Beruflich Dokumente
Kultur Dokumente
DESCRIPTION PACKAGING
MasterProtect 180 is a protective high build epoxy MasterProtect 180 is supplied in 5kg units.
resin coating specifically developed to protect
concrete. Supplied as a two-component system TYPICAL PROPERTIES*
comprising pigmented base and a hardener, it
requires only on site mixing to produce an easily Working life at 25°C 40 minutes
applied decorative and chemically resistant finish.
Mixed density at 25°C 1.5g/cm³
MasterProtect 180 can be safely used in areas
Initial cure 24 hours @ 25°C
where contact with foodstuffs is envisaged or for
Final cure 7 days @ 25°C
coating potable water storage tanks. It is solvent
Coverage 0.3-0.6kg / m² / coat
free and can be used with safety in small rooms or
tanks without the need to provide special Total dry film thickness Min 400 microns
ventilation. MasterProtect 180 coatings will not Bond to concrete >1.5N/mm²
support the growth of bacteria. ASTM D4541
NOTE
Field service, where provided, does not constitute
supervisory responsibility. For additional
information contact your local BASF
representative.
BASF_CC-UAE/Pr_180_02_95/v4/05_17
The technical information and application advice given in this BASF publication are based on the present state of
STATEMENT OF our best scientific and practical knowledge. As the information herein is of a general nature, no assumption can be
RESPONSIBILITY made as to a product's suitability for a particular use or application and no warranty as to its accuracy, reliability or
completeness either expressed or implied is given other than those required by law. The user is responsible for
checking the suitability of products for their intended use.
Field service where provided does not constitute supervisory responsibility. Suggestions made by BASF either
NOTE orally or in writing may be followed, modified or rejected by the owner, engineer or contractor since they, and not
BASF, are responsible for carrying out procedures appropriate to a specific application.