Beruflich Dokumente
Kultur Dokumente
1. Spiral binding with plastic cover and front page (white A4 page), refer Appendix
A.
i. Faculty & program
ii. Student’s name
iii. Student ID
iv. Start date of industrial training
v. End date of industrial training
vi. Industrial/company name and address
2. Acknowledgement
3. Abstract
4. Table of Contents
5. List of figures (if any)
6. List of tables (if any)
7. List of abbreviations (if any)
Students are required to write down their industrial training activities in the report
according to the tasks or assignments given by the industrial supervisor as
described below;
13. References
14. Appendices – only include the activities that are related to Electrical or
Electronics Engineering.
Administration Office,
Faculty of Electrical & Electronics Engineering,
University Malaysia Pahang,
26600 Pekan, Pahang
U/P: (Write down your LI Faculty Supervisor Full name)
APPENDIX A
SAMPLE OF FRONT PAGE (WHITE-A4)
50 mm
XXX Company
N0. 4 JALAN IPOH, BATU 18
RAWANG INDUSTRIAL & HOUSING ESTATE
TAMAN RAWANG PERDANA, RAWANG
SELANGOR DARUL EHSAN
APPENDIX B
50 mm
SAMPLE OF THE SPINE
SAMPLE OF TABLE OF CONTENTS
TABLE OF CONTENTS
1 × ENTER (1.5 line spacing)
Page
ACKNOWLEDGEMENTS i
ABSTRACT ii
TABLE OF CONTENTS iii
LIST OF TABLES iv
LIST OF FIGURES v
1 × ENTER (1.5 line spacing)
CHAPTER 1 COMPANY PROFILE
1 × ENTER (1.5 line spacing)
1.5 line spacing,
1.1 Introduction
Title case
CHAPTER 4 CONCLUSION
4.1 Introduction
4.2 xxx
CHAPTER 5 RECOMMENDATIONS
5.1 Introduction
5.2 xxx
REFERENCES
APPENDICES
A xxx
B xxx
C xxx
SAMPLE OF LIST OF TABLES
LIST OF TABLES
1 × ENTER (1.5 line spacing)
6.5 Monotonic and cyclic properties of the MANTEN and RQC100 130
materials
6.7 Experimental actual life and predicted fatigue life using the 136
crack initiation approach
6.9 Predicted fatigue life at critical location with mean stress effect 160
6.10 Comparisons between the Material S-N and Component S-N 161
approaches for the SAETRN loading conditions
6.15 Predicted fatigue life at critical location (node 132171) using the 172
crack initiation approach for the various loading conditions
LIST OF FIGURES
1 × ENTER (1.5 line spacing)
Figure No. Title Page
3.1 The fatigue process: a thin plate under cyclic tensile loading 35
3.4 Sequences which cause problems for the peak-valley and range 46
counting methods
3.5 Sequences having the same average value taken as the reference 47
level
6.1 Finite element meshing for (a) TET4 and (b) TET10 using the 114
same global mesh length
6.2 Von Mises stresses contours (a)TET4 and (b) TET10 meshes at a 115
high load level
SAMPLE OF FRONT PAGE OF CHAPTER, FIGURE AND EQUATION
CHAPTER 2
UPPERCASE, BOLD
2 × ENTER (1.5 line spacing)
LITERATURE REVIEW
TAB: 12.7 mm
2 × ENTER (1.5 line spacing)
2.1 INTRODUCTION
1 × ENTER (1.5 line spacing)
The purpose of this chapter is to provide a review of past research efforts related
to internal combustion engine, free piston engine, finite element analysis, durability
assessment models and surface treatment on the fatigue life. A review of other relevant
The materials are very good in constructing the communication device such as
xxxx.