24.0 4-φ6.4 24.0 4-φ6.4
PS520 series Port size
02 1/4" ISO 1
03 3/8" ISO 2
04 1/2" ISO 2
(100)
(100)
Specifications
34.0
34.0
Model PS520-02-S PS520-02-D PS520-03(4)-S PS520-03(4)-D
Port size 1/4" 3/8" (1/2") ZESF-02 ZESF-03,04
Body material Aluminum alloy 124.0
Sectional area 29mm 2 62mm 2 109.5 112.0
98.0 94.0 2-φ5.5
Fluid Compressed air 84.0 2-φ5.5 48.0
36.0
Acting Internal pilot
Operating pressure range 1.5 ~ 8 kgf/cm 2
56.0
38.0
46.0
28.0
Proof pressure 9.99 kgf/cm 2
Ambient temperature -10℃ ~ 60℃
Duty cycle 100% ED 18.0 24.0
4-M5XP0.8X12dp 4-M6XP1.0X12.5dp
Coil type DIN
Protection class IP65 (DIN 40 050)
10.5
5-G 1/4
14.5
43.0 56.0 5-G 3/8, 5-G 1/2
Insulation class F
19.5
22.5
R P R
Voltage tolerance ±10% R P R
30.0
36.0
10
Standard voltage 220VAC, 110VAC, 24VDC (The other voltage is optional)
13
B 24.0 A
Net weight (W/I base) 320g (500g) 460g (640g) 700g (980g) 840g (1120g) B 30.0 A
2-24 Shako Co., Ltd. www.shako.com.tw Shako Co., Ltd. www.shako.com.tw 2-25
3/2 WAY PILOT SOLENOID VALVE PU322 series
ISO-9001
QUALITY CERTIFIED
Features Dimensions
*Medium size, large flow rate. PU322-02-S PU322N-02-S
*Lockable manual override for
easy operation. 2-7.0 2-φ4.3 2-7.0 2-φ4.3
SOLENOID VALVES
SOLENOID VALVES
26.0
19.0
26.0
strict quality control provide a
10.0 10.0
19.0
3.5
3.5
long durability. 130.0 130.0
*Coil nut is available, please refer
to page 7-4. 2-G 1/4 2-G 1/4
G 1/8
*Ex-proof coil is available, please
4.0
35.0
4.0
35.0
refer to page 7-8.
N N
130.0 130.0
PU322 02 S 2 LED E1
PU series Acting style Port size Thread Solenoid Voltage LED Coil type
3/2 way Blank Normally closed 02 1/4" Blank G S Single solenoid 1 110VAC Blank Blank DIN PU322-03-S PU322N-03-S
Pilot acting N Normally open 03 3/8" N NPT 2 220VAC (W/O LED) F Lead wire
04 1/2" R Rc 9 24VDC E1 EX-proof 22mm width
2-7.0 2-φ4.3 2-7.0 2-φ4.3
E2 EX-proof 30mm width
E3 EX-proof CSA standard
22.7
30.0
22.7
30.0
Specifications * Please refer to page P7-8 for the details of ex-proof coil.
