Beruflich Dokumente
Kultur Dokumente
Mushroom growing requires little space and time and farmers can make use of their rice
straws following harvesting. Mushroom can be grown the whole year round provided a
good storage of rice straw is prepared.
This article illustrates the fundamental techniques involved in the culture of banana or
rice straw type of mushroom, Volvariolla volvacoa. The vegetable and Legume Crops
Section of the Bureau of Plant Industry is now producing mushroom spawn in abundance.
Dry rice straws and banana leaves are the most common types of bleeding materials.
However, other materials like cotton wastes, jute sacks, corn stalks, water hyacinth, sugar
baggasse and abaca waste materials may also be used for bedding materials.
Sufficient water supply and soaking tank or any similar container are used. Plastic sheet
of gauge No.6, empty cement bags and sacks are used to cover the beds.
Procedures
1. Gather long, clean and well dried rice straws and banana leaves, preferably those
that are still standing in the field. Avoid using old and contaminated bedding
materials.
2. Bundle the bedding materials 6-8 inches in diameter. If rice straws are used,
arrange butt ends together.
3. Cut the bundle materials 1.5 to 2 ft. long.
4. Soak the bundled materials in water for at least 3 hours but not more than 10
hours until enough moisture is absorbed by the materials.
5. Foundation as support for the bed.
6. Set the soaked-bundled materials, closely knit the together, evenly and compactly.
7. Water the bed well with the urea or ammonium sulfate at rate of 1-2 tbsp. per
gallon of water. Add sugar at the rate of 33 grams per gallon of water to improve
the yield of mushrooms.
8. Press the layer to level of surface. Stop watering when the water starts to drip off
the bed.
9. Insert thumb-size prawns around the bed, four (4) inches from along the side and
four (4) inches apart from each other. Never plant spawn at the middle of the bed.
10. Set the second layer of straw on the top of the first layer. Put the butt ends
together in two opposite direction. Water and press down. Follow the same
procedure until a six-layer bed is attained.
11. Cover the entire bed with plastic sheet gauges No. 6 or cement bags or sacks for
seven days after which it is removed.
Harvesting
The growth of mushrooms on the bed come in flushes. With adequate maintenance and
care, the first flush usually comes and flushes from 13 to 15 days following seeding.
When a flush is on watering must be avoided. Watering is resumed when the flush is
over. Harvesting is done in the following manner:
1. Harvest the whole mushroom including the stump. Don?t leave any stump in the
bed as this would rot and in rotting the adjacent mushroom may be affected.
2. As much as possible care must be taken not to disturb the small buttons.
3. Mushrooms in the button stage of growth are more succulent, hence they are
better preferred than the fully opened ones.
4. Harvested mushroom may be placed in trays or in kaings.
1. When the bed is made, it may be well to cover it with plastic sheet, gunny sack or
any suitable materials to protect it from the drying effect of the wind and to keep
it humid.
2. After the removal of the plastic sheet don?t water the bed as the bed is still wet.
3. Watering should be done only in amounts, which would keep the surface moist
and its environs humid.
4. Watering may be done using a sprinkler, passing same over the bed and along the
sides. Avoid soaking the bed as this condition is equally harmful to the proper
development of the mushrooms as insufficient watering.
5. When the mushroom buttons start to form, water must be stopped until the flush is
over.
6. Resume watering when the flush is over to coax another flush to come.
Pages: 1 2
Related Posts:
Spawnless Mushroom Production Using Munggo Hull
The Promising Business of Growing Mushrooms
How to Grow Taingang Daga (Auricularia)
Entrepreneurship Training Programs for SMEs
Downloads
Search
1. 1
Leo Says:
October 11th, 2007 at 5:35 pm
i like the way you present the procedures, it help people like myself in venturing
in some business like this one. thanks for the tips.
Thank you for the information given about mushrooms. I am really interested in
growing them as a source of income. I am an OFW here in saiapan, and
wondering where can I get the spawns? Do you know any producer that can send
them thru mail in this area ouside the Philippines? Thank you so much.
thank you for the fruitful information.i want to start this business but my question
is where can we sell our harvested mushroom.thank you very mush
thanks for this wonderful tips re: mushroom farming. I’m leah & really so
engrosed with starting a business like this but my problem is where can i avail of
the spawns & much better a training thereof. By the way i presently live in
Libungan, Cotabato. A Minicipality between Pigcawayan & MIdsayap…Pls. I
need your response.
Hi, you can inquire at TLRC hotline (02) 727-6205 if they have reqional training
centers, or you can visit the website at http://www.tlrc.gov.ph.
Eu-leh, Thanks for the helpful info. This is just a follow-up to the question posted
earlier: where can we sell the mushrooms? I’m from Sothern Luzon, and after
harvesting my mushrooms, where can I bring them? How’s the market for this
right now? What are the current market prices for the different kinds of
mushrooms? Which kind is more in demand? Are there support groups or trade
guilds to help start-up growers like me? Thanks for the help again.
