Beruflich Dokumente
Kultur Dokumente
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
I2c ( IF PMIC / FUEL )
IF_PMIC_ESET_N
UART_RXD/TXD, USB_HS_DM/DP
SDC3_DATA[0:7]
T-Flash
MHL_I2C
MHL HD_TX SDC1_DATA[0:7]
MAX CMD/CLK
eMMC
77804 W9010 PEN_I2C MSM_RESOUT_N
(IF PMIC) (wacom) SLEEP_CLK_WIFI
SDC2_DATA[0:3]
BT PCM BT/WIFI
WCD9320 SLIMBUS BT_UART
BT_EN/BT_host_wake/BT
PM8841_RESET_ _WAKE
N
PM8841
PMIC_SPMI_CLK
PMIC_SPMI_DATA MSM8974
D[0:3] MIPI
CIS_SPI
13M CAM
I2C
2M cam
8-1
D[0:1] MIPI
I2C
USB3.0_CLK / SSRX/SSTX
XO_OUT_D0.EN D[0:3] MIPI
SLEEP_CLK_WIFI
19M CLK
PM8941 SLEEP_CLK LCD
TS_I2C
XO-Therm (PMIC) PM8941_PON_RESET_N
NFC_EN
MSM_Therm
BATT_Therm
PA_Therm
MSM_PS_HOLD
NFC_I2C NFC
NFC_EN NFC_FIRMWARE
NFC_IRQ
WTR0_BB
WTR0_GPS SHUB_SPI
MCU_AP_INT Sensor
SensorHub
HUB
WTR1605L SENSOR_I2C
8. Level 3 Repair
(TRCV) Gesture
(VT cam)
SENSOR_I2C
8-1. Block Diagram
8-2
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-2-2. Bottom
8-3
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-4
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-5
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
Equipments
8-6
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-3-1. Power On
Yes
No
Yes
Yes
No
Check the Clock OSC600 Change the OSC600
Is that frequency 19Mhz?
※ Test condition (Oscilloscope setting)
: 20.0us.div (time division)
Yes
END
8-7
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
GND_XOADC 2 1 19M_IN
19M_OUT
3 4
C608 OSC600
XO_THERM
R603
C604
VREF_XO
VSW_S8
92
VSW_S8
83
VSW_S8 L611
82
VSW_S7
64
VSW_S7
63
VSW_S6 L610
28
VSW_S6
27 C653 C651 C650 C648 C647 C646
VSW_S5 L609
12
VSW_S5
11 C649
VSW_S5 L608
3
VSW_S4
96
VSW_S4
88
VSW_S4 L607
87
VSW_S3
71
VSW_S2
17
L606
VSW_S2
16
VSW_S2 L605
7
VSW_S1
44
L604
MPP_04
86 TP_603
MPP_03
78 TP_602
MPP_02
34 TP_601
MPP_01
33 TP_600
VREG_S4B_0P9 VREG_S2B_0P9
8-8
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-3-2. Initial
Initial Failure
Yes
Abnormal
Re Check "8-3-1 Power on" Abnormal Check the OSC600 (Crack, open etc.)
