Beruflich Dokumente
Kultur Dokumente
Wiring Diagram
VM, EM-EU5, CHID E146802-E149890
Foreword
The descriptions and service procedures contained in this manual are based on designs and
methods studies carried out up to November 2013.
The products are under continuous development. Vehicles and components produced after the
above date may therefore have different specifications and repair methods. When this is judged
to have a significant bearing on this manual, an updated version of this manual will be issued to
cover the changes.
In service procedures where the title incorporates an operation number, this is a reference to V.
S.T. (Volvo Standard Times).
Service procedures which do not include an operation number in the title are for general
information and no reference is made to V.S.T.
The following levels of observations, cautions and warnings are used in this Service
Documentation:
Note: Indicates a procedure, practice, or condition that must be followed in order to have the
vehicle or component function in the manner intended.
Caution: Indicates an unsafe practice where damage to the product could occur.
Warning: Indicates an unsafe practice where personal injury or severe damage to the product
could occur.
Danger: Indicates an unsafe practice where serious personal injury or death could occur.
All rights reserved. No part of this publication may be reproduced, stored in retrieval system,
or transmitted in any forms by any means, electronic, mechanical, photocopying, recording or
otherwise, without the prior written permission of Volvo Truck Corporation .
Contents
Example of wiring diagram ........................................................................................................1
Illustrations............................................................................................................................ 52
List of relays........................................................................................................................... 88
List of connectors................................................................................................................... 89
List of components................................................................................................................. 99
+ Battery voltage.
+ 30 Voltage with S12 key connected (main switch).
+ DR Voltage with the ignition switch in the driving position,
the preheating position and the starting position.
Connection point.
Fuse.
Switch.
Relay.
Connector MB pin 9.
BA Engine ECU.........................................................................................
...................................... page 8
BB Gateway / OBD.....................................................................................
..................................... page 10
BX Telematics .......................................................................
.......................................................... page 11
CK ..................................................... page 17
Brake lamp ...........................................................................
CL ................................................ page 18
Exhaust brake ...........................................................................
DL ..................................... page 23
Differential lock .....................................................................................
EA Reversing light...........................................................................
................................................ page 24
ER ..................................................... page 28
Interior light...........................................................................
EX ..................................... page 29
12V Power supply ................................................................................
EZ ..................... page 30
Extra Switch for Bodybuilder ................................................................................
FA ................................................................ page 31
Horn...........................................................................
FW ..................................... page 32
Fifth wheel light.....................................................................................
HC ..................................... page 35
Engine preheat .....................................................................................
HM ................................ page 38
Fuel filter heater.........................................................................................
JA ................................................ page 39
Radio .........................................................................................
KA ..................................... page 40
Electric window winders .......................................................................
LS ..................................... page 43
Range / Area inhibitor...........................................................................
MA ........................... page 44
Second tag axle lift .........................................................................................
MB ........................................... page 45
Split gearbox...................................................................................
MC ................................................ page 46
Eaton gearbox ...........................................................................
NC ..................................................... page 49
Tachograph...........................................................................
Note: The following illustrations show the locations of connectors in their respective components. Some connectors may not
appear to be connected because the location of their components varies according to the design of the bodybuilder.
C3070813
FH 3.5 Rear view mirror defogger, left and right ................................................................................... {EA 0 A}
FH 3.6 Trailer Brake / Brake Light Relay / Reverse Lamp Relay.......................................................... {EA 0 A}
FH 4 Fuse Group 4
FH 5 Fuse Group 5
FH 6 Fuse Group 6
FH 7 Fuse Group 7
FH 8 Fuse Group 8
FH 9 Fuse Group 9
FH 11 Fuse Group 11
XT62:12 {GA 2 D}
XT62:13 {GA 3 C}
XT62:14 {GA 2 C}
XT62:15 {GA 3 C}
Y18G:1 {DP 2 B}
Y18G:4 {DP 2 B}
A11 Control unit, door lock {KH 0 B} B13 Sensor, wheel speed, lhs. 1 st front axle
{EE_2 0 D}
A12 Control unit, ABS (Anti-lock Brake Sys-
tem) {EE 0 B} B13A Sensor, wheel speed, lhs. 1:st front axle
{EE 0 D}
A13 Control Unit ABS, Anti-Lock Brake Sys-
tem, 6 channels {EE_2 0 B} B14 Sensor, wheel speed, rhs. 1:st front axle.
