100%(1)100% fanden dieses Dokument nützlich (1 Abstimmung)
985 Ansichten2 Seiten
This document provides specifications for hex bolts in SAE J429 Grade 8. It lists dimensional requirements for bolt size, width across flats, head height, radius of fillet. Materials must meet SAE J429 Grade 8 standards for mechanical and chemical properties. Threads must meet ASME B1.1 standards for UNC and UNF class 2A. Bolt heads require manufacturer ID marking and six radial lines. Bolts must have a light protective oil finish. Material test reports are required to show lot traceability, dimensions, chemical analysis, mechanical properties and comply with Fastenal requirements. Quality assurance must meet category 3 of ASME B18.18.
This document provides specifications for hex bolts in SAE J429 Grade 8. It lists dimensional requirements for bolt size, width across flats, head height, radius of fillet. Materials must meet SAE J429 Grade 8 standards for mechanical and chemical properties. Threads must meet ASME B1.1 standards for UNC and UNF class 2A. Bolt heads require manufacturer ID marking and six radial lines. Bolts must have a light protective oil finish. Material test reports are required to show lot traceability, dimensions, chemical analysis, mechanical properties and comply with Fastenal requirements. Quality assurance must meet category 3 of ASME B18.18.
This document provides specifications for hex bolts in SAE J429 Grade 8. It lists dimensional requirements for bolt size, width across flats, head height, radius of fillet. Materials must meet SAE J429 Grade 8 standards for mechanical and chemical properties. Threads must meet ASME B1.1 standards for UNC and UNF class 2A. Bolt heads require manufacturer ID marking and six radial lines. Bolts must have a light protective oil finish. Material test reports are required to show lot traceability, dimensions, chemical analysis, mechanical properties and comply with Fastenal requirements. Quality assurance must meet category 3 of ASME B18.18.
The information below lists the required dimensional, chemical and physical characteristics of the products in this purchase order. If the order received does not meet these requirements, it may result in a supplier corrective action request, which could jeopardize your status as an approved vendor. Unless otherwise specified, all referenced consensus standards must be adhered to in their entirety.
E F H R
Full-Size Body Radius of
Size Width Across Flats Head Height Diameter Fillet
• Material & Mechanical Properties: SAE J429 Grade 8 • Thread Requirements: ASME B1.1, UNC & UNF, Class 2A • Head Marking: Manufacturer’s ID and six radial lines 60º apart. • Finish: Light Protective Oil • Material Test Reports: The MTR must have documented lot traceability, dimensional results, full chemical test results and full mechanical test results to the specification(s) above. In addition, the MTR shall be in full compliance with Fastenal’s MTR Requirements. • Quality Assurance Provisions: Category 3 of ASME B18.18 Page 2 of 2 Fastenal Product Standard REV-04