13.4 13.4
3.7
3.7
158.0 158.0
Model PU322(N)-02-S PU322(N)-03-S PU322(N)-04-S
Port size 1/4" 3/8" 1/2" 3-G 3/8
3-G 3/8
Body material Aluminum alloy
Fluid Compressed air
46.0
46.0
4.5
4.5
Sectional area 18mm 2 35mm 2 70mm 2
Acting Internal pilot 26.0 26.0
2-φ4.3 26.0 45.0 2-φ4.3 26.0 19.0
Operating pressure range 2 ~ 8 kgf/cm 2
158.0 158.0
Proof pressure 9.9 kgf/cm 2
Ambient temperature -10℃ ~ 50℃
Duty cycle 100% ED PU322-04-S PU322N-04-S
Coil type DIN (Standard)
2-7.0 2-φ4.3 2-7.0 2-φ4.3
Protection class IP65 (DIN 40 050)
30.0
30.0
Insulation class F
34.0
34.0
1
1
0
0
Voltage tolerance ±10%
16.0 16.0
4.0
4.0
Standard voltage 220VAC, 110VAC, 24VDC (The other voltage is optional) 204.5 204.5
Net weight 280g 450g 685g
3-G 1/2 3-G 1/2
Flow chart
73.5
73.5
50.0
50.0
6.0
Model: PU322-02-S Model: PU322-03-S Model: PU322-04-S
6.0
6 4.5
Pressure (kgf/cm2)
Pressure (kgf/cm2)
Pressure(kgf/cm2)
7 4.0
5 3.5
6
4 3.0
5 2.5 36.0 36.0
4 3 2.0
3 2 1.5 2-φ4.3 35.75 66.45 2-φ4.3 35.75 30.7
2 1.0
1 0.5
1
0 200 300 00 0.0
204.5 204.5
400 600 800 1000 1200 1400 500 1000 1500 2000 0 500 1000 1500 2000 2500 3000 3500
Flow (l/min) Flow (l/min) Flow (l/min)
2-26 Shako Co., Ltd. www.shako.com.tw Shako Co., Ltd. www.shako.com.tw 2-27
5/2, 5/3 WAY PILOT SOLENOID VALVE BW520 series
ISO-9001
QUALITY CERTIFIED
Features Dimensions
FRL COMBINATIONS
FRL COMBINATIONS
18.0
18.0
*Anodized aluminum body with special
12.8
12.8
machining inner slot, low friction, strict quality
control provides a long durability. 2-6.0 2-6.0
34.5
34.5
27.0
24.0
24.0
How to order
X 02 N S 2 LED E1
3.5
3.5
BW520 2-φ3.2 14.0 22.5 2-φ3.2 14.0 62.5
cross hole cross hole
28.0 15.5 28.0 55.0
BW series Acting style Port size Thread Solenoid Voltage LED Coil type
(98.5) (138.5)
520 5/2 way Blank Standard 01 1/8" Blank G S Single solenoid 1 110VAC Blank For 1/8"
530 5/3 way X Exhaust center 02 1/4" N NPT D Double solenoid 2 220VAC (W/O LED) Blank Lead wire
Y Pressurized center 03 3/8" R Rc 9 24VDC D DIN
BW520M 02 N 02
E1 EX-proof 22mm width BW530(X)(Y)-01-D BM520M-0106
E2 EX-proof 30mm width
E3 EX-proof CSA standard
BW series Port size Thread Stations
* Please refer to page P7-8 for the details of ex-proof coil.
01 1/8" Blank G 02 2 stations L2=(N-1)x19+42
02 1/4" N NPT 03 3 stations
30.0 2-φ3.2
R Rc XX XX stations cross hole L1=(N-1)x19+30
18.0
12.8
Specifications
25.0
Model BW520-01-S(D) BW530-01-D BW520-02-S(D) BW530-02-D BW520-03S(D) BW530-03-D 2-6.0
13.2
Port size 1/8" 1/4" 3/8" 4-φ4.3 9.0
43.0
30.0
58.0
40.6
Fluid Compressed air 5-1/8" 16.0
Sectional area 12mm 2 9mm 2 16mm 2 12mm 2 30mm 2 18mm 2
34.5
Acting Internal pilot
20.0
24.0
Operating pressure range 1.5~8 kgf/cm2 6-G 1/4
3.5
Proof pressure 9.9 kgf/cm 2 2-φ3.2 14.0 74.0 12.8
Ambient temperature -10℃ ~ 60℃ cross hole
28.0 67.0
Duty cycle 100% ED (150.0) BW520-01-S x 4pcs BW520-01-D BW530-01-D
Coil type DIN (Standard)
Protection class IP65 (DIN 40 050)
Insulation class F Number of
station (N) 2 3 4 5 6 7 8 9 10
Voltage tolerance ±10%
Standard voltage 220VAC, 110VAC, 24VDC (The other voltage is optional) L1 49 68 87 106 125 144 163 181 201
