Beruflich Dokumente
Kultur Dokumente
AlarmAttribute
Alarm Severity:Minor
Alarm Reason
System Influence
None.
Handling Suggestions
Other hardware errors, other software errors, RAM error, UART error,
TMA critical alarm level, TMA minor alarm level, hardware fault, software
fault, EEPROM error, FLASH erase error, FLASH error, or external LNA fault:
1. Select Dynamic Management -> Dynamic Command -> SDR -> AISG
Device, and reset the AISG device according to the antenna number/rack
number/device type in the additional alarm information in the alarm details.
No -> Step 2.
No -> Substep b.
No -> Step 2.
No -> Step 3.
No -> Step 2.
2. Select Dynamic Management -> Dynamic Command -> SDR -> AISG
Device, and reset the AISG device according to the antenna number/rack
number/device type in the additional alarm information in the alarm details.
1. Select Dynamic Management -> Dynamic Command -> SDR -> AISG
Device, and perform RET calibration according to the antenna number/rack
number/device type in the additional alarm information in the alarm details.
No -> Step 2.
No -> Step 3.
1. Select Dynamic Management -> Dynamic Command -> SDR -> AISG
Device, and perform configuration data transmission and then RET
calibration according to the antenna number/rack number/device type in the
additional alarm information in the alarm details.
No -> Step 2.
No -> Step 3.
1. Select Dynamic Management -> Dynamic Command -> SDR -> AISG
Device, and configure the tower mounted amplifier to the normal mode
according to the antenna number/rack number/device type in the additional
alarm information in the alarm details.
No -> Step 2.
No -> Substep b.
No -> Step 2.
2. Verify that the cables of the antenna and feeder system are properly
connected.
a. Check whether the cables of the antenna and feeder system are
properly connected (For example, the connectors are not secured, or there
are short circuits).
No -> Substep b.
No -> Step 3.
1. Verify that the type of the external extended device is set to be the
same as that of the actual device.
No -> Substep b.
b. Modify the device type to be the same as that of the actual device.
No -> Step 2.
1. Select Dynamic Management -> Dynamic Command -> SDR -> AISG
Device, and perform RET calibration according to the antenna number/rack
number/device type/right tilt value in the additional alarm information in the
alarm details.