Beruflich Dokumente
Kultur Dokumente
DESCRIPTION
TYPICAL PROPERTIES
Alccofine 1108SR* is high strength, single At 270C under laboratory conditions
component, cementitious pre packed crack
injection, micro-fine grout powder. It is based on Property Value
unique PSD technology to facilitate effective filling Form Dry fine powder
of deep fine cracks and voids. It has particle size Component Single
much finer than other hydraulically setting Particle size d95 < 15 Microns
materials like OPC. It is produced in state of the
Blaine Fineness > 8000 cm2/gm
art manufacturing plant in a controlled
Marsh Cone Viscosity1 35 to 55 seconds
environment resulting in consistent quality.
Compressive strength2 > 40 MPa at 7 days
> 50 MPa at 28 days
1: Orifice diameter 4.76 mm 2: At 0.5 water to powder ratio
FIELDS OF APPLICATION Results may vary as per site conditions
PDS/AF/1108SR/V1/06/15
TECHNICAL SERVICE HEALTH and SAFETY
Consult Alccofine technical service department for PPE: Hand gloves, goggles and suitable
the information related to the product and its respiratory mask shall be used.
application. PRECAUTIONS: Avoid prolonged contact with
skin. Like for all other micro fine materials, may
PACKAGING cause irritation to eyes and respiratory system if
inhaled. If swallowed seek medical attention
Alccofine 1108SR is available in 25 Kg bags.
Other pack sizes are available on request. immediately.
HAZARD: Regarded as non-hazardous for
transportation.
DISPOSAL: Empty bags shall not be reused and
STORAGE AND SHELF LIFE disposed off as per local rules and regulations.
ADDITIONAL INFORMATION: Refer MSDS of
Bags containing Alccofine 1108SR should be
the product.
stored in well-ventilated, sheltered, cool, dry area
and protected from moisture, rain and heat. DECLARATION
Under such storage conditions shelf life of sealed All the information is based on facts and figures experienced in the
field and laboratory. It is the responsibility of the end user to
product is minimum six months from the date of reconfirm the performance parameters. As company does not have
manufacture. any control on handling of the product and site situation, it cannot be
held responsible for deviation in the performance parameters
mentioned in this product data sheet.
CONTACT:
1100