Beruflich Dokumente
Kultur Dokumente
Product Purity.
Greater Security.
Added Value.
1
2
3
6 4
7 5
1 LED-line 8 digits To control the system and give the metal signal (visual)
2 Control buttons +,-,F To control and adjust the control parameters
3 Menu bar 3 parameters To navigate between parameters
4 Function key Reset Reset metal or fault signal
5 Function key Test Test button for metal detection system
6 Red lamp Störung (fault) Blinking in case of fault
7 Red lamp Metall (metal) Glowing in case of metal signal
System design
Jumper
Enable parameter
setting
Hex-switch
Parameter selection
(max. 16 parameters)
IP rating: IP65
Switching inputs
1 reset
1 manual ejection
1 compressed-air monitor or thermo switch or filling level monitor
1 initiator (flap position monitor)
Switching outputs
2 metal detection
1 fault signal
2 switching outputs 24V DC, 100 mA, for metal detection
Options / accessories
Control Unit remotely installable up to 15 m
Metal counter
etc.
Top performance features
Adjust sensitivity:
1. 1x button “F“
2. Change parameter with ”+/-“ buttons
3. Confirm changes with button “F“
Product change:
1. 2x button “F“
2. Change parameter with ”+/-“ buttons
3. Confirm changes with button “F“
Activate Auto-Set:
1. 3x button “F“
2. Auto-Set starts automatically after three seconds
3. Confirm changes with button “F“
New function „Auto-Set“
Certain conditions at the place of installation are quite common in the plastics industry and
can influence a metal detector and can lead to false detections:
• Conductive material (e.g. wet material)
• Vibrations
• Electro-smog
“Auto-Set“ can compensate such environmental influences and delivers optimum scanning
sensitivity and prevents false detections
Function can be activated individually and automatically on-site by the customer
The function is being offered in this form by S+S exclusively
Comparison PRIMUS user interface
Improvements:
Switch +/- buttons for more intuitive control