Hi, I’m not really an expert in mushroom farming. You can inquire directly to
Bureau of Plant Industry, Mushroom Producers Assoc. of the Phils. and TLRC
(see all the contact details above). Regards,
Thank you!!!
This was very informative, but I am having great difficulties finding mushroom
spawn suppliers.
(seedlings, spors)
When reaching BPI I was sent around on a merry go round trying to find one
person with information and products. No luck.
Is there an easier way to find spawn, varieties sold in the Philippines and the
prices?
Fungiola
hi fungiola, have you tried contacting dept. of agriculture directly? here’s the
contact details:
Department of Agriculture
Elliptical Road, Diliman, Q.C.
Tel: (02) 920-4069 to 75
Email: webgroup@da.gov.ph
Hi, I am new in mushroom farming but my problem is the pests. What solution
can you give me against the sciarid fly/larvae? is there any biological/chemical
pesticides I can use to combat these pests and where can I order/buy them?
hi! im jun,23yrs old from davao del norte panabo city. i would like to start a
business, im very well interested in mushroom farming can anyone help me how
to start a mushroom farming? i will be greatful if anyone would reply this matter..
tnx!
im jun ones again you can reach me through mobile number 09183433881 or
email me at jun_flipbeats@hotmail.com or robjr_camaho@yahoo.com… please
me to put up a mushroom plantation couse im very well interested.. txxx.
for those who are interested in mushroom culture, try to contact the Dept. of
Agriculture in Muntinlupa City. Just look for the tel nos. in Telephone Directory
(Government)the procedures are much easier.
or email
kmbeltran@hotmail.com
Am very much interested in mushroom farming and would like to know where I
can train.
web: http://www.tlrc.gov.ph
email: tlidsg@yahoo.com
phone: 727-6205 loc. 200
this was truly a great source of indormation for someone like me who’s just
beginning to venture into a mushroom business. are there any mushroom
businesses i can visit? i stay in diliman but our farm is in zambales. also, where
can i get the costs for start-up of this business just so i’m sure my capital is
enough.
gina
2. 2
Leo Says:
October 25th, 2007 at 4:09 pm
russel, check the TRC schedule every month. you can request for a special
seminar schedule if the participants is 5 or more. contact:
TLRC Building
#103 J. Abad Santos cor. Lopez Jaena Sts.,
Little Baguio, San Juan, Metro Manila
Tel: (02) 727-6205
Web: http://www.tlrc.gov.ph
4. 4
im very much interested in mushroom, can you send me some other tips?
5. 5
mel Says:
October 28th, 2007 at 9:52 pm
I am very interested to learn more about this industry, I would like to start a
business of mushroom growing but still need a lot of knowledge. Thank you for
these information. Please inform me regarding any trainings and seminars
available. Your tips and advice would be greatly appreciated. Here is my email
melaysnantonio@yahoo.com,thanks.
6. 6
7. 7
Dr Sali Bazze Says:
November 7th, 2007 at 9:26 pm
I live and work in Uganda, East Africa.Have read yr very interesting info :button
mushroom growing
Could you send me spawn and full instructions for commercial production.Could
you assure me of regular spawn supply.
Thanks for yr nice presentation
Please revert a s a p.
(07.11.07)
8. 8
9. 9
Leo Says:
November 16th, 2007 at 1:47 pm
hi cerilo, you can inquire from different training institutions, here’s the list
10. 10
jagfdo Says:
November 26th, 2007 at 5:32 pm
Nikolai Codiase, My uncle, who runs Jentrix Enterprises at the Capitol, can help
you market your oyster mushroom. They fall-short of supply since they also
process their mushroom burger patties, mushroom wine, cantoon noodles with
mushroom. Try to drop by onetime.
11. 11
jagfdo Says:
November 26th, 2007 at 5:35 pm
By the way, Jentrix Ent also conducts training for oyster mushroom production
and how to set-up a mushroom farm. Please email me for those interested who are
interested of visit http://ygolottes.com and look for the jentrix icon for further
details. thanks
12. 12
13. 13
anonymous Says:
December 3rd, 2007 at 11:02 am
14. 14
15. 15
Lorenzo Says:
December 20th, 2007 at 5:19 pm
16. 16
Lorenzo Says:
December 20th, 2007 at 5:25 pm
1.0 What is the market value of each mushroom type (Umbrella / Botton type) for
1 kg?
2.0 How is the preservation process for both if I need to package it in platic
pockets for distribution to suppermarkets?
17. 17
for those who are interested in making a feasibility study in mushroom growing
and production, please e-mail me @ monettecportacio@gmail.com i would be
happy to be of help.