Net weight 125g(195g) 215g 235g(335g) 445g 410g(500g) 700g L2 61 80 99 118 137 156 175 194 213
2-28 Shako Co., Ltd. www.shako.com.tw Shako Co., Ltd. www.shako.com.tw 2-29
5/2, 5/3 WAY PILOT SOLENOID VALVE BW520 series
ISO-9001
QUALITY CERTIFIED
Dimensions Dimensions
FRL COMBINATIONS
FRL COMBINATIONS
27.0
22.0
20.0
22.0
17.0
17.0
38.0 38.0
50.0
66.0
2-φ4.3
35.0
24.0 3-3/8"
7.0
32.0
32.0
7.0
cross hole
(85.0)
2-1/8" 20.0 21.4 2-1/8" 20.0 88.5
40.0
36.0
36.0 13.4 36.0 80.5
6.5
(130.0) (197.0)
(165.0)
BW530(X)(Y)-02-D BW520M-0206
L2=(N-1)x23.0+46.0
38.0
4-φ4.3 25.7 2-φ3.2 2-7.5
13.7 cross hole
27.0
50.2
43.0
60.0
20.0
2-φ4.3 21.0 3-1/4"
cross hole
66.0
21.0
50.0
32.0
7.0
6-G 1/4
(85.0)
BW520-02-S x 4pcs BW520-02-D BW530-02-D
36.0
6.5
Number of
station (N) 2 3 4 5 6 7 8 9 10
2-1/4" 24.0 111.7
L1 57 80 103 126 149 172 195 218 241
45.0 101.2
L2 69 92 115 138 161 184 207 230 253
(247.5)
2-30 Shako Co., Ltd. www.shako.com.tw Shako Co., Ltd. www.shako.com.tw 2-31
3/2 WAY PILOT SOLENOID VALVE BW320 series
ISO-9001
QUALITY CERTIFIED
Features Dimensions
FRL COMBINATIONS
FRL COMBINATIONS
18.0
13.0
operation.
*Anodized aluminum body with special
2-6.0
machining inner slot, low friction, strict quality
19.0 15.0
control provides a long durability.
*Coil nut is available, please refer to page 7-5.
*Ex-proof coil is available, please refer to page 7-8.
3-1/8" 21.0 14.0 2-φ3.1
cross hole
7.7
(N)
A
(35.0)
How to order
24.0
27.0
BW320 N 02 N S 2 LED E1 R P
BW series Acting style Port size Thread Solenoid Voltage LED Coil type 16.0 16.5
320 3/2 way Blank Normally closed 01 1/8" Blank G S Single solenoid 1 110VAC Blank For 1/8" 60.3
Pilot acting N Normally open 02 1/4" N NPT D Double solenoid 2 220VAC (W/O LED) Blank Lead wire (88.0)
R Rc 9 24VDC D DIN
For 1/4"
Blank DIN
F Lead wire
EX-proof 22mm width
E1
EX-proof 30mm width
BW320(N)-02
E2
E3 EX-proof CSA standard
2-φ3.3 27.4
* Please refer to page P7-8 for the details of ex-proof coil. cross hole
22.0
17.0
Specifications
2-6.0
Model BW320(N)-01 BW320(N)-02 30.0 12.4
Port size 1/8" 1/4"
Body material Aluminum alloy
Fluid Compressed air
3-1/4"
Sectional area 12mm 2 16mm 2
(N)
Acting Internal pilot 25.0 14.9 2-φ4.2
8.2
cross hole
Operating pressure range 1.5~8 kgf/cm2
(66.0)
Proof pressure 9.9 kgf/cm 2 A
Ambient temperature -10℃ ~ 60℃
32.0
35.0
Duty cycle 100% ED
Coil type DIN (Standard) R P
Protection class IP65 (DIN 40 050)
22.5 16.15
Insulation class F
Voltage tolerance ±10% 72.2
Standard voltage 220VAC, 110VAC, 24VDC (The other voltage is optional) (120.0)
2-32 Shako Co., Ltd. www.shako.com.tw Shako Co., Ltd. www.shako.com.tw 2-33
5/2 PILOT SOLENOID VALVE 5/2&3/2WAY PILOT SOLENOID VALVE
NAMUR VALVE NAMUR VALVE
Features Features
*Medium size, 30mm width, *Big seceional area and flow rate.
*The switch gasket attached on the valves the
large flow rate. valve switching from 5/2 way to 3/2 way.
*Lockable manual override *The mounting holes on the valve is identical to
ISO standard for easy installation on the single
for easy operation.
or double acting actuator of ball valve.