Trouble shooting process Check the U603, U606 (Crack etc)
Normal
Change UME500
Abnormal
Change PBA
END
L208
U202
202
L
TP209
P20
P2
209
U843
3
7 U843
TP
TP210
P21
P2
210 R214
214
14 C220
22
22
200
BAT600
BA
BAT600
AT
T6
T600
60
00
C849
C849
9
R216
216
16 215
C6 7 2
C672
R213
213 R217
217
U817
17
81
R2
R231
231 C50
C5006
500
0006
6
C825
25
C825
P218
18
TP218
P219
TP219
826
26
C218
C218
C604
C604
R603
R603
C608
TP220
P22
P2
220
20 TP217
P21
P2
217 R211
R211 R212
212 R210
210 C258
258
58 C5007
500
50
0007
7 C611
611 C5008
C5008
50
5 00
00
088
TP
TP
T
R228
22
22
288
OSC600
C601
C601
R628
62
6 2
288
R637
637
63
602
C602
U60
U601
601 U608
U608
608
61
661
1
C661
C
C66
66
C688
688
C5
C5004
5000
00
044
L707
707
70 TP_608
P 608
08
C559
559
C559
L612
C668
L706
706
L7
C698
R458
458
R45 8
C684
C684
C683
U926
C931
931
93
R459
59
R45
C664
C664
R921
92
92
211
R413
413 R918
918
18
D602
022
D601
011
D600
000
60
60
60
R415
415 R915
915
D
R650
65
500 R920
92
92
200
R220
22 0 R223
223 R419
419
685
TP221
21
22
L615
615
15
C680
R2
22
2 27
27
R501
501
R319
319
R510
R510
C230
C230
C236
C236
R50
R51
C247
24
24
477 C248
248
24 C246
246
24 R226
22
22
266 C675
675
75 ZD2
ZD201
201
20
T
C235
C235
R225
R225
R224
R224
C228
228
22
C234
234
34
R649
9
R649
R648
8
R648
TP_500
P 500
00 Z
ZD602
U206
206
C232
232
U304
U304
304
R421
21
R400
00
R401
R42
R40
ANT
ANT203
NT
T2
20
033 AN
ANT202
NT20
NT 022
L211
211
C674
C674
R461
61
R462
62
R46
R46
R451
451
51
C243
243
24 C240
240
24
40 C242
24
24
422 R221
221
22 C676
676 ZD2
ZD200
200
2
200
000 D400
400
40
U
L210
210
L2
8-9
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-3-3. No Service
No service
Yes
PHONE : N9005XXXX
Menu → Phone → Keypad →
*#1234# → check Phone version →
PHONE : N9005XXXX or Check the connection of RF coaxial cable
PHONE : unknown
PHONE : unknown
Yes
Check OSC600 No
Frequency = 19.2MHz Replace the OSC600
Yes
Replace U300
Yes
END
8-10
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
VREG_L20_2P95
VREG_L21_2P
VRE
VREG_S3A_1P8
VREG_S2A_2P15 VREG_LVS1_1P8
CAM_IO_1P8
VREG_S1A_1P3
VREG_LVS3_1P8
VPH_PWR VREG_BOOST_BYP
VREG_S2A_2P15
C624 C625 C626
R607
VREG
BAT600
C628
C627
TP_BAT_THERM
TP_VREF_BAT
TP_VREG_600
TP_BAT_ID
VREG_S1A_1P3
L602
L601
L603
VPH_PWR C631 C632 C633
VPH_PWR
VPH_PWR GND_S3
C639
GND_S2
214
222
223
182
210
169
177
193
218
211
227
103
113
144
151
120
192
140
111
124
133
125
141
174
118
135
161
183
142
GND_S1
63
23