{EE_2 1 D}
A33 Tachograph {NC 0 B}
B14A Sensor, wheel speed, rhs. 1:st front axle
{EE 1 D}
A62 Control unit, ADS (AdBlue Dosing Sys-
tem) {CV 0 C}
B15 Sensor, wheel speed, lhs. 1:st driven rear
axle {EE_2 1 D}
A81 Control unit, Serial Interface Box gateway
{BB 0 B}
B15A Sensor, wheel speed, lhs. 1:st driven rear
axle {EE 2 D}
A96 Control unit, Roof cooler {HD 0 C}
A149 Control unit, Telematics Extended Plat- B40A Sensor, brake lining wear indicator, lhs. 1:
form (TESP) {BY 0 B} st front axle {NA 2 C}
A152 Control unit, Telematics Extended Plat- B41A Sensor, brake lining wear indicator, rhs. 1:
form (TESP) {BY 0 D} st front axle {NA 2 D}
B06A Sensor, air pressure, air tank, front {NA 0 B52 Sensor, water level, water separator {HD
D} 1 D}
B06B Sensor, air pressure, air tank, rear {NA 0 B60LF Loudspeaker, left front {JA 1 D}
D}
B60RF Loudspeaker, right front {JA 1 D}
B07 Sensor, fuel level {NA 1 D}
B81 Sensor, Water in fuel {BA 3 B} E27L Tail lamp module, left {CE 0 D} {CG 2 E}
{CK 0 D} {CN 0 D} {EA 1 D}
B96 Sensor, NOx (CAN based) {CV 1 B}
E27R Tail lamp module, right {CE 1 D} {CG 3 E}
B97 Sensor, exhaust temp, upstream catalyst {CK 1 D} {CN 3 D} {EA 2 D}
{CV 3 D}
E30LP Lamp, full-and dipped beams, left {CE 3
B102 Sensor, Oil temperature {BA2 3 A} E} {CE 1 D} {CN 1 D}
B118 Sensor, Oil pressure {BA2 2 A} E30LS Lamp, full- and dipped beams, left {CE 1
C} {CE 3 D}
B133 Sensor, Air filter restriction {BA 1 C}
E30RP Lamp, main and dipped beams, right {CE
1 D} {CE 4 D} {CN 2 D}
B139 Sensor, Rail pressure {BA2 2 A}
E16DS Lamp, instep light {ER 0 D} R01 Heater, engine preheat {HC 1 D}
E16PS Lamp, instep light {ER 0 D} R05 Heater, air dryer {HM 0 C}
E17A Bulb interior light {ER 2 C} R09 Heater, fuel filter {HM 1 C}
R23E Heater, AdBlue hose {CV 1 D} S47 Position switch, low split indicator, NO.