SOLENOID VALVES
*Anodized aluminum body
SOLENOID VALVES
6
30.0
30.0
30
30
158.0
6
226.0
(158) (226)
32.0
OPEN 4 WAY
OPEN 3 WAY
OPEN 4 WAY
OPEN 3 WAY
32
46
32
3-G 1/4 49.0 20.5 49.0 74.7
7.0
7
158.0 226.0 49 49
Specifications Specifications
Model CY520-02-S CY520-02-D Model CY525-02-S CY525-02-D
Port size 1/4" Flow chart Port size 1/4" Flow chart
Body material Aluminum alloy Body material Aluminum alloy
Model: CY520-02-S Model: CY525-02-S
Fluid Compressed air 6
Fluid Compressed air 6
Pressure (kgf/cm2)
Pressure (kgf/cm2)
Pressure (kgf/cm2)
Pressure (kgf/cm2)
Protection class IP65 (DIN 40 050) 5 Protection class IP65 (DIN 40 050) 5
4 4
Insulation class F 3 Insulation class F 3
2-34 Shako Co., Ltd. www.shako.com.tw Shako Co., Ltd. www.shako.com.tw 2-35
3/2 WAY DIRECT SOLENOID VALVE 3/2 WAY DIRECT SOLENOID VALVE
Features Features
*3/2 way solenoid valve, direct *3/2 way solenoid valve.
acting for quick and sensitive The valve is easy to be stacked.
response. *To stack the valve, assembly
kit is necessary.
*Large flow rate.
*Assembly kit includes O-ring x 1,
*The valve is easy to be installed,
SOLENOID VALVES
SOLENOID VALVES
AM325 02 N S 2 LED E
PU valve
series
Acting style Number of stack Port size Thread Solenoid Voltage LED Coil type
Blank Normally closed Blank W/O stack 01 1/8" Blank G S Single solenoid 1 110VAC Blank Blank DIN
3/2 way
Port size Thread Voltage Coil type N Normally open M02 2 valves stack 02 1/4" N NPT 2 220VAC (W/O LED) F Lead wire
AM valve Solenoid LED
M03 3 valves stack R Rc 9 24VDC E1 EX-proof 22mm width
series Blank Mxx xx valves stack E2 EX-proof 30mm width
02 1/4" Blank G S Single solenoid 1 110VAC Blank DIN
(W/O LED) E3 EX-proof CSA standard
3/2 way 03 3/8" N NPT 2 220VAC E Ex-proof
Dimensions
Direct acting R Rc 9 24VDC
PU320-01-S/02-S PU320N-01-S/02-S G 1/8
Dimensions
17.0
M5
M5
AM325-02 AM325-03
2-G 1/4
(82.0)
(82.0)
2-G 1/4
2-G 1/8 2-G 1/8
90.0
96.0
2-G 1/4 2-M4.0xP0.7xL7.8
22.0
2-M4.0xP0.7xL7.8
22.0
12.75
2-M5-P0.8
10.8
2-G 3/8
8.1 8.1
25.0
19.0 19.0
5.0
5.0
23.0 23.0
26.0 26.0
15.0 22.5 33.0 33.0
31.8 37.0 9.25
(69.0) (69.0)
25.5 72.0
77.0 Specifications
Specifications
Model PU320(N)-01-S PU320(N)-02-S
Model AM325-02-S AM325-03-S Port size 1/8" 1/4" How to stack valve
Port size 1/4" 3/8" Flow chart
Body material Aluminum alloy
Body material Aluminum alloy
Model: AM325-02-S Sectional area 1.5mm 2
Fluid Compressed air 7 Fluid Compressed air
Pressure (kgf/cm2)
2-36 Shako Co., Ltd. www.shako.com.tw Shako Co., Ltd. www.shako.com.tw 2-37
5/2 WAY PILOT PNEUMATIC VALVE 5/2, 5/3 WAY PNEUMATIC VALVE
Namur valve 18mm width
Features Features
*Suitable for flammable working environments. *Suitable for flammable working
*The valve is actuated by air environments.
for accurate response. *The valve is actuated by air for
accurate response.
