Beruflich Dokumente
Kultur Dokumente
Date: 27.09.2010
Operator: Rafe
Project 1
27.09.2010
Disano 825 Comfort - opal diffuser Disano 825 FL 4X18 CNR white / Luminaire Data
Sheet
Luminous emittance 1:
105° 105°
90° 90°
75° 75°
60° 60°
80
45° 45°
120
Lampholder: In polycarbonate, with contacts in phosphor bronze. Socket 2H 2H 15.6 17.0 15.9 17.2 17.4 15.7 17.0 16.0 17.2 17.5
G13. 3H 17.4 18.6 17.7 18.8 19.1 17.4 18.6 17.7 18.9 19.2
4H 18.0 19.1 18.3 19.4 19.7 18.1 19.2 18.4 19.5 19.8
Electric gear: 230V/50Hz power supply. Hard wire, 0.50 sqmm cross section, 6H 18.4 19.4 18.8 19.7 20.1 18.5 19.5 18.8 19.8 20.1
and PVC-HT sheath, resistant up to 90°C, according to CEI 20-20 standards. 8H 18.5 19.5 18.9 19.8 20.2 18.6 19.6 19.0 19.9 20.3
12H 18.6 19.5 19.0 19.9 20.2 18.7 19.6 19.0 20.0 20.3
2P+T terminal block w/ or w/o fuseholder, with maximum allowed lead cross
4H 2H 16.2 17.3 16.6 17.6 17.9 16.2 17.4 16.6 17.7 17.9
section of 2.5 sqmm. 3H 18.2 19.1 18.5 19.5 19.8 18.2 19.2 18.6 19.5 19.9
Mounting: recessed in module 600 shooks or panels. 4H 18.9 19.8 19.3 20.1 20.5 19.0 19.9 19.4 20.2 20.6
Equipment: 6.3A protection fuse (art. CNR-R). Supplied without brackets for 6H 19.4 20.2 19.9 20.6 21.0 19.5 20.3 20.0 20.7 21.1
8H 19.6 20.3 20.0 20.7 21.1 19.7 20.4 20.1 20.8 21.2
direct contact mounting onto the cross Ts. In case of non-contact mounting, 12H 19.7 20.3 20.2 20.7 21.2 19.8 20.4 20.3 20.8 21.3
use brackets acc.900. 8H 4H 19.2 19.9 19.6 20.3 20.7 19.3 20.0 19.7 20.4 20.8
Regulations: Produced according to applicable EN60598-1 CEI 34-21 6H 19.9 20.4 20.3 20.8 21.3 19.9 20.5 20.4 20.9 21.4
8H 20.1 20.6 20.6 21.0 21.5 20.2 20.7 20.7 21.1 21.6
standards, IP40IK03 degree of protection according to EN 60529 standards 12H 20.2 20.7 20.7 21.1 21.6 20.3 20.7 20.8 21.2 21.7
and approved by the Italian Body for Quality Marking (IMQ). They have 12H 4H 19.2 19.8 19.7 20.3 20.7 19.3 19.9 19.7 20.3 20.8
obtained the ENEC European Certificate of Conformity. These products can 6H 19.9 20.4 20.4 20.8 21.3 20.0 20.5 20.5 20.9 21.4
be installed on normally inflammable surfaces. 8H 20.2 20.6 20.7 21.1 21.6 20.3 20.7 20.8 21.2 21.7
Additional gear: Electronic ballast. Variation of the observer position for the luminaire distances S
Emergency light version: If a black-out occurs, only one lamp connected to S = 1.0H +0.1 / -0.1 +0.1 / -0.1
the emergency circuit will stay on, thus avoiding the inconvenience caused S = 1.5H +0.2 / -0.3 +0.2 / -0.3
S = 2.0H +0.4 / -0.7 +0.4 / -0.6
by a sudden absence of all light. It has a 60-minute emergency run time.
When power is restored, the battery recharges automatically. Standard table BK06 BK06
Correction
-5.3 -5.3
Summand
Corrected Glare Indices referring to 5400lm Total Luminous Flux
Page 2
Project 1
27.09.2010
1 2
Surface Rho [%] from ( [m] | [m] ) towards ( [m] | [m] ) Length [m]
Floor 20 / / /
Ceiling 70 / / /
Wall 1 50 ( 0.000 | 0.000 ) ( 10.000 | 0.000 ) 10.000
Wall 2 50 ( 10.000 | 0.000 ) ( 10.000 | 4.500 ) 4.500
Wall 3 50 ( 10.000 | 4.500 ) ( 0.000 | 4.500 ) 10.000
Wall 4 50 ( 0.000 | 4.500 ) ( 0.000 | 0.000 ) 4.500
Page 3
Project 1
27.09.2010
1 2
Surface Rho [%] from ( [m] | [m] ) towards ( [m] | [m] ) Length [m]
Floor 20 / / /
Ceiling 70 / / /
Wall 1 50 ( 0.000 | 0.000 ) ( 10.000 | 0.000 ) 10.000
Wall 2 50 ( 10.000 | 0.000 ) ( 10.000 | 4.500 ) 4.500
Wall 3 50 ( 10.000 | 4.500 ) ( 0.000 | 4.500 ) 10.000
Wall 4 50 ( 0.000 | 4.500 ) ( 0.000 | 0.000 ) 4.500
Page 4
Project 1
27.09.2010
Room 1 / Summary
4.50 m
440 400
440 480 440 3.75
480
0.50
0.00
0.00 1.25 3.75 6.25 8.75 10.00 m
Height of Room: 2.800 m, Mounting Height: 2.882 m, Maintenance factor: Values in Lux, Scale 1:72
0.80
Specific connected load: 21.87 W/m² = 4.71 W/m²/100 lx (Ground area: 45.00 m²)
Page 5
Project 1
27.09.2010
1 2
Surface Rho [%] from ( [m] | [m] ) towards ( [m] | [m] ) Length [m]
Floor 20 / / /
Ceiling 70 / / /
Wall 1 50 ( 0.000 | 0.000 ) ( 10.000 | 0.000 ) 10.000
Wall 2 50 ( 10.000 | 0.000 ) ( 10.000 | 4.500 ) 4.500
Wall 3 50 ( 10.000 | 4.500 ) ( 0.000 | 4.500 ) 10.000
Wall 4 50 ( 0.000 | 4.500 ) ( 0.000 | 0.000 ) 4.500
Page 6
Project 1
27.09.2010
Disano 825 Comfort - opal diffuser Disano 825 FL 4X18 CNR white
5400 lm, 82.0 W, 1 x 4 x FL18/4/3B (Correction Factor 1.000).
3 6 9 12
2 5 8 11
1 4 7 10
Page 7