Beruflich Dokumente
Kultur Dokumente
Wiring Diagram
VM, EM-EU5, CHID E149891-
Foreword
The descriptions and service procedures contained in this manual are based on designs and
methods studies carried out up to May 2014.
The products are under continuous development. Vehicles and components produced after the
above date may therefore have different specifications and repair methods. When this is judged
to have a significant bearing on this manual, an updated version of this manual will be issued to
cover the changes.
In service procedures where the title incorporates an operation number, this is a reference to V.
S.T. (Volvo Standard Times).
Service procedures which do not include an operation number in the title are for general
information and no reference is made to V.S.T.
The following levels of observations, cautions and warnings are used in this Service
Documentation:
Note: Indicates a procedure, practice, or condition that must be followed in order to have the
vehicle or component function in the manner intended.
Caution: Indicates an unsafe practice where damage to the product could occur.
Warning: Indicates an unsafe practice where personal injury or severe damage to the product
could occur.
Danger: Indicates an unsafe practice where serious personal injury or death could occur.
All rights reserved. No part of this publication may be reproduced, stored in retrieval system,
or transmitted in any forms by any means, electronic, mechanical, photocopying, recording or
otherwise, without the prior written permission of Volvo Truck Corporation .
Contents
Example of wiring diagram ........................................................................................................1
Illustrations............................................................................................................................ 54
List of relays........................................................................................................................... 95
List of connectors................................................................................................................... 97
+ Battery voltage.
+ 30 Voltage with S12 key connected (main switch).
+ DR Voltage with the ignition switch in the driving position,
the preheating position and the starting position.
Connection point.
Fuse.
Switch.
Relay.
Connector MB pin 9.
BX Telematics.........................................................................................
......................................... page 11
BY Dynafleet.................................................................................................................................... page 12
CN ................................................... page 18
Bending light...........................................................................
DC ................... page 22
Gear Selector ECU, I-Shift .....................................................................................
DP ............................................................. page 24
I-Shift.............................................................................
EE ........................................ page 26
ABS 4 Channels ................................................................................
EF .................... page 28
ABS, Trailer connection.........................................................................................
GA ......... page 34
Windscreen wiper and washer .........................................................................................
HA ................... page 35
Climate unit air conditioner.....................................................................................
HD .............................. page 37
Charge air cooler .........................................................................................
HM .............................................. page 39
Fuel filter heater...........................................................................
JA ......................... page 40
Radio on dashboard .........................................................................................
JB ......... page 41
Radio on upper shelf.........................................................................................................
KH ........................................ page 43
Central door locking...........................................................................
MA ......................................... page 46
Second tag axle lift ...........................................................................
MB ................................................... page 47
Split gearbox...........................................................................
NC Tachograph................................................................................................................................ page 51
ZA ........................................ page 52
Earth connection................................................................................
Note: The following illustrations show the locations of connectors in their respective components. Some connectors may not
appear to be connected because the location of their components varies according to the design of the bodybuilder.
