Beruflich Dokumente
Kultur Dokumente
Page 1 of 2
Home > CQ > Service Bulletins > Line Filter for DM-TR20 Turret Controller
SB # 1266
Rev. A
FSB/SWB/TIN Ref#
Action Mandatory
Date 7/26/2018
By Wayne Kline
Status Approved
Category Electrical
Description Machines listed in effectivity did not have a line filter for the Turret Controller.
On these units, the line power for the Turret Controller was wired into the
Rexroth filter. It is mandatory that the frames listed in the effectivity section
are retrofitted with a new line filter for the Turret Controller.
Machines wired this way may have an "Alarm 7: IGBT Failure or high current"
or the Turret Controller may fail completely. WinMax will report the following
error message:
ALARM: Turret Controller Fault detected.
Controller reports Short circuit on power stage: check servomotor wiring or
motor or controller may have internal damage.
A change has been implemented in manufacturing to add a new line filter for
the Turret Controller and no longer use the Rexroth filter for this device.
Please order and install the parts listed in the Materials section below and use
the appropriate schematic drawing (for MY or MYS models) to install the parts.
For frames that have the new filter, confirm that the Turret Controller filter is
not connected to the Rexroth filter.
Tables, Charts
https://partner.hurco.com/CQ/Lists/Service%20Bulletins/DispForm.aspx?ID=1266 8/24/18
Service Bulletins - Line Filter for DM-TR20 Turret Controller... Page 2 of 2
TMX8MYS: HTS80054
TMX8MYS VDI: HTSV80001~0007
TMX10MY: HTY100017
TMX10MY VDI: HTYV10001~3
TMX10MYS: HTS100019~0021
TMX10MYS VDI: HTSV100001~0006
Materials 409-0001-030; Filter, Noise 3 Phase, 10 Amp, 1 ea.
110-0046-005; LOCKWASHER, M4 HELICAL SPRING, 4 ea.
109-5024-003; PPHMS, M4 X 0.7 X 8MM LG, 4 ea.
Software Requirements Not Applicable
Procedure Wire the new line filter per the attached schematics, (Wiring Changes.pdf).
Confirm that the turret line filter is not connected to the Rexroth line filter as
shown in the attached, (004-1810-011 Rev C is Correct.pdf).
Fig.1
Fig.2
Fig.3
Fig.4
Fig.5
Fig.6
Fig.7
Fig.8
Fig.9
Fig.10
Assigned To
Version: 15.0
Created at 4/10/2017 8:52 AM by Kline, Wayne
Last modified at 8/22/2018 9:36 AM by Stroup, Julie
https://partner.hurco.com/CQ/Lists/Service%20Bulletins/DispForm.aspx?ID=1266 8/24/18
Correct
X X
X' X'
S1 S1
Z Z
S2 S2
W W
FAN
S3 S3
IN IN
H U R C O C O M P A N I E S , I N C ., IN D I A N A P O L IS , I N D IA N A 4 6 2 6 8 , U S A
New Filter
Remove wires 410, 412 and 414 from this
line filter and wire to 401, 402 and 403.
Relabel both ends of wires.