18. 18
sonny Says:
January 2nd, 2008 at 8:32 pm
Hi everyone, I’m interested in mushroom farming but I don’t know where to ask
the information and the training necessary. I reside here in Cebu City, please help
me. My contact no. is 0920-8936741. Thank you very much.
19. 19
JEN Says:
January 13th, 2008 at 5:49 am
policarpio_jen@yahoo.com
09178859172
20. 20
juani2 Says:
January 16th, 2008 at 6:16 am
hello!!! i’m a second year student in a science high school here in cebu and we’re
already having a research about mushrooms and we’re gonna make a study on
it…..i don’t have any knowledge about it so pls help me…
also, for those who knows a mushroom grower center here in cebu pls tell
me….THANK YOU!!!
21. 21
alicia Says:
January 16th, 2008 at 10:32 am
i like your procedure on how to make mushrooms outof rice straw.but i prefer to
know how to make mushrooms out of sawdust.we have plenty of sawdust in our
backyard when they cut our mango trees.is there a possiblity to make mushrooms
out of it|?
22. 22
jeni Says:
January 19th, 2008 at 7:21 am
juani2 and i are classmates but we are having different groups. as what she had
also ask, i aslo wanted to know if do know a mushroom grower here in Cebu? we
really need your help…
this is for our research study….
if you someone, plz do help us…
Thank you….
23. 23
harriet Says:
January 22nd, 2008 at 6:09 pm
hi, guyz
i’m also looking for a mushroom grower here in cebu. there are a lot of us who’s
asking for your knowledge about this. plzzzz………… help it’s urgent we gonna
pass it tommorow plzzzzzzzzzzzzzzzzzzz.
tnx :-)
24. 24
geoprincess Says:
January 22nd, 2008 at 6:21 pm
25. 25
nikko Says:
January 22nd, 2008 at 11:34 pm
please, if anyone could help us in our quest for that legendary “mushroom
growing center or nursery” here in cebu, please tell us. thanks a lot!
26. 26
I am a college student here in Legazpi City, Bicol and a 3rd year student with
entrepreneurship major. I am doing a feasibility study and i choose mushroom
cultivation as my proposed business since there’s no producer here. Can you help
me where i can buy seedlings here in legazpi? Anyway your article here help my
papers for my FS. tnx
27. 27
dxn Says:
January 24th, 2008 at 7:00 pm
28. 28
29. 29
30. 30
Hi,
I’m willing to join the seminar. How much would it cost per person and how long
the seminar would be? Please count me in. I’ll be in the Philippines on March 15-
23, 2008. Here’s my contact number: +6593963487 (singapore).
Thanks.
31. 31
Hi, i want to culture a white rot fungus and a mushroom before april, pls the
purpose is to create it for bioremediation of contaminated soil with crude oil.
hence this will aid my project research studies.
I want to know how Phanerochaete chrysosporium can be produced iam peter ojo
from uniben ,Nigeria
thank you peter
32. 32
Leo Says:
February 9th, 2008 at 8:20 pm
@rom, please call TLRC directly for their schedule on mushroom seminar.
33. 33
34. 34
albert Says:
February 21st, 2008 at 6:09 pm
35. 35
ALY Says:
February 25th, 2008 at 3:59 pm
36. 36
hello everyone,
37. 37
helo po…
thank u po sa info…
38. 38
Hi! i’m leah, i live in quezon city, i’m interested in mushroom culture and would
like to know if it’s possible to cultivate mushroom in such limited space. i would
like to start just in small quantity. Could it be possible to do such.
39. 39
shari Says:
March 8th, 2008 at 10:55 am
hello guyz!!!!
people all over the world please help me in mushroom research study…the effect
of humidity in the growth rate of mushrooms..tnx!!!
40. 40
41. 41
cil Says:
March 12th, 2008 at 11:51 pm
hi there,
Meron ba tayong Philippines mushroom association kung saan tuturuan ka sa
lahat-lahat, meron daw po kasi noon, may nakapagsabi sa akin.
42. 42
Leo Says:
March 13th, 2008 at 1:10 am
43. 43
cil Says:
March 14th, 2008 at 8:07 pm
hi leo,
not yet in service po, saan po ba ito?baka me iba pa kayong number
44. 44
Leo Says:
March 15th, 2008 at 10:04 pm
45. 45
cil Says:
March 22nd, 2008 at 10:16 am
46. 46
Leo Says:
March 22nd, 2008 at 11:58 am
47. 47
I just like the other people here asking where to get spores to grow mushrooms.
I’m just wondering if I can use the grass stalks growing here in baguio as a
substitute for growing mushrooms? Can I have a modular instructions for growing
mushrooms?
48. 48
monette_portacio Says:
April 15th, 2008 at 12:36 am
@ mr. dait… you can go to dti office at your place. there’s a vcd that you can ask
from them.
49. 49
awen Says:
April 20th, 2008 at 2:49 pm
50. 50
wala bang libreng pa-training and seminar from basic spawn growing to harvest?