C3070813
FH 3.5 Rear view mirror defogger, left and right ................................................................................... {EA 0 A}
FH 3.6 Trailer Brake / Brake Light Relay / Reverse Lamp Relay.......................................................... {EA 0 A}
FH 4 Fuse Group 4
FH 5 Fuse Group 5
FH 6 Fuse Group 6
FH 7 Fuse Group 7
FH 8 Fuse Group 8
FH 9 Fuse Group 9
FH 10.1 Left full beam / Right full beam / Daytime running lamps .......................................................... {CE 3 A}
FH 11 Fuse Group 11
XT62:12 {GA 2 D}
XT62:13 {GA 3 C}
XT62:14 {GA 2 C}
XT62:15 {GA 3 C}
Y18G:1 {DP 2 B}
Y18G:4 {DP 2 B}
A12 Control unit, ABS (Anti-lock Brake Sys- B12B Sensor, tachograph / speedometer {NC 2
tem) {EE 0 B} E}
A13 Control Unit ABS, Anti-Lock Brake Sys- B13 Sensor, wheel speed, lhs. 1:st front axle
tem, 6 channels {EE_2 0 B} {EE_2 0 D}
A13E Control unit, TECU (automatic transmis- B13A Sensor, wheel speed, lhs. 1:st front axle
sion) {DP 0 C} {EE 0 D}
A33 Tachograph {NC 0 B} B14 Sensor, wheel speed, rhs. 1:st front axle
{EE_2 1 D}
A62 Control unit, ADS (AdBlue Dosing Sys-
tem) {CV 0 C} B14A Sensor, wheel speed, rhs. 1:st front axle
{EE 1 D}
A81 Control unit, Serial Interface Box gateway
{BB 0 B} B15 Sensor, wheel speed, lhs. 1:st driven rear
axle {EE_2 1 D}
A96 Control unit, Roof cooler {HD 0 C}
B15A Sensor, wheel speed, lhs. 1:st driven rear
axle {EE 2 D}
A109 Control unit, GSECU (Gearshift ECU)
{DC 1 B}
B16 Sensor, wheel speed, rhs. 1:st driven rear
axle {EE_2 2 D}
A113 Climate unit, Compressor {HA 0 D}
A146 Control Unit, Tracking System {BX 1 C} B25 Sensor, accelerator pedal {BA 2 B}
A149 Control unit, TESP (Telematics Extended B30A Sensor, Load indicator, rhs. 2nd front axle
Platform) {BY 0 B} {MD 3 D}
A150 Control Unit, TGW II (Telematics Gate- B40A Sensor, brake lining wear indicator, lhs. 1:
way) {BY 2 B} st front axle {NA 2 C}
A152 Control unit, TESP (Telematics Extended B41A Sensor, brake lining wear indicator, rhs. 1:
Platform) {BY 0 D} st front axle {NA 2 D}
B06A Sensor, air pressure, air tank, front {NA 0 B52 Sensor, water level, water separator {HD
D} 1 D}
B81 Sensor, Water in fuel {BA 3 B} E30R Lamp, full- and dipped beams, right {CE 4
D} {CE 1 D} {CN 2 D}
B96 Sensor, NOx (CAN based) {CV 1 B}
E30RS Lamp, full-and dipped beams, right {CE 4
D} {CE 1 C}
B97 Sensor, exhaust temp, upstream catalyst
{CV 3 D}
G01A Battery {AA 1 D}
B133 Sensor, Air filter restriction {BA 1 C}
G01B Battery {AA 1 D}
B143 Sensor, temperature dosing unit {CV 2 D}
G02 Alternator {AA 1 D}
E03L Lamp, spot light, left {CF 1 D}
H01 Horn, air-operated {FA 0 D}
E03R Lamp, spot light, right {CF 1 D}
H09 Horn, Electric {FA 2 D}
E05 Lamp, 5:th wheel light {FW 1 C}
M01 Motor, windscreen wiper {GA 2 D}
E07L Lamp, fog light, left {CG 1 D}
M02 Motor, windscreen washer pump {GA 0
D}
E07R Lamp, fog light, right {CG 1 D}
E16PS Lamp, instep light {ER 0 D} R01 Heater, engine preheat {HC 1 D}
E17A Bulb interior light {ER 2 C} R05 Heater, air dryer {HM 0 C}
E17RR Bulb interior light {ER 2 C} R09 Heater, fuel filter {HM 1 C}
E27L Tail lamp module, left {CE 0 D} {CG 2 E} R14 Termination resistor {BA 0 D}
{CK 0 D} {CN 0 D} {EA 1 D}
R17 Resistor {HA 1 C}
E27R Tail lamp module, right {CE 1 E} {CG 3 E}
{CK 1 D} {CN 3 D} {EA 2 D} R23A Heater, AdBlue hose {CV_2 2 C}
R23D Heater, AdBlue hose {CV_2 1 C} S44-R Break contact, interior light {ER 1 C}
R23E Heater, urea hose,press.line,unisolated S45 Position switch, differential gear lock indi-
part {CV 1 D} cator, rear wheels, NC. or NO. {DL 0 C}
R23G Heater, urea hose,backflow to pump,uni- S47 Position switch, low split indicator, NO.
