Sie sind auf Seite 1von 1

POST MILES SHEET TOTAL

DIST COUNTY ROUTE


TOTAL PROJECT NO. SHEETS

1 Dowel bars spaced @ 1’-0" on center, at transverse joint, see Note 4 1

Typ Typ

A Lower runner wires


FES S
RO
IO
N
P A
Upper runner wires REGISTERED CIVIL ENGINEER

L
D
E

E
R

N
E
William

G
I ST

INEER
K. Farnbach
November 17, 2006

G
No. C49042

E
R
PLANS APPROVAL DATE
Exp. 9-30-08
The State of California or its officers or
S CIVIL
agents shall not be responsible for the accuracy

A
A I
T
E N
I F OR
or completeness of electronic copies of this plan O
F C AL
sheet.

Dowel
B B
Bars
To accompany plans dated

1 Dowel bars spaced @ 2’-4" on center at longitudinal joint 1

Typ Typ

Lower runner wires Upper runner wires

2006 REVISED STANDARD PLAN RSP P12


A Fasteners spaced at 3’-0",
four each side of assembly

W2.5 spacer wires welded Upper runner wires


to Upper Runner Wire Longitudinal Joint
Lower runner wires
or edge of Conc Pavement
Longitudinal Joint
or edge of Conc Pavement
PLAN Dowel
C C
Bars
DOWEL BAR BASKET
(TRANSVERSE JOINT)
See Note 1
1’-6"

Arc or resistance weld alternate


Dowel Bar ends of dowel bars, see Note 5

R= Dowel Fasteners spaced


at 3’-0", four each
W10 Wire W2.5 spacer wires welded side of assembly
Upper runner wire to Upper Runner Wire
Legs

Thickness
125

Upper runner wires PLAN


1
DOWEL BAR BASKET
Typ

Pa
Wire
Min
Legs (LONGITUDINAL JOINT)
Leg
Lower runner wires Wire
See Note 1
Leg

Lower runner wire


Base
"A" SHAPE "U" SHAPE
NOTES:
SECTION A-A
ASSEMBLY FRAME DETAILS 1. "U" frame shape assembly shown. "U"
frame shape or "A" frame shape are
Pavement Lane Width acceptable.

6" Upper runner wires Dowel bars 2. Wire sizes shown are minimum required.
6"
D

3. All wire intersections are to be


Lower resistance welded.
runner
wire Washer
4. Use tie bar spacing for longitudinal dowel
Clip bar locations. See Std Plans P1 and P2,
and Revised Std Plan RSP P3 for tie
Washer
Pavemen Clip bar requirements.
Lower runner wires
Base Base
Longitudinal Joint
Concrete 5. Weld may be at top or bottom of
Longitudinal Joint or edge of Conc Pavement
Nail dowel bar.
or edge of Conc Pavement
Concrete Nail
SECTION B-B Lower runner wire

See Note 1

STATE OF CALIFORNIA
Pavement Lane Length
DEPARTMENT OF TRANSPORTATION

Var Upper runner wires Dowel bars Var D


CONCRETE PAVEMENT-
PLAN SECTION D-D
DOWEL BAR BASKET
DETAILS
FASTENER DETAIL
Transverse Joint
Pavemen NO SCALE
Lower runner wires
Base
Transverse Joint
RSP P12 DATED NOVEMBER 17, 2006 SUPERSEDES STANDARD PLAN P12

SECTION C-C DATED MAY 1, 2006 - PAGE 125 OF THE STANDARD PLANS BOOK DATED MAY 2006.

See Notes 1 and 4


REVISED STANDARD PLAN RSP P12

10-24-06

Das könnte Ihnen auch gefallen