Beruflich Dokumente
Kultur Dokumente
0 7/26/2012
Fire Watch Training Package Rev.0 (20Jul2012) 1 Fire Watch Training Package Rev.0 (20Jul2012) 2
The hot work is carried out on or near combustible The hot work is close enough to cause ignition
coatings or sandwich-type construction that cannot through heat radiation or conduction on the following:
be shielded, cut back or removed or in a space within 1. Insulated pipes, bulkheads, decks, partitions or
a sandwich type construction that cannot be inerted overheads
2. Combustible materials and/ or coating
Combustible materials adjacent to the opposite 3. The work is close enough to unprotected
sides of bulkheads, decks, overhead, metal combustible pipe or cable runs to cause ignition
partitions or sandwich-type construction may be As specified in the PTW (Permit to Work)
ignited by conduction or radiation
All Hot Works on Platform, FPSO and Below Deck
of Vessel/Barge shall require “Fire Watch”!
Fire Watch Training Package Rev.0 (20Jul2012) 5 Fire Watch Training Package Rev.0 (20Jul2012) 6
1
Fire Watch Training Package Rev.0 7/26/2012
Fire Watch Training Package Rev.0 (20Jul2012) 7 Fire Watch Training Package Rev.0 (20Jul2012) 8
Fire Watch shall have the following Duties & Review and understand the conditions set out in
Responsibilities: approved PTW.
Attend the relevant meeting i.e. pre-shift tool box
He must not perform any other duties apart from meeting, PTW Review, and JSA Discussion
being Fire Watch while the hot work is in progress
Are authorized to stop work if
Have a clear view of the work area and have access to
necessary and restore safe
all “dead-ends” of the work area included in the fire watch
(area covered by Permit To Work (PTW)) conditions within the hot work
Are able to communicate with workers exposed to hot
area & authorized to stop
work “unauthorized personnel” from
entering the hot work area
Fire Watch Training Package Rev.0 (20Jul2012) 9 Fire Watch Training Package Rev.0 (20Jul2012) 10
Inspect fire extinguishers, water hose reel and ensure Alert employees of any fire beyond the incipient stage
they are in good condition and ready for use at any time If unable to extinguish fire in the areas exposed to the hot
Assist the workers to prepare the hot work area such as work, activate the alarm
installation of fire blanket, removal of flammable material, Remain in the hot work area for at least 30 minutes after
etc
t completion of the hot work, unless the Supervisor
Continuously monitor the work area for potential fire (Welder/Fitter Foreman) confirmed that the exposed area
hazards and take the necessary action to prevent fire or is safe and does not pose any further fire hazard
explosion e.g. by stopping hot work or removing Ensure fire fighting equipment will not block any
combustible material access/egress and return them to their dedicated storage
Attempt to extinguish any fires in the hot work area using after use
the provided fire fighting equipment e.g. portable fire Know your “escape route & means of escape”
extinguisher or water hose reel
Fire Watch Training Package Rev.0 (20Jul2012) 11 Fire Watch Training Package Rev.0 (20Jul2012) 12
2
Fire Watch Training Package Rev.0 7/26/2012
RADIATION : transfer of heat without direct contact or Interrupt the CHAIN REACTION
heating a fluid or air between the objects
Fire Watch Training Package Rev.0 (20Jul2012) 17 Fire Watch Training Package Rev.0 (20Jul2012) 18
3
Fire Watch Training Package Rev.0 7/26/2012
WET DRY
Class B fires >> Dry chemicals and carbon dioxide - Water - DRY POWDER
- Foam - CO2
WATER
POWDER
Class C fires >> Non-conductive extinguishing agents such
as dry chemicals or carbon dioxide
FOAM
CO2
Class D fires >> Sodium carbonate, graphite,
bicarbonate, sodium chloride, and salt-based chemicals
Fire Watch Training Package Rev.0 (20Jul2012) 19 Fire Watch Training Package Rev.0 (20Jul2012) 20
POWDER
WHY Fire Extinguisher Failed?
EXTINGUISHERS
WATER
CO2
2
FOAM
TYPE not suitable
N2 Not functioning
Caked powder
Incorrect placement
•Not available
User
•Un-skilled
Fire Watch Training Package Rev.0 (20Jul2012) 21 Fire Watch Training Package Rev.0 (20Jul2012) 22
Fire Watch Training Package Rev.0 (20Jul2012) 23 Fire Watch Training Package Rev.0 (20Jul2012) 24
4
Fire Watch Training Package Rev.0 7/26/2012
Fire Watch Training Package Rev.0 (20Jul2012) 25 Fire Watch Training Package Rev.0 (20Jul2012) 26
Fire Watch Training Package Rev.0 (20Jul2012) 29 Fire Watch Training Package Rev.0 (20Jul2012) 30
5
Fire Watch Training Package Rev.0 7/26/2012
When it is necessary
barrier off the area
and post signs in dual
language to warn people Remove all combustible
of the dangers. items before you start
work & keep HIGH
Standard Housekeeping
at all time.
Fire Watch Training Package Rev.0 (20Jul2012) 31 Fire Watch Training Package Rev.0 (20Jul2012) 32
Fire Watch Training Package Rev.0 (20Jul2012) 33 Fire Watch Training Package Rev.0 (20Jul2012) 34
Fire Watch Training Package Rev.0 (20Jul2012) 35 Fire Watch Training Package Rev.0 (20Jul2012) 36
6
Fire Watch Training Package Rev.0 7/26/2012
Fire Watch Training Package Rev.0 (20Jul2012) 37 Fire Watch Training Package Rev.0 (20Jul2012) 38
Fire Watch Training Package Rev.0 (20Jul2012) 39 Fire Watch Training Package Rev.0 (20Jul2012) 40