solated part {CV 2 D} {LS 0 C}
R23H Heater, urea hose,backflow to tank,uniso- S47A Break contact split {MB 0 C}
lated part {CV 1 D}
S48 Closing contact, brake lights {CK 0 C}
R23J Heater, AdBlue hose {CV_2 1 C}
S49 Closing cont/ Rev. lights {EA 1 D}
R36 Heater, AdBlue filter housing {CV 1 D}
S58B Position switch, clutch pedal, NO. {BA 1
R51 *opt* {CV 1 B} B}
S02 Stalk switch, full- / dipped beams {CG 0 S61 Position switch, seat belt lock, NC. {NA 2
B} {CN 1 B} C}
S02A Switch, full beams and dipped beams {CE S63 Contact low range {LS 0 C}
0 A} {CE 4 A} {CE 3 A} {CG 4 C} {FA 2 B}
S71 Pressure switch, compressor charging,
S04 Switch, climate fan, selector type {HA 0 NO. {BA 2 D}
C}
S76A Switch, extra spotlights {CF 0 B}
S06 Stalk switch, windscreen wiper, selector
type {GA 1 B} S77 Switch, emergency call {BY 3 D}
S07 Switch, engine brake, selector type {CL 0 S90 Position switch, Neutral {BA 2 D}
C}
S103 Switch, heated mirror, {HG 2 B}
S07A Switch, engine brake, selector type {CL 1
C}
S103B Switch, heated mirror {HG 0 C}
S30 Switch unit, multi-function display {NA 2 S152 Switch, 5th wheel position {FW 0 B}
A}
S171 Switch, GLU (Gearlever unit) {DC 1 D}
S41 Switch, battery main switch control {AA 1
C}
S196 Switch, double speed rear axle, NO {NC
3 D}
S43 Pressure switch, parking brake indicator,
NC. {BA 1 D}
S232 Switch, Safety mode {MC 2 C} Y05A Solenoid valve, bogie lift {MD 3 D}
U06R11 Voltage converter 11A {EX 0 C} Y06 Solenoid valve, range inhibitor {LS 1 C}
U06R19 Voltage converter 19A {EX 1 C} Y06A Solenoid valve, range inhibitor {LS 1 C}
V01 Diode {LD 2 C} Y11 Solenoid valve unit, ABS, lhs. front {EE 0
D}
V02 Diode module {LD 2 C}
Y11A Solenoid Valve Unit, ABS, lhs. Front {EE_
V03 Diode {LD 0 C} 2 0 D}
V04 Diode {LD 0 C} Y12 Solenoid valve unit, ABS, rhs. front {EE 1
D}
V05 Diode {CE 2 B}
Y12A Solenoid Valve Unit, ABS, lhs. Front {EE_
2 1 D}
V06 Diode {CE 2 B}
V25 Diode {CL 1 D} Y14A Solenoid Valve Unit, ABS, lhs. Rear {EE_
2 2 D}
V27 Diode {MA 1 C}
Y15A Solenoid Valve Unit, ABS, lhs. 3:rd Axle
V28 Diode {MD 1 D} {EE_2 3 D}
W06 Antenna, GSM {BY 4 B} Y16A Solenoid Valve Unit, ABS, lhs. 3:rd Axle
{EE_2 3 D}
W12 Antenna, GPS {BY 4 A}
Y18 Solenoid valve, PTO (Power Take Off)
X02 Trailer connection, ABS/EBS {EF 2 C} {LD 3 D}
X03 Trailer connection, 15-pole unit {CK 2 D} Y18A Solenoid valve, PTO (Power Take Off)
{CN 1 E} {EA 3 D} {DP 2 B}
X04 Trailer connection, 7-pole unit, 24 N {CE Y27 Solenoid valve, low split {MB 0 C}
2 D} {CK 2 C} {CN 1 D} {EA 3 D}
Y31 Solenoid valve, area inhibitor {LS 2 C}
X07 Socket 12V {EX 1 D}
Y41L Electrically operated rearview mirror, left
X54 Connector, Engine (B+) power {AA 0 D} {HG 0 D}
BL.................................................... Blue
BN ................................................... Brown
GN................................................... Green
GR................................................... Grey
OR................................................... Orange
P...................................................... Pink
R...................................................... Red
IS..................................................... Black
VO................................................... Violet
W..................................................... White
Y...................................................... Yellow
Note: If an electrical cable has two colours, it will be marked as shown below: Y/R = Yellow/Red.
Last page