Beruflich Dokumente
Kultur Dokumente
Part-A
Screwed fasteners:
Riveted joints:
Keyed Joints:
1. Design a saddle key to be used in a shaft of diameter 30 mm.
2. Design a hallow saddle key used in a shaft of diameter 25 mm.
3. Design a taper sunk key to connect two shafts of 30 mm. diameter.
4. Draw a gib head key to use in a machine member shaft of diameter 30 mm.
5. Design a sunk key to be used in a shaft of 32 mm diameter.
6. Show 6 splines that are used in a shaft of 32 mm diameter.
7. Draw a woodruff key to join a wooded shaft of diameter 28 mm.
8. Design a round key to join a shaft of 30 mm diameter.
Cotter Joints:
Part-B
Assembly Drawings:
1. Draw an assembled view for the part drawings of Petrol engine connecting- rod.
2. Draw an assembled view for the part drawings of Piston
3. Draw an assembled view for the part drawings of Screw jack
4. Draw an assembled view for the part drawings of Single Tool Post
5. Draw an assembled view for the part drawings of Plummer block
6. Draw an assembled view for the part drawings of protected flanged coupling
7. Draw an assembled view for the part drawings of Foot step Bearing