Beruflich Dokumente
Kultur Dokumente
Nishiguchi/SENAUN
Indicates where sections should Indicates sections that should be glued first,
*Hint: Trace along the folds with a ruler be glued together. then cut out.
and an exhausted pen (no ink) to get a sharper, easier fold.
Indicates where to insert sections. Indicates sections that should be folded once,
Do not glue the sections together. then unfolded.
Assembly Instructions
After folding the part once and gluing the two
Glue
Mountain fold(dotted line) folds together, cut out from the yellow area.
The glue spot(colored dot)
Make a mountain fold. Glue parts 2 and 3 together in
shows where to apply the glue.
Valley fold(dashed and dotted line) the same way.
Glue spot(Red dot)
Make a valley fold. Glue parts with the same number together.
Scissors line(solid line) Glue spot(Green dot)
Cut along the line. Glue within the same part.
Cut in line(solid line) Glue spot(Blue dot)
Cut along the line. Glue to the rear of the other part.
Before gluing, crease the paper along mountain fold and valley
Assembly tip fold lines and make sure rounded sections are nice and stiff.
Parts
Glue the rear sides of Affix parts 15, 19, and 23 to the mast by gluing
these parts together. them to the positions shown in the illustration.
Bottom of vessel
Glue parts 71 - 76 (square sails) after folding them once. As shown in the illustration,
to give the appearance of wind in the sails curl them vertically,
and then shape them to make them bulge from the center toward the outside.
Parts -
Na
Ntiiopnal Institu
With po te
the co n For
oper M Sea
ation ar Tra
of th u
e N tr ing
aining
in
vessel
ationa
l Inst
itute
For
Sea
Train
ing
Nat
p
the c on
With
ratio Ma
Sea
Tra
r
oope inin
u
g
n of
th
e Na trai
tiona
l Ins ning
titute ves
For S sel
ea T
rainin
g
Nation
Nippon
al Institut
e For Sea
Maru tra
Trainin
g
With the
cooperation ining ve
of the Nat
ional Inst ssel
itute For Sea
Training
Finished!