Technology is nothing if not shared to the grassroot.
Ask ko lang if the CLSU mushroom Center is a GOVERNMENT FUNDED
center?
kasi kung ganon ang case, pwede sigurong mag-training ng libre?
Di ba?
51. 51
aida Says:
April 24th, 2008 at 7:51 am
Hi!
I want to know if is their any training on growing mushroom here at my place
bauang, la union? Is their any vcd on steps by steps of growing mushroom to
cultivation to packaging? And how much?
52. 52
Leo Says:
April 24th, 2008 at 11:45 am
@Don Pogua, i think some LGUs give free training, you have to inquire from
them directly though.
53. 53
Leo Says:
April 24th, 2008 at 11:49 am
54. 54
aida Says:
April 24th, 2008 at 6:07 pm
Hi!
May i know the telephone number of LGUs?
55. 55
Leo Says:
April 25th, 2008 at 5:00 pm
56. 56
is der any training institutions that conduct seminar about mushroom production
hir in lubao pampanga? if ders any kindly email me..tnx
57. 57
monette_portacio Says:
April 30th, 2008 at 9:56 am
58. 58
59. 59
60. 60
Lanie Lleno Says:
May 5th, 2008 at 9:54 am
hi ma’am I am a 3rd year BS-Entrep. student here in Bicol, and right now i am
conducting a project feasibility study about mushroom cultivation and production.
can you help me please. Thank you…
61. 61
62. 62
Leo Says:
May 5th, 2008 at 8:52 pm
@lanie, several articles about mushroom growing were already posted here. just
use the search bar above with the keyword “mushroom”
63. 63
jennifer Says:
May 9th, 2008 at 1:51 pm
we sell oyster mushroom spawn and fresh mushrooms at MSC Marinduque Please
contct 09206742516
64. 64
jay-ar Says:
May 11th, 2008 at 4:33 pm
Sir/Mam,
can you provide me a .pdf file of mushroom farming? and also, how much does it
take to start a mushroom farming business?
thanks
65. 65
Hello Leo,
Do you have articles on how to preserve mushrooms for long term storage? like
drying and vacuum packaging them?
thanks
66. 66
67. 67
68. 68
69. 69
I would like to know more about mushroom cultivation and how to plant it…
please send me more info and where can I buy seeds of these…I am from Bacolod
City, and would like to learn and start planting my own mushrooms…please send
me info who to call..preferably the growers themselves so I can call and talk to
them…thanks and have a nice day…
70. 70
tesp Says:
June 7th, 2008 at 12:17 am
71. 71
edz Says:
June 9th, 2008 at 2:17 pm
hello, do you market for mushroom? just in case i get into mushroom producing,
can you help me find market for it?
thanks
edz
72. 72
Leo Says:
June 9th, 2008 at 3:06 pm
73. 73
mac Says:
June 9th, 2008 at 9:56 pm
i just want to know if u have any idea where can i market my mushrooms? thank
you so much mac
74. 74
Leo Says:
June 10th, 2008 at 9:44 am
@mac, you can market your mushrooms to restaurants, canteen, grocery stores,
supermarkets, wet markets, wholesale traders and even selling it in front of your
house. it requires a bit of sales talk though :)
75. 75
judy Says:
June 17th, 2008 at 6:43 pm
hi! I’m judy from laguna. i would like to start a business, im very well interested
in mushroom farming can anyone help me how to start a mushroom farming?
training/seminars near my location. is there any mushroom farm that i can visit?
tnx
76. 76
Leo Says:
June 17th, 2008 at 10:11 pm
@judy, read through the comments left by readers and people who are into
mushroom growing. check also “Related Posts” on other mushroom articles.
77. 77
anton Says:
June 19th, 2008 at 9:56 pm
where can i buy spores and other stuff needed to start my mushroom farm?
thanks
78. 78
Leo Says:
June 20th, 2008 at 8:14 pm
79. 79
@edz & mac, can i know your location please. marketing mushroom really isn’t a
problem at all. because there is a large market of it. even in your neighborhood is
a big marketing area. you might still need the help of our growers to produce for
you since it is cultivated, you can’t add any chemical to make it grow faster.
80. 80
joshua Says:
June 25th, 2008 at 7:58 pm
81. 81
hi!i’m a student of uplb. may i know where existing mushroom farms are in
laguna?
82. 82
jenny Says:
June 29th, 2008 at 5:10 pm
Hello, Can anyone tell me where i can get training in manila, cavite or laguna area
for growing mushroom? I ‘ve been calling TLRC but no one is answering.
Thanks po.
83. 83
jenny Says:
June 29th, 2008 at 5:13 pm
the number i called is the one listed above: Just want to verify if the numbers are
still active. If not , kindly tell me the new numbers where i can call them.