33
87
79
16
32
24
47
31
56
12
35
20
38
28
26
42
27
10
29
13
74
89
18
82
57
85
40
58
98
21
19
22
14
64
96
7
1
9
2
VREG_L8_1P8
VDD_L13_20_23_24
VOUT_5VS_OTG
VDD_L6_12_14_15
VDD_L8_16_18_19
VDD_L9_10_17_22
VDD_TORCH
VOUT_5VS_HDMI
BATFET_CP_DRV
VREG_5V
VREG_5V
VREG_5V_SNS
VREG_S1
VREG_S2
VREG_S3
VREG_RF_CLK|VREG_L5
VREG_XO|VREG_L7
VOUT_LVS1
VOUT_LVS2
VOUT_LVS3
VDD_GPLED
VDD_L2_LVS1_2_3
VDD_L4_11
VREG_FAULT
BAT_THERM
VSW_5V
VSW_5V
VIN_5VS
VDD_INT_BYP
VDD_RGB
VCOIN
VSW_S1
VSW_S2
VSW_S2
VSW_S3
VREG_L1
VREG_L2
VREG_L3
VREG_L4
VREG_L6
VREG_L8
VREG_L9
VREG_L10
VREG_L11
VREG_L12
VREG_L13
VREG_L14
VREG_L15
VREG_L16
VREG_L17
VREG_L18
VREG_L19
VREG_L20
VREG_L21
VREG_L22
VREG_L23
VREG_L24
VDD_FLASH
VDD_L1_3
VDD_L21
VDD_L5_7
VDD_S1
VDD_S2
VDD_S3
VDD_WLED
VREF_BAT
VDD_MSM_IO
VBAT_SNS
VREG_BMS
BMS_CSM
BMS_CSP
BAT_ID
VBAT
VBAT
VBAT
C642
152
37
REF_BYP GND_REF
XO_THERM XO_THERM
139
OTG_IN TP_OTG_IN
170 226
MSM_THERM 138
AMUX_1 PHY_VBUS TP_USB_PHY_VBUS
R609 R608
BATT_THERM 154
AMUX_2
172
AMUX_3 USB_IN
178 173
PA_THERM1 203
AMUX_4 USB_IN
181
AMUX_5 USB_IN
186 220
AMUX_PU1 DC_IN
195 221
AMUX_PU2 DC_IN
229
DC_IN
179
AMUX_USB_ID
R610 162 189
AMUX_HW_ID OVP_OUT
205
OVP_OUT
11 212
19M_IN 3
XTAL_19M_IN DC_IN_OVP_CTL
228
19M_OUT XTAL_19M_OUT DC_IN_OVP_SNS
171
OVP_CP_DRV
69
XO_OUT_A0 XO_OUT_A0 C645
84 187
XO_OUT_A1 VPRE_CAP
60
XO_OUT_A2
200 VPH_PWR
R611 VCHG
75 216
XO_OUT_D0 TP_605 44
XO_OUT_D0 VCHG
217
XO_OUT_D0_EN 83
XO_OUT_D0_EN VCHG_SNS
XO_OUT_D1
208
VSW_SMBC
52 224
USB3.0_CLK_M XO_OUT_DIFF_N VSW_SMBC R612
68 201
USB3.0_CLK_P XO_OUT_DIFF_P VREG_SMBC
70 209
XTAL_32K_IN VDRV_P C654
54
XTAL_32K_OUT
TP606 30 198
VREF_XO SLEEP_CLK SLEEP_CLK VPH_PWR
206
VPH_PWR
188 207
VREF_LPDDR3_CA 213
VREF_DDR3_CA VPH_PWR
VREF_LPDDR3_DQ 46
VREF_DDR3_DQ
123
VREF_XO MPP_01|VREF_PADS
156
SDC_UIM_VBIAS
MPP_02|EXT_BOOST_EN
U606
126 148
97
VSW_WLED MPP_03|VREF_DAC
132
TXDAC0_VREF
150
VREG_WLED MPP_04|PRIVACY_LED
121
EAR_ADC_3.5
WLED_CABC MPP_05|ENET_LDO_EN
127 145
WLED_SNK1 MPP_06|ENET_RST_N
119 136
WLED_SNK2 MPP_07|NFC_EXT_EN
104 153
WLED_SNK3 MPP_08|MHL_RESET_N
80 39
41
GPLED_SNK1 GPIO_01|KYPD_SNS1
53
FLASH_LED_SET
65
GPLED_SNK2 GPIO_02|KYPD_SNS2
62
VOL_DOWN
49
GPLED_SNK3 GPIO_03|KYPD_SNS3
55 OK_SW
GPLED_SNK4 GPIO_04|KYPD_SNS4
61
ERR_FG
66
GPIO_05|KYPD_SNS5
71
VOL_UP
81
GPLED_SRC1 GPIO_06|KYPD_SNS6
77
VT_CAM_STBY
73
GPLED_SRC2 GPIO_07|KYPD_SNS7
94
CAM_SENSOR_DET
88
GPLED_SRC3 GPIO_08|KYPD_SNS8
76
VT_CAM_A_EN
