Beruflich Dokumente
Kultur Dokumente
TEACHER:……………………………………………………………………………………………………………………………….
MODULE:……………………………CODE:…………………….DATE:……/………/………TURN:………………………
1. Which of the following creates a flapping sound near the front of the engine?
a. Timing belt tension too tight
b. Drive belt too tight
c. Drive belt too loose
d. Timing belt tension too loose
2. An engine noise sounds like a knock at the side of the engine that is louder
when the engine is cold and goes away or is reduced when the engine reaches
operating temperature. Which of the following is the MOST likely cause?
a. Cam bearing
b. Main bearing
c. Piston slap
d. Wrist pin
3. This question is not like the others. It has the word EXCEPT. For this question,
look for the choice that could NOT cause the described situation. Read the entire
question carefully before choosing your answer.
All of the following are reasons why you must disable the fuel injection system
and ignition system when conducting an engine compression test, EXCEPT:
9. A technician hears a knock or thumping at the side of the engine block that is
louder when the engine is hot and goes away when the affected cylinder is
shorted out. Which of the following could be the cause?
a. Main bearing
b. Wrist pin
c. Rod bearing
d. Piston slap
10. An engine is making a knocking sound that changes with RPM, and the noise
disappears while a cylinder is being tested during the cylinder balance test.
Which of the following could be the cause?
a. Rod bearing
b. Main bearing
c. Piston Slap
d. Burnt valve
11. Technician A says old antifreeze may cause corrosion build-up in the cooling
system. Technician B says some original equipment manufacturers (OEM)
recommend that the coolant be changed at specified intervals. Who is right?
a. A only
b. B only
c. Both A and B
d. Neither A nor B
12. This question has the word LEAST. For this question, look for the choice that
would LEAST likely fit the described situation. Read the entire question carefully
before choosing your answer.
Which of the following steps is LEAST likely to be necessary when refilling a
cooling system?
a. Bleeding the air out of the system
b. Mixing tap water and distilled water
c. Mixing the proper ratio of water to coolant
d. Check the radiator cap for proper fit