Thanks
84. 84
Leo Says:
June 29th, 2008 at 6:49 pm
85. 85
jenny Says:
June 30th, 2008 at 1:23 pm
@Leo. Wow that was fast. :) thanks for the quick response. I really appreciate the
immediate input.
I will be calling it now. If the training from TLRC wouldn’t available asap, do you
any other group that offers the same training?
Thanks Again,
jenny
86. 86
Leo Says:
June 30th, 2008 at 2:07 pm
@jenny, you’re welcome. check this link for other training centers:
http://www.mixph.com/2006/03/trainings-and-seminars-institutions.html
87. 87
Jenneth Says:
July 1st, 2008 at 10:43 am
Hi! can anybody help me out regarding this Mushroom Training? i’ve been to our
local agriculture offices but they don’t conduct such training. i want to have a full
knowledge and training of mushroom cultivation/farming. Please tell me where i
can get training here in Mindanao particularly in Cagayan De Oro City or Ozamiz
City?
88. 88
Jenneth Says:
July 1st, 2008 at 11:41 am
please help me, this is my email add jneth_3da@yahoo.com and mobile no.
09107857574. your help is greatly appreciated. thank you
89. 89
Jenneth Says:
July 7th, 2008 at 1:10 pm
Good Day!
90. 90
Leo Says:
July 8th, 2008 at 10:23 am
@Jenneth, i’m not sure if there’s any training centers in mindanao, but you can
call/text the following mushroom growers and inquire from them:
bodgie vera cruz - 09169952445
Mushroom Producers Assoc - (02) 442-5074
Tarlac - (045) 985-0052
annabelle e. demafelix - 0910 7494434 email: bdemafelix@yahoo.com
monette portacio - monettecportacio@gmail.com
91. 91
Hi,
I am from Papua New Guinea, University of Goroka. I am very keen in learning
how to culture mushrooms. I have been looking for mushroom training
opportunities but could not find one within and abroad. Thank you for this offer.
How can I enroll? When is the next training?Is it possible for job attachment or on
the job training?
Best regards,
A. Barish
92. 92
Hello,
Lex
93. 93
monette portacio Says:
July 15th, 2008 at 11:53 am
@ lex, yes you can still grow mushroom even if you have limited space. be sure
your landlady will allow you to grow mushroom in your boarding house… =) if
you need assistance regarding setting it up, you can contact me @
monettecportacio@gmail.com
94. 94
Is there anyone who could send me a simple cost and return analysis of a
mushroom business?
I reside in San Miguel, Bulacan. If i’m going to market my produce in Metro
Manila, I must have a good volume to be able to cover the transportation cost.
Now, how many fruiting bags is advisable for me to start the business.
Is there any buyer that you know that will be able to pick up my production?
Do have any info on how much is the prevailing price of 1 fruiting bag of
Pleurotos specie?
Tnx for helping us!
95. 95
96. 96
@mr. nogoy,
a fruiting bag costs 25/bag in commercial suppliers. its up to you on how many
fruiting bag you can start with. you need to market first so that you can have an
idea on how many fruiting bags you need to start with. =)
97. 97
Julius Cesar Nogoy Says:
July 19th, 2008 at 10:09 am
98. 98
Leo Says:
July 20th, 2008 at 2:40 pm
99. 99
@julius,
100. 100
hello everyone,
please visit our site mushroomlab.multiply.com
we are based in tarlac city.
our products:
volva spawn
pleurotus spawn & fruiting bags
starter packages for volva cultivation available thru lbc
our services:
102. 102
ms cheryl,
103. 103
marvin Says:
August 7th, 2008 at 4:22 pm
hi eveyone!
104. 104
I am presently working here in Mackay, Qld, Australia. I was able to gather some
techniques to mass cultivate / high breed white button mushrooms, 15 day-to-pick
variety. This mushroom button is very popular here in Australia. I am willing to
provide any assistance that I can share. Contact me thru my email add,
jolyngaa@yahoo.com.au
105. 105
bodgie vera cruz Says:
August 12th, 2008 at 8:19 am
hello everyone,
please visit our site mushroomlab.multiply.com
we are based in tarlac city.
our products:
volva spawn
pleurotus spawn & fruiting bags
starter packages for volva cultivation available thru lbc
our services:
106. 106
Hello everyone,
for those who have interested in mushroom farming, cultivating and growing. We
have technology all about mushrooms, from PDA, tisue,pure culture up to
harvesting. Keep in touch with us at this number (0927)8099701 email:
teddylaurie@ymail.com
107. 107
Xian Says:
August 27th, 2008 at 11:21 am
Hi i’m Xian,
I’m interested about this kind of business but i’m just new and inexperienced, I
was wondering if maybe there is an available video for this. That would help me
to make a great start, thanks..pls e.mail me in this account nico_diola@yahoo.com
cheers to all!
