Beruflich Dokumente
Kultur Dokumente
1. The operation of making hole in a piece part with the help of die is called:
a. Reduce the friction between the wheel face and the job
ANS: A
a. Flutes
b. Threads
c. Diameter
d. Relief
ANS: A
3. The best method of avoiding accident is by observing _____ related to job, machine and
workplace
a. Blade
b. Safety precautions
c. Piercing
d. Thread
ANS: B
4. The pin must be somewhat smaller than the hole; the difference in sized is cared for by the
______, which for running fits, is the minimum specified difference between the dimensions of
the pin and the hole:
a. Tolerance
b. Allowance
c. Fit
d. Unilateral
ANS: B
5. Wide belts with multiple longitudinal V- grooves that run with matching grooves on the sheaves:
a. Flat V- belts
b. V- belts
c. Ribbed belts
ANS: C
a. 10,000
b. 20,000
c. 30,000
d. 40,000
ANS: B
7. Helical gear often have large active _____ compared to spur gear of the same pitch:
a. Face width
b. Addendum
c. Dedendum
d. Clearance ratio
ANS: A
8. Straight and Zerol bevel gears should not be used when the pitch-line speed is greater than
about:
a. 100 fpm
b. 1000 fps
c. 1000 fpm
ANS: C
9. Has been found to be an excellent combination from the standpoint of wear and friction if thin-
film lubrication exists:
10. Managing nickel steels attain yield strength of as much as _____ without quenching:
a. 250 ksi
b. 300 ksi
c. 200 ksi
d. 500 ksi
ANS: A
a. 1/Pd
b. 1.25/Pd
c. 1/Pc
d. 1.25/Pc
ANS: A
12. When grease are heat treated after the teeth are cut, the profile error will:
a. Increase
b. Decrease
c. Remains constant
d. Decrease slightly
ANS: A
13. A type of spring composed of flat bars of varying length clamped together:
a. Motor spring
b. Leaf spring
c. Negator spring
d. Helical spring
ANS: B
14. This type of bearing is often used in opposite pair and are suited for preloading:
a. Viscosity
b. Centipoise
c. Reyn
d. Kinematics viscosity
ANS: D
b. Brass aluminum
c. Titanium
ANS: D
16. One manufacturer indicates that the breaking strength of ¼ to 2/4 in. aluminum bolts is
about ____ ksi based on the stress area:
a. 61-62
b. 62-64
c. 64-66
d. 68-70
ANS: B
17. This expression is interpreted to mean that the probability of a particular bearing surviving
the given time is 90%:
a. 90% life
b. 90% efficiency
c. 90% loading
d. 90% tough
ANS: A
a. Disk
b. Drum
c. Clutch
d. Brakes
ANS: C
19. Oil tempered SW is cold draw to size and then hardened & tempered & it has usually has
carbon content of:
a. 0.55-0.75%
b. 0.65-0.70%
c. 0.60-0.65%
d. 0.60-0.80%
ANS: A
20. The type of variable loading which the stress varies from a certain minimum value to
maximum value in the same direction:
a. Varying type
b. Repeated
c. Fluctuating
d. Reversed
ANS: B