Beruflich Dokumente
Kultur Dokumente
The most appropriate formation for a casing seat is
a. Fractured Limestone b. Fractured Dolomite d. Porous Sandstone e. Clean Shale
2. Shear mechanism of cutting formations requires that the formation exhibit a
a. High Compressive strength b. Low compressive strength
3. In formations where heavy to complete losses of circulation are expected the jet sizes should be
a. Very small b. Very large or open
4. What is the benefit of a center jet in a bit?
5. Resistance to flow in mud due to chemical reactions is called
a. Plastic Viscosity b. Yield Point c) Gel Strength
6. Annular velocity is generally considered across
a.BHA c.Drill Collars c.Drill Pipe
7. In Cement Bond Log if the MV records very high readings (40 to 50 Ohms) the quality of the cement
bond would be rated
a. Excellent b. Good c. Fair d. Poor e. Free Pipe
8. Name 5 mud properties which are taken at regular intervals at the drilling site. Give their units
a. Mud Density (Sp.Gr, PPG) b.Funnel Viscosity (sec) c. Filtrate or water loss (cc) d. Solids Content (%).
e.Chlorides (ppm)
9. A mast remains a single after manufacture and is relatively portable. True/False
10. A three joint of drill pipe is a) Double b) Single c) Triple or stand
11. Name 4 casing accessories
a.Shoe b. Float collar c. Stage Collar d. Centralizer
12. In designing a casing program the liner is run from the surface to the section’s total depth.
True/False
13. With a top drive the rotary table does not rotate. True/False
1