109. 109
Fria Says:
August 27th, 2008 at 10:33 pm
Thanks po,
110. 110
mr xian,
111. 111
112. 112
HI, everyone,
SA LAHAT NG GUSTONG MATUTO MAGTANIM NG KLASE KLASENG
VARIETY NG MUSHROOM, MAY LIBRENG SEMINAR PO TAYO
TUNGKOL SA PAGPAPATUBO NG KABUTE O CULTURED MUSHROOM,
HUWAG KAYONG MAGBABAKASAKALI SA MGA WILD MUSHROOM
BAKA IKAW AY MALASON. FREE SEMINAR ON HOW TO GROW AND
CULTIVATING MUSHROOM. FOR MORE DETAILS CONTACT TEDDY
(0927) 8099701 OR EMAIL US rejlaurie@hotmail.com
113. 113
Leo Says:
September 8th, 2008 at 11:40 pm
114. 114
Rino Says:
September 11th, 2008 at 2:40 am
so after all this seminar, is there really a market for mushrooms in the Philippines
or do we have to source our own?
115. 115
Israel Borja Says:
September 11th, 2008 at 11:27 am
Hi to everyone.
116. 116
Those who are interested to learn the art and science of mushroom growing, you
may consider having training at the CLSU Mushroom Training.
117. 117
118. 118
@ mr borja, i know a dost consultant from pulilan bulacan. you can contact him.
his name is Zaldy de Guzman, 09178238619
119. 119
120. 120
Thanks to those very good advises… I really appreciate the replies… @ Dr. Dr.
Renato G. Reyes > Where is CLSU? @ Ms. Protacio I already emailed you…
hope you reply back…
I’ve been watching some vids at youtube about mushroom growing… they do
introduce some very good techniques there.. specially those of PF Tek… maybe
you guys could check it out… just search for PF Tek or mushroom growing.
Many Thanks.
121. 121
Leo Says:
September 13th, 2008 at 4:33 pm
122. 122
arnel Says:
September 19th, 2008 at 2:18 pm
hello.im interested in mushroom culture,cna i ask anyone there if what will be the
best fertilizer to enhance the growth and production of volvariella.thank you
123. 123
All thanks goes to you coz you’re educative and no other site that is providing
such a comprehensive coverage of mushroom farming. i’m a potential beginner of
mushroom farming. Keep on Keeping on.
124. 124
All thanks goes to you cos you’re very educative on mushroom growing. Plus no
other web site is offering such. I’m a youthful Kenyan and a potential mushroom
farmer.
125. 125
MAGANDANG UMAGA,
SA LAHAT NG GUSTONG MATUTONG MAGTANIM NG KLASE2
KABUTE, MAY SEMINAR PO TAYO TUNGKOL SA PAGTANIM, PAG-
ALAGA, PAGAWA NG BINHI AT PAG-AANI. HUWAG TAYONG
MAGBAKASAKALI SA MGA WILD MUSHROOM BAKA KAYOY
MALASON DAHIL SA KONTAMINASYON. MAY MGA BINHI NA TAYO
READY TO PLANT NA, MERON NA DIN TAYO PURE CULTURE PARA
NAMAN SA MGA GUSTONG GUMAWA NG MOTHER SPAWN. MGA
KAGAMITAN SA PAGAWA NG MGA PUNLANG KABUTE, KATULAD NG
PRESSURE COOKER(STAINLESS) AT PP PLASTIC 6 X 12 X .03 PARA SA
FRUITING BAG. SA MGA KARAGDAGANG KATANUNGAN MAG EMAI:
teddylaurie@ymail.com
126. 126
Zaldy Says:
September 22nd, 2008 at 10:11 pm
127. 127
Mila Says:
September 23rd, 2008 at 10:25 am
Hi! i’m quite enterested in mushroom culture. tanong ko lang po kung pwede sa
isang lugar na malapit sa creek(sapa)..may 500 sq meters po kasi akong vacant lot
dito sa Sorsogon city nakatiwangwang lang po..Saan po kaya ako makaavail ng
ng pangtanim? ung malapit sa Sor city..thanks!
128. 128
Leo Says:
September 23rd, 2008 at 12:31 pm
129. 129
130. 130
131. 131
ANOUNCEMENT:
SA LAHAT NG MGA NAKADALO NG MUSHROOM SEMINAR SA
DEPARTMENT OF AGRICULTURE OFFICE OF THE SECRETARY NAFC
BUILDING NOONG JULY 18, MERON PO TAYONG FREE HANDS-ON
TRAINING OF MUSHROOM CULTURE,SPAWN MAKING AND GROWING.
MAGSADYA NA LANG PO KAYO SA DEMO FARM KO SA MEYCAUAYAN
BULACAN SA KARAGDAGANG KATANUNGAN EMAIL:
teddylaurie@ymail.com or call us: 09192033178. bring your own Lunch pack. ”
LIBRENG HANDS - ON TRAINING” SEPTEMBER 28, 2008 PARA SA MGA
STUDYANTE NAMIN SA D.A.