GPLED_SRC4 GPIO_09|KYPD_DRV1
86
TSP_EN
158
GPIO_10|KYPD_DRV2
93
VT_CAM_IO_EN
190
FLASH_DRV_1 GPIO_11|KYPD_DRV3
110
FSA_EN
FLASH_DRV_2 GPIO_12|KYPD_DRV4
157
MAIN_CAM_A_EN
176
GPIO_13|KYPD_DRV5
102
NFC_EN
LED_B 167
RGB_BLU|GP_LED_DRV2 GPIO_14|KYPD_DRV6
109
LCD_1P8_EN
LED_G 160
RGB_GRN|GP_LED_DRV1 GPIO_15|CLK_CODEC
149
DIVCLK1_CODEC
D600 LED_R RGB_RED|LED_ATC|GP_LED_DRV0 GPIO_16|CLK_HAPTICS
165
SLEEP_CLK_WIFI
CHG_DET 72
GPIO_17|CLK_QPA1
117
VIB_DRV_N GPIO_18|CLK_QPA2
43
CRESET_B
GPIO_19|MIPI_DSI_RST_N MLCD_RST
D601 180 36
JIG_ON_N 155
CBL_PWR_N GPIO_20|GOBI_PWR_EN
25
PHONE_ON_N KYPD_PWR_N GPIO_21|EXT_REG_EN1 BOOST_BYP_N
191
OPT_1 GPIO_22|HS_DET
59
EAR_DET
202 34
OPT_2 GPIO_23|KYPD_DRV7
114 105
129
OPT_3 GPIO_24|KYPD_DRV8
51
VT_CAM_NRST
R623 197
OPT_4 GPIO_25|KYPD_DRV9
67
MAIN_CAM_RST
R625 R626 MSM_PS_HOLD PS_HOLD GPIO_26|KYPD_DRV10 FUEL_ALERT
R647 163 184
PHONE_ON_N R624 196
RESIN_N GPIO_27|FLASH_STROBE
194
IRDA_IRQ
PON_1 GPIO_28|TX_GTR_THRESH
159
TX_GTR_THRES
GPIO_29|SD_WP TOUCH_INT
PMIC_SPMI_DATA 147 90 TP_TSP_INT
131
SPMI_DATA GPIO_30|TS_CHGR_IN
143
TSP_INT
PMIC_SPMI_CLK SPMI_CLK GPIO_31|BAT_ALARM
TP_PON_OUT 204 166
PON_OUT 164
PON_OUT GPIO_32|NFC_CLK_REQ
106
PM8941_PON_RESET_N PON_RESET_N GPIO_33|PWM_LED_CTL1
128
MICBIAS_EN_MSM
EAR_MICBIAS_EN
GND_WLED_SMPS
GPIO_34|PWM_LED_CTL2
137
GPIO_35|PWM_LED_CTL3 WACOM_LDO_EN
GND_CHG_HP
GND_CHG_HP
GND_XOADC
146
GPIO_36|PWM_LED_CTL4 HALL_SENSOR_INT
GND_REF
GND_5V
GND_S1
GND_S2
GND_S3
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
NC
NC
100
101
107
108
112
115
116
122
130
175
185
219
225
199
215
168
134
230
231
50
78
91
92
99
48
15
17
95
45
GND_XOADC
GND_S3
GND_S2
GND_S1
GND_REF
VREF_XO
C604 R603
XO_THERM
OSC600 C608
4 3
19M_OUT
1 2
19M_IN GND_XOADC
8-11
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
Yes
No
Is SIM/SD socket ok? Replace SIM/SD socket.
Yes
Yes
END
R404
802 F803
F802 F803
F8
C812
812
12
F80 F8
VPP
VPP
PP
F801
F8 F
T TSP INT
T
F800
F800
00
TP
SIM600
M6 0 0 TP_TFLASH_CMD_3V
FL
LA
LAAS
SH CM
CMD 3V
3V
RFS101
RFS100
FS
S100
C677
677
C691
691
BOTHH
B HHOLE702
H HOL
OLE
LE7
E7002
2
C693
C693
C742
42
R719
19
8-12
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
TA / USB Insert
Yes
Yes
No
Check the CHG_IN_5V(C685)=5V Resolder and Replace U829
Yes
No
Battery is Charging? Resolder or Replace U616
Yes
END
8-13
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
VBUS_DET
VREG_S3A_1P8
L
L601
C654
C624