SOLENOID VALVES
SOLENOID VALVES
How to order
How to order Flow chart
SA520 X 01 N S
SY520 02 N S Flow chart Model: SA520-01S
SA pneumatic Acting style Port size Thread Pneumatic control 6
Pressure (kgf/cm2)
Model: SY520-02S valves series 5
SY pneumatic Port size Thread Pneumatic control Blank Standard 01 1/8" Blank G Single 4
Pressure (kgf/cm2)
02 1/4" Blank G S 7
5/3 way valve is only available Double
6 53 X Exhaust center R Rc 1
5/2 way N NPT D Double pneumatic 5
for double pneumatic control D pneumatic 00 100 200 300 400 500 600
Y Pressurized center
R Rc 4 Flow (l/min)
Specifications 3
2
1 Specifications Model: SA520-01D
Model SY520-02S SY520-02D 0 200 300 400 600 800 1000 1200 1400 6
Pressure (kgf/cm2)
Model SA520-01S SA520-01D SA530-01D
5
Fluid Compressed air Model: SY520-02D Body material Aluminum alloy 00 100 200 300 400 500 600
7
Fluid Compressed air
Acting External pilot (2 ~ 8 kgf/cm 2 ) 6 Model: SA530-01D
5
Acting External pilot (1.5 ~ 7 kgf/cm 2 ) 7
Pressure (kgf/cm2)
Operating pressure range 0 ~ 8 kgf/cm 2 4 6
5
3
Operating pressure range 0 ~ 8 kgf/cm 2 4
Proof pressure 9.99 kgf/cm 2 2
3
1 Proof pressure 9.99 kgf/cm 2 2
Ambient temperature -10℃ ~ 80℃ 0 200 300 400 600 800 1000 1200 1400 1
30.0
2-6.0 2-φ3.1
18.0
18.0
18.0
105.0 120.0 30.0 30.0
12.8
12.8
67.5 76.0 30.0
12.8
2φ
-19.0xL1.7 24.0 2φ
-5.5 2φ
-19.0xL1.7 24.0 2-φ5.5 88.0
16.0 5-G 1/8 16.0 5-G 1/8 16.0 5-G 1/8
G 1/8 2-G 1/8 G 1/8 2-G 1/8 2-G 1/8
32.0
46.0
27.0
32.0
46.0
27.0
27.0
13.5
13.5
13.5
14.0 14.0
3.5
14.0
3.5
3.5
3-G 1/4 49.0 20.5 3-G 1/4 49.0 35.5
7.0
2-38 Shako Co., Ltd. www.shako.com.tw Shako Co., Ltd. www.shako.com.tw 2-39
5/2, 5/3 WAY PNEUMATIC VALVE 3/2 WAY PNEUMATIC VALVE
22mm width 26/30/34mm width
Pressure (kgf/cm2)
7
6
*The valve is actuated by air for *The valve is actuated 5
4
3
accurate response. by air for accurate response.
SOLENOID VALVES
SOLENOID VALVES
2
1
*The mounting position is identical 0 200 300 400 600 800 1000 1200 1400
Model: SK320-03S
6
Pressure (kgf/cm2)
5
4
3
2
How to order 1
00
How to order 500 1000 1500 2000
Pressure (kgf/cm2)
4.0
Pressure (kgf/cm2)
Blank Standard 02 1/4” Blank G Single 7
6 32 3/2 way (N.C.) 02 1/4" N NPT
2.5
Net weight 135g 145g 220g Flow (l/min) Net weight 180g 375g 595g
Dimensions Dimensions
SB530(X)(Y)-02D
SB520-02S SB520-02D SK320-01S/02S SK320-03S SK320-04S
2-6.0 2-7.0 2-φ4.3 2-7.0 2-φ4.3 2-7.0 2-φ4.3
2-6.0 2-φ3.2 2-φ3.2
2-6 2-φ3.2
19.0
26.0
30.0
22.7
26.0
34.0
17.0
22.0
17.0
22.0
22
17
21.0 3-G 1/4 21.0 3-G 1/4 2-G 1/8 21 3/G 1/4 30.5 2-G 1/8, 2-G 1/4 45.0 3-G 3/8 55.5 3-G 1/2
G 1/8 2-G 1/8 G 1/8 G 1/8 G 1/8
35.0
35.0
7.0
35.0
4.0
7.0
50.0
46.0
6.0
35
4.5
17.5
17.5
17.5
25.0
23.0
17.5
2-40 Shako Co., Ltd. www.shako.com.tw Shako Co., Ltd. www.shako.com.tw 2-41
5/2, 5/3 WAY PNEUMATIC VALVE SK520 series
26/30/34mm width ISO-9001
QUALITY CERTIFIED
Features Dimensions
*Suitable for flammable working SK520-01S/02S SK520-01D/02D SK530(X)(Y)-01D/02D
environments. 2-7.0 2-φ4.3 2-7.0 2-φ4.3
*The valve is actuated by air for 2-7.0 2-φ4.3
19.0
26.0
19.0
26.0
accurate response.
