Beruflich Dokumente
Kultur Dokumente
www.highered.tafensw.edu.au
TAFE NSW -Technical and Further Education Commission
Mechanical Deformation of Metals
http://www.doitpoms.ac.uk/tlplib/slip/intro.php
This process continues until all the available slip planes in the piece of
metal are used up. The metal is then said to be work-hardened.
In this condition, the metal is hard and strong; but it has lost its ductility,
and, if further shaping is required, must be softened by annealing.
Highly work-hardened material has more internal stress points. These form
many nuclei of the new grains, hence grains will be smaller.
Recrystallisation
This is BAD!
Here, an interstitial
atom migrates into
the stress zone,
hindering
dislocations.
Binders
Hot forming
Cold forming
Recrystallisation
Annealing
Work Hardening
Stress Relieving
Grain Growth
Slip
Dislocation
Elastic vs Plastic Strain
Interstitial atom
Substitutional atom
Diffusion
Carburising