Beruflich Dokumente
Kultur Dokumente
Using the
ATC Lite Application
with ATC200-LITE-USB
Teletilt® Control System
WARRANTY NOTICE
Proper installation procedures must be followed when
installing and operating RET equipment. Failure to assure
installations are done properly by trained installation personnel
and to follow procedures discussed in this bulletin may cause
warranty for such products to be void.
Andrew requires that all RET installations be pre-tested and
configured prior to installation using the latest controller
software version. Failure to conduct pre-test and pre-installation
procedures defined by Andrew will void warranty.
SAFETY NOTICE
The installation, maintenance, or removal of an antenna
requires qualified, experienced personnel. Andrew installation
instructions are written for such installation personnel.
Antenna systems should be inspected once a year by qualified
personnel to verify proper installation, maintenance, and
condition of equipment.
Andrew disclaims any liability or responsibility for the results
of improper or unsafe installation practices.
Do not install near power lines. Do not install on a wet or Wear shoes with rubber soles
Power lines, telephone lines, windy day or when and heels. Wear protective
and guy wires look the same. lightning or thunder is clothing including a
in the area. Do not use long-sleeved shirt and rubber
Assume any wire or line can
metal ladder. gloves.
electrocute you.
1.0 Introduction
This document describes how to upgrade actuator firmware of Andrew actuators using the
ATC200-LITE-USB portable controller. Please note that the portable controller requires AC power
supply.
The Andrew ATC Lite controller software is required to be installed on a laptop. Visit the Andrew
website at www.andrew.com to download the latest software and installation instructions.
2.0 Options
In order to upgrade actuator firmware, the Andrew portable controller needs to have a data
connection to the actuator. That can be achieved in three different ways.
Antenna
RET
Cable
ATC200-LITE-USB
Portable Controller PC
Figure 2-1. Option 1: Upgrading Actuator Firmware Through a RET Jumper Cable.
Required Material:
1 ea ATC200-LITE-USB
1 ea Short RET cable, e.g. ATCB-B01-001
1 ea Laptop with the latest version of ATC Lite running on Windows 2000, XP, or Vista operating system
Top Smart
Bias Tee Home Run
RET Cable
Coaxial
Cable ATC200-LITE-USB
~
~~~ ~
~~~ Portable Controller
BTS
Required Material:
1 ea ATC200-LITE-USB
1 ea Home run cable, e.g. ATCB-B01-060
1 ea Laptop with the latest version of ATC Lite running on Windows 2000, XP, or Vista operating system
ATBT-
Bottom-24V
Smart Bias
RET Tee
BTS RET BTS Cable
Cable
Required Material:
1 ea ATC200-LITE-USB
1 ea Short RET cable, e.g. ATCB-B01-001
1 ea Bottom SBT, e.g. ATBT-BOTTOM-24 V
1 ea Laptop with the latest version of ATC Lite running on Windows 2000, XP, or Vista operating system
Command Status/Response
window displays activity.
Click Yes
3. After completing required firmware updates, the application will begin gathering all information on
devices attached to the bus.
After the firmware update, the version can be checked by selecting an actuator device and clicking
on the Get Device Info button (Figure 4-3). Check to verify that the version showing is the desired
version (Figure 4-4).