SOLENOID VALVES
SOLENOID VALVES
19.0
26.0
10.0 10.0
73.5 84.0 10.0
103.0
35.0
35.0
35.0
4.0
4.0
4.0
17.5
17.5
How to order 21.0 21.0 21.0
2-G 1/8 2-G 1/8 2-G 1/8
2-φ4.3 37.0 13.0 2-φ4.3 37.0 23.5 2-φ4.3 37.0 42.5
SK520 X 01 N S 73.5 84.0 103.0
30.0
22.7
30.0
22.7
30.0
22.7
Specifications 13.4 13.4
105.0 120.0 13.4
Model SK520-01S(D) SK530-01D SK520-02S(D) SK530-02D SK520-03S(D) SK530-03D SK520-04S(D) SK530-04D 142.0
Port size 1/8" 1/4" 3/8" 1/2" G 1/8 30.0 5-G 3/8 2-G 1/8 30.0 5-G 3/8 30.0 5-G 3/8
2-G 1/8
Body material Aluminum alloy
Fluid Compressed air
46.0
46.0
46.0
4.5
4.5
4.5
23.0
23.0
23.0
Sectional area 18mm 2 14mm 2 18mm 2 14mm 2 35mm 2 32mm 2 70mm 2 54mm 2
Acting External pilot (1.5 ~ 7 kgf/cm 2 ) 26.0 26.0 26.0
2-φ4.3 2-φ4.3 2-φ4.3
Operating pressure range 0~8kgf/cm 2 0~7kgf/cm 2 0~8kgf/cm 2 0~7kgf/cm 2 0~8kgf/cm 2 0~7kgf/cm 2 0~8kgf/cm 2 0~7kgf/cm 2 52.0 19.0 52.0 34.0 52.0 56.0
Proof pressure 9.9 kgf/cm 2 105.0 120.0 142.0
26.0
34.0
26.0
34.0
6 4.5
26.0
34.0
6
Pressure (kgf/cm2)
Pressure (kgf/cm2)
Pressure (kgf/cm2)
Pressure (kgf/cm2)
5 7 5 4
6 3.5
4 4 3 16.0 16.0
5 2.5
3 4 3
2 16.0
2 3 2 1.5 143.0 153.0
2 1 1
1 0.5 175.5
1 0
00 0
100 200 300 400 500 600 0 200 300 400 600 800 1000 1200 1400 0 500 1000 1500 2000 0 500 1000 1500 2000 2500 3000 3500
Flow (l/min) Flow (l/min) Flow (l/min) Flow (l/min) G 1/8 42.0 5-G 1/2 2-G 1/8 42.0 5-G 1/2 2-G 1/8 42.0 5-G 1/2
50.0
50.0
50.0
6 6 4.5
6.0
6.0
6
6.0
Pressure (kgf/cm2)
Pressure (kgf/cm2)
Pressure (kgf/cm2)
Pressure (kgf/cm2)
4
25.0
25.0
5 5
25.0
5
3.5
4 4 4 3
3 3 3 2.5
2
2 2 2 1.5 36.0 36.0 36.0
1 1 1
1 0.5
00 0 0 0 2-φ4.3 71.5 30.75 2-φ4.3 71.5 40.75 2-φ4.3 71.5 63.25
100 200 300 400 500 600 0 100 200 300 400 500 600 700 800 0 500 1000 1500 2000 0 500 1000 1500 2000 2500 3000
143.0 153.0 175.5
Flow (l/min) Flow (l/min) Flow (l/min) Flow (l/min)
2-42 Shako Co., Ltd. www.shako.com.tw Shako Co., Ltd. www.shako.com.tw 2-43