132. 132
133. 133
astrid Says:
September 24th, 2008 at 1:39 pm
gud day! i’am student of Laconsolacion biñan, laguna.. can i ask something
about how cultured mushroom work??? my feasibility study is mushroom
cultivation and i dont know where to get an information regrding my study i hope
you can help me thnku
134. 134
Leo Says:
September 24th, 2008 at 1:59 pm
@astrid, read “Related Posts” and all the comments, most of the answers are
already there.
135. 135
Astrid,
We have incoming seminars about mushroom at Victoria Laguna, if you are
interested contact my email: teddylaurie@ymail.com
136. 136
137. 137
138. 138
LANIE Llano,
We have mushroom Farm there in Bicol, Purok 6 Poblacion Uno Basud
Camarines Norte, if you wanted to look our farm, just email us
teddylaurie@ymail.com
139. 139
Xian Says:
September 25th, 2008 at 10:21 am
Hi Monette,
I already e-mailed you, Thanks in advance, your help would really be of great
service to me.
Cheers!
140. 140
Monette Portacio Says:
September 25th, 2008 at 10:32 am
hi xian,
r u nico?
141. 141
Good day!
We are fourth year high school students and we are conducting a research
regarding oyster mushrooms. We need to buy oyster mushroom mycelia, but we
don’t know where and which farm can we get one because some farms just supply
grown mushrooms and not not the mycelium itself. so, if there’s anyone of you
here who knows where we could buy the mycelia, please e-mail us at
researchgroup3iv50809@yahoo.com. thank you.
142. 142
research group,
We have available oyster mushroom mycelia ( Pink, Florida and Sajor-Caju ) also
available medicinal mushroom (Ganoderma Lucidum). For more info email us
teddylaurie@ymail.com or txt us (0919)2033178. Thank you!
143. 143
Mr. Laurie,
thank you for the immediate reply. by the way we’ve already e-mailed you
regarding some details. again, thank you.
144. 144
Peps Andim Says:
September 30th, 2008 at 10:30 am
145. 145
Shaju MJ Says:
September 30th, 2008 at 8:19 pm
146. 146
Peps,
This is Teddy Laurie of R.E.J.L. mushroomcare, from what please are you there in
mindanao? One of our buyer is from misamis oriental through LBC. This is my
number 09192033178. Do you know how to plant, cultivate and harvest
mushrooms?
147. 147
Shaju MJ,
Good morning Sir/Madam, this is Teddy Laurie of R.E.J.L. MUSHROOMCARE,
we are conducting seminars about spawn making, cultivating, growing and
harvesting mushrooms. Whole day seminar with hands-on training, you may
contact us this email address: teddylaurie@ymail.com. Thank you.
148. 148
Albert Says:
October 6th, 2008 at 1:05 am
Napakainformative po nung about dun sa snail fertilizer nyo. Ittry ko rin po gawin
yun. Meron po ba yun expiration? Good for how long po yun?
149. 149
Albert Says:
October 6th, 2008 at 1:06 am
TEDDY,
150. 150
Albert,
Good for 6 months ang kuhol fertilizer natin, after 6 months lagyan mo uli ng
asukal at pede pa uli gamitin. Pero mas maganda kung maconsume mo na sya sa
loob ng 6 months. Gumawa ka ng tama lang sa pangangailangan mo, mas
maganda bago pa,buhay na buhay ang mga micro organism nito.
151. 151
152. 152
jim Says:
October 8th, 2008 at 4:30 pm
153. 153
allan Says:
October 8th, 2008 at 4:36 pm
Allan,
Magandang hapon, si Teddy Laurie ito ng R.E.J.L. MUSHROOMCARE. Kung
mga gamit sa mushroom ang hinahanap mo, meron tayo lahat na kailangan mo.
Sa mga karagdagang informasyon tumawag sa cell na ito 09192033178 o di kaya
mag email: teddylaurie@ymail.com. May hands-on seminar din tayo.
155. 155
JIM,
Malapit ang lugar mo dito sa meycauayan magsadya ka sa demo farm ko at don
mo mabili ang kailangan mong spawn. Anong mushroom variety ang kailangan
mo? Para sa karagdagang kaalaman magtxt 09192033178 email:
teddylaurie@ymail.com
156. 156
I am very interested to learn about growing and culturing mushroom in clsu. What
is the sked.
157. 157
158. 158
Teddy Laurie Says:
October 10th, 2008 at 11:24 pm
Arnold,
Kung makakaluwas ka ng maynila makipagkita ka sa akin at turuan kita kung
anong dapat mong gawin sa pagsimula mo ng mushroom farm, ituro natin ang
pagawa ng punla ng kabute, pagtatanim at pagaalaga. Meron tayong whole day
seminar with hands-on, keep in touch if nandito kana, txt mo ako sa
09192033178, dito sa demo farm ko.