{LS 0 C}
R23G Heater, AdBlue hose {CV 2 D}
S47A Break contact split {MB 0 C}
R23H Heater, AdBlue hose {CV 1 D}
S48 Closing contact, brake lights {CK 0 C}
R23J Heater, AdBlue hose {CV_2 1 C}
S49 Closing cont/ Rev. lights {EA 1 D}
R36 Heater, AdBlue Filter Housing {CV 1 D}
S58B Position switch, clutch pedal, NO. {BA 1
B}
S02 Stalk switch, full- / dipped beams {CG 0
B} {CN 1 B}
S61 Position switch, seat belt lock, NC. {NA 2
C}
S02A Switch, full beams and dipped beams {CE
4 A} {CE 3 A} {CE 0 A} {CG 4 C} {FA 2 B}
S63 Contact low range {LS 0 C}
S04 Switch, climate fan, selector type {HA 0
C} S71 Pressure switch, compressor charging,
NO. {BA 2 D}
S06 Stalk switch, windscreen wiper, selector
type {GA 1 B} S76A Switch, extra spotlights {CF 0 B}
S07 Switch, engine brake, selector type {CL 0 S77 Switch, emergency call {BY 3 D}
C}
S90 Position switch, Neutral {BA 2 D}
S07A Switch, engine brake, selector type {CL 1
C} S103 Switch, heated mirror, mirror adjustment
{HG 2 B}
S08 Switch, differential gear lock, rear wheels
{DL 1 B} S103B Switch, heated mirror {HG 0 C}
S11 Switch, bogie lift, selector type {MA 1 B} S105 Switch, hazard warning lights {CN 2 A}
S11A Switch, bogie lift, selector type {MD 1 C} S106_DD Switch, Passenger window winder (Driver
Side) {KA 1 B}
S15 Switch, ignition, selector type {AA 2 C}
S106_DP Switch, Passenger window winder (Pas-
S19 Switch extra {EZ 1 B} senger Side) {KA 1 D}
S28A Switch, power take-off 1 {LD 3 C} S107 Switch, Driver window winder {KA 2 B}
S30 Switch unit, multi-function display {NA 2 S117 Position switch, differential lock, rear in-
A} teraxle {DL 1 C}
S41 Switch, battery main switch control {AA 1 S152 Switch, 5th wheel position {FW 0 B}
C}
S207 Switch, Panic alarm {BX 1 B} Y05 Solenoid valve, bogie lift {MA 1 D}
S232 Switch, Safety mode {MC 2 C} Y05A Solenoid valve, front 2nd axle lift {MD 3
D}
U06R11 Voltage converter 11A {EX 0 C}
Y06 Solenoid valve, range inhibitor {LS 1 C}
U06R19 Voltage converter 19A {EX 1 C}
Y06A Solenoid valve, range inhibitor {LS 1 C}
V01 Diode {LD 2 C}
Y11 Solenoid valve unit, ABS, lhs. front {EE 0
V02 Diode {LD 2 C} D}
V03 Diode {LD 0 C} Y11A Solenoid Valve Unit, ABS, lhs. Front {EE_
2 0 D}
V04 Diode {LD 0 C}
Y12 Solenoid valve unit, ABS, rhs. front {EE 1
D}
V05 Diode {CE 2 B}
V22 Diode {HA 3 B} Y14 Solenoid valve unit, ABS, rhs. rear {EE 3
D}
V25 Diode {CL 1 D}
Y14A Solenoid Valve Unit, ABS, lhs. Rear {EE_
V27 Diode {MA 1 C} 2 2 D}
V28 Diode {MD 1 D} Y15A Solenoid Valve Unit, ABS, lhs. 3:rd Axle
{EE_2 3 D}
W06 Antenna, GSM {BY 4 B}
Y16A Solenoid Valve Unit, ABS, lhs. 3:rd Axle
W12 Antenna, GPS {BY 4 A} {EE_2 3 D}
X02 Trailer connection, ABS/EBS {EF 2 C} Y18 Solenoid valve, PTO (Power Take Off)
{LD 3 D}
X03 Trailer connection, 15-pole unit {CK 2 D}
{CN 1 E} {EA 3 D} Y18A Solenoid valve, PTO (power take-off) {DP
2 B}
X04 Trailer connection, 7-pole unit, 24 N {CE
2 D} {CK 2 C} {CN 1 D} {EA 3 D} Y27 Solenoid valve, low split {MB 0 C}
X07 Socket 12V {EX 1 D} Y31 Solenoid valve, area inhibitor {LS 2 C}
X54 Connector, Engine (B+) power {AA 0 D} Y33A Solenoid valve, (Unit Injector 1) {BA2 1 D}
Y01 Solenoid valve, exhaust brake {CL 2 C} Y33C Solenoid valve, (Unit Injector 3) {BA2 1 D}
BL.................................................... Blue
BN ................................................... Brown
GN................................................... Green
GR................................................... Grey
OR................................................... Orange
P...................................................... Pink
R...................................................... Red
IS..................................................... Black
VO................................................... Violet
W..................................................... White
Y...................................................... Yellow
Note: If an electrical cable has two colours, it will be marked as shown below: Y/R = Yellow/Red.
Last page