Sie sind auf Seite 1von 5

DI–482

DIAGNOSTICS – AUTOMATIC TRANSMISSION (A340E, A340F)


DIB1E–01

DTC P0705 Transmission Range Sensor Circuit Mal-


function (PRNDL Input)

DTC P0850 Park/Neutral Switch Input Circuit

CIRCUIT DESCRIPTION
The park/neutral position switch detects the shift lever position and sends signals to the ECM.
DTC No. DTC Detection Condition Trouble Area
2 or more switches are ON simultaneously at R, N, D, 2 and L
P0705
positions (2–trip detection logic)
 Short
Sh t in
i park/neutral
k/ t l position
iti switch
it h circuit
i it
Park/neutral position switch remaines ON while driving under
 Park/neutral position switch
conditions (a) and (b) for 30 sec. (2–trip detection logic)
P0850  ECM
(a) Vehicle speed: 70 km/h (44 mph) or more
(b) Engine speed: 1,500 – 2,500 rpm

2003 TOYOTA TACOMA (RM1002U)

Author: Date: 744


DI–483
DIAGNOSTICS – AUTOMATIC TRANSMISSION (A340E, A340F)

WIRING DIAGRAM
3RZ–FE J/B No. 1
2 GAUGE 5
B–Y
1I 1F
W W ECM
R/B I14
Ignition B–R
No. 2
AM1 Switch 2
2 R–B R
2 E5

2 19 3D 2 3B
AM1 1 4
1 ST1 IG1 J/B J/B
No. 3 3
No. 3 R L
1 E5
ALT B 18 3D 4 3B
2 P 4
B–R 2
R–B E5

2
16 IK2 Park/Neutral 2 IK2
Position Switch 2 R–B
P1 4 IK3 5 IK3
B–R R
3 4
P1 P
P1 2
W 8
P1 R
21 6 L 8
G G 9 B–Y
IK2 P1 P1 IK3

5 3E J/C
E D
J/B No. 3 J10 J9

R/B No. 2
6 3E W–B W–B
21 STARTER Relay
G EA
Battery IF1 2 2
G
1 2
W 2 2 To
5 3 STARTER
Y–GR
B+
J/B No. 1 21 3E
3 STA 6 20 22 22 NSW
B Y–GR Y–GR
1I 1F 3E 3E E5

J/B No. 3

D11915

2003 TOYOTA TACOMA (RM1002U)

Author: Date: 745


DI–484
DIAGNOSTICS – AUTOMATIC TRANSMISSION (A340E, A340F)

5VZ–FE J/B No. 1


2 GAUGE 5
B–Y
1I 1F
W W ECM
R/B I14
B–R
No. 2 Ignition
6
2 AM1 Switch R–B R
2 E6

2 19 3D 2 3B
1 4
AM1
ST1 IG1 J/B J/B
1 4
No. 3 No. 3 R L
1 E6
ALT 18 3D 4 3B
2 B 5
B–R P 2
R–B E6

2
16 IK2 Park/Neutral 2 IK2
Position Switch 2 R–B
P1 4 IK3 5 IK3
B–R R
3 4
P
P1 P1
2 8
W
R
P1
21 L 8
9
G 6 B–Y
G IK2 P1 P1 IK3

5 3E
E J/C D
J/B No. 3 J10 J9

R/B No. 2
6 3E W–B W–B
21 STARTER Relay
G EA
IF1 G 2 2
Battery 1 2
W To
2 2
5 3 STARTER
Y–GR
B+
J/B No. 1
21 3E
3 STA 6 20 22 3 NSW
B Y–GR Y–GR
1I 1F 3E 3E E6

J/B No. 3

D13177

2003 TOYOTA TACOMA (RM1002U)

Author: Date: 746


DI–485
DIAGNOSTICS – AUTOMATIC TRANSMISSION (A340E, A340F)

INSPECTION PROCEDURE

1 Read PNP, REVERSE, DRIVE, 2ND and LOW signals.

When using hand–held tester


PREPARATION:
(a) Remove the DLC3 cover.
(b) Connect a hand–held tester to the DLC3.
(c) Turn the ignition switch ON and hand–held tester main
switch ON.
CHECK:
Shift lever into the P, R, N, 2 and L positions, and read the PNP,
REVERSE, 2ND and LOW signals on the hand–held tester.
OK:
Shift position Signal
2 2ND OFF → ON
L LOW OFF → ON
R REVERSE OFF → ON
P, N PNP OFF → ON

When not using hand–held tester


3RZ–FE
PREPARATION:
2 L R
Turn the ignition switch ON.
CHECK:
Measure voltage between terminals NSW, 2, L and R of ECM
and body ground when the shift lever is shifted to the following
(–) (+) NSW
positions.
OK:
NSW–Body R–Body 2–Body L–Body
Position ground ground ground ground
5VZ–FE
P,N 0V 0V 0V 0V
R 7.5 – 14 V* 7.5 – 14 V* 0V 0V
D 7.5 – 14 V 0V 0V 0V

R 2 L NSW 2 7.5 – 14 V 0V 7.5 – 14 V 0V


(–) (+)
L 7.5 – 14 V 0V 0V 7.5 – 14 V

D12208 HINT:
*: The voltage will drop slightly due to lighting up of the back up
light.

OK Check and replace the ECM


(See page IN–28).

NG

2003 TOYOTA TACOMA (RM1002U)

Author: Date: 747


DI–486
DIAGNOSTICS – AUTOMATIC TRANSMISSION (A340E, A340F)

2 Check park/neutral position switch.

PREPARATION:
Remove the park/neutral position switch.
CHECK:
Check the continuity between the switch terminals when oper-
5 43 21
ating the switch lever, as shown in the table below.
9 87 6 OK:
Switch Position Terminal No. Specified Condition
R Contuinuity
D06561 6–3
Except R No contuinuity
D Contuinuity
7–3
Except D No contuinuity
2 Contuinuity
4–3
Except 2 No contuinuity
L Contuinuity
8–3
Except L No contuinuity
P and N Contuinuity
9–6
Except P and N No contuinuity

NG Replace park/neutral position switch


(See page AT–9).

OK

3 Check harness and connector between ECM and park/neutral position switch.

NG Repair or replace harness and connector.

OK

Check and replace the ECM


(See page IN–28).

2003 TOYOTA TACOMA (RM1002U)

Author: Date: 748

Das könnte Ihnen auch gefallen