159. 159
brutus Says:
October 12th, 2008 at 11:32 am
Hi Ted, saan lugar yong demo farm mo? May bayad ba yong seminar? Maraming
salamat!
160. 160
Brutus,
May libreng seminar tayo sa pagalaga at pagtanim, kailangan umabot kayo 20
person. Ang me bayad pagawa ng pure culture, spawning o binhi, cultivating,
growing at harvesting with hands-on training. Half day for free seminar, wholeday
with pay 800.00.
161. 161
162. 162
monette portacio Says:
October 16th, 2008 at 1:47 am
anyone who is interested with instructional video for mushroom, just let me know.
thanks. monettecportacio@gmail.com
163. 163
Ryan Says:
October 23rd, 2008 at 11:15 am
Hi Teddy,
salamat po
164. 164
Teddy, those links you provide are all for growing and cultivating. Most questions
here are is there a market for mushrooms or none? Or do you only want to sell
your videos?
165. 165
Joey, we are not selling our videos, but we have live seminars and and hands on
training. Sa ngayon wla pa kaming market sa mushroom, maraming bumibili ng
mushroom kahit saang dako dito sa atin. Mga restaurant mga palengke,
supermarkets. Ang gawa namin ngayon ay ang ituro ang technology sa mga
gustong matutong gumawa ng binhi at pagpapatubo ng kabute.
166. 166
Teddy Laurie Says:
October 26th, 2008 at 9:06 am
Ryan,
Ang market ko ngayon ay ang mga palengke, restaurant at mga tindahan
ipinuprocess ko ang production ko ngaun gaya pagawa ng: Pickled mushrooms,
Dried, Powdered at Mushroom Burger ( mushroom paties). Makipagugnayan ka
nalang sa akin sa mga karagdagang informasyon 09192033178 emai:
teddylaurie@ymail.com
167. 167
bek Says:
October 28th, 2008 at 4:25 pm
I have a small oyster mushroom farm here in Manila. I’d like to ask for assistance
in marketing our produce. Any help would be greatly appreciated. Thanks a lot!!
168. 168
bek Says:
October 28th, 2008 at 4:49 pm
169. 169
nancy Says:
November 28th, 2008 at 11:11 am
170. 170
nancy Says:
November 28th, 2008 at 11:13 am
171. 171
royce Says:
November 30th, 2008 at 10:02 pm
hello i also want to plang mushrooms i was a farmer of vegtable from benguet. do
must it be a dark place where mushroom grows and whats the temperature
172. 172
Leo Says:
November 30th, 2008 at 11:19 pm
@royce, please check “Related Posts”, and read through the comments as you can
get a lot of tips from other growers and farmers.
173. 173
ms nancy,
174. 174
aileen Says:
December 2nd, 2008 at 6:03 pm
Good day!
May i know if you have office branch here in Cebu where i can attend seminar on
mushroom raising?
my emai is white_birdies@yahoo.com
thanks a lot!
sincerely yours,
aileen
175. 175
bodgie vera cruz Says:
December 4th, 2008 at 10:31 am
hello everyone,
please visit our site mushroomlab.multiply.com
we are based in tarlac city, batangas ,laguna.
our products:
volva spawn
pleurotus spawn & fruiting bags
starter packages for volva cultivation available thru lbc
our services:
176. 176
nancy Says:
December 5th, 2008 at 9:29 am
ms. monnete dis is nancy san po ako pwedeng mag seminar? may background ako
bout sa mushroom production. actually naging actual business ko yon nung fourth
yr college ako. i actually graduated B.S. agricultural business. meron ba kayong
new method on how to cultivate mushroom? i really want this to be my lifetime
endeavor. thank you!
177. 177
ms nancy,
Good day. Pls. help me. Saan po ako pwede mag-attend ng seminar about
culturing mushroom? Pls e-mail me at srlfudent@yahoo.com. Thanks.
179. 179
Leo Says:
December 10th, 2008 at 12:11 pm
180. 180
adeluisa_avila Says:
December 28th, 2008 at 9:02 pm
181. 181
adeluisa_avila Says:
December 28th, 2008 at 9:16 pm
182. 182
shari Says:
December 29th, 2008 at 12:42 pm
183. 183
shari Says:
December 30th, 2008 at 10:47 am
..hello po ulit..
..tanong ko po sana kung mero po bang mushroom grower dito sa cebu?…
..eto po ang mail ko: kaleiteen@yahoo.com.ph
184. 184
James Says:
January 5th, 2009 at 3:25 pm
Good afternoon everyone. I’m looking for a banana mushroom spawn in bataan
area. Here is my e-mail address (Deidreamer00@yahoo.com) Tnx.
Leave a Reply
Name (required)
Website
Submit Comment