R643
64
64
433
95
C695
C605
60
055
C69
PWR
PWR_P
WR V_BAT
C607
C622
C606
C687
C666
666
66
C
C673
673
C
C
C
C667
66
677 C670
67
700
C697
C669
669
69 U60
U604
044
L600
WPC_5V
U616
U616 PWR
PWR
WR G
L613
CHG_IN_5V
R642
C696
C671
671 R633
63
63
333
81
C681
C665
C662
8
C68
R632
6 32 C665
6 65
TA6
TA600
600
6
6000
00
C662
V_BATTERY_SENSE
63
63
388
VBATGND_SENSE
6 86
682
82
ZD
ZD603
D6
D60
6003
03
C666
C685
U708
C725
725
C726
726
C7
H5
H6
H2
H3
E9
C7
H8
B8
J5
J6
MVIO
BATT
BATT
BATT
BATT
MVBUS
MVBAT
BAT_SP
BAT_SN
BATT_FG
C1
CHGIN
D1
CHGIN
D2
CHGIN
SUS600
US6
U
USS6
600
000
B2
WCIN
B1
WCIN
E1
BYP
E2
BYP
C2
BYP_W
C3
BYP_W
D3
BYP_W
L613 F1
CHGLX
G1
CHGLX
U8
U829
829
H1 U616
CHGPG
830
83 L809
80
099 J2
CHGPG
C841
841 832
H4
SYS
C831
8 31
C833
PM_SYS_PWR J3
SYS
J4
SYS
C671 G2
AVL
F3
DETBATB
V_BUS_5V CHG_IN_5V
U829
L809 B3 A2
IN OUT
C2 A3
IN OUT
C3 B2
IN OUT
C1 B1
OVLO VBUSDET VBUS_DET
C830
A1 1
OVP_EN
C832
C833
_EN NC
2
NC
GND
GND
GND
C4
A4
B4
8-14
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-3-6. OTG
Yes
Yes
Yes
Yes
END
8-15
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
VBUS_DET
VREG_S3A_1P8
V_BAT
VPH_PWR
WPC_5V
CHG_IN_5V
V_BATTERY_SENSE
C665
VBATGND_SENSE
C662
C664
C667
C666
C685
C686
H5
H6
H2
H3
C7
H8
B8
E9
J5
J6
MVIO
MVBUS
BAT_SN
BATT_FG
BATT
BATT
BATT
BATT
BAT_SP
MVBAT
V_BATTERY_SENSE
C1 A8
D1
CHGIN DN1
A9
USB_HS_DM
CAP X2 D2
CHGIN DP2 USB_HS_DP
V_BUS_5V CHG_IN_5V JTAG_TXD
C683
C684
CHGIN
E8
UT1 UART_TXD
U829 B2
B1
WCIN UR2
D8
UART_RXD
WCIN
E10
JTAG_RXD
E1
SL1
D10
VPS_L
VPH_PWR BYP SR2 VPS_R
L809 E2
BYP
B10
B3 A2 C2
COMN1
C10
MUIC_DM
IN OUT C3
BYP_W COMP2 MUIC_DP
C2 A3 PM_SYS_PWR D3
BYP_W
C9
IN OUT BYP_W BC
C3 B2
L613 F1 C8
IN OUT CHGLX MIC_USB
C1 B1 G1 C687
C669
C670
VBUS_DET
CHGLX
OVLO VBUSDET B9
UID MUIC_ID
C830
H1 D9
CHGPG IDB
VPH_PWR J2 C6
A1 1 CHGPG JIG JIG_ON_N
C832
C833
OVP_EN _EN\ NC
2 H4
SYS ADN1
B7
JTAG_IF_CON_SENSE
VREG_S3A_1P8
NC PM_SYS_PWR J3 A7
SYS ADP2 OVP_EN
GND
GND
GND
J4
SYS
R632
D7
U616 AUR2
C671 G2 E7
D602
AVL AUT1
F3
VF_DETB DETBATB
C4
A4
B4
F2 H7 R633
CHG_DET E3
INOKB QSTRT
G8
WCINOKB VCELL V_BATTERY_SENSE
F8
EO
LED600 A5 J7
FLED1 ALRTB FUEL_ALERT
10V A6
FLED1
G7
B5
SCLFG
F7
FUEL_SCL_1.8V
FLASH_LED_SET B6
TORCHEN SDAFG FUEL_SDA_1.8V
USB_VBUS_MSM_4.9V FLASH_LED_EN FLASHEN
B3
TEST1
C673 A2 C4
SAFEOUT1 TEST2
A3 A4
SAFEOUT2 TEST3
B4
TEST4
H9
VDD_VIB_3P0 IN_MOT
C5
MOTOR_P H10
VCCTEST
MOTOR_N R637 J9
MDN
F4
MDP SYS_A
F5
PM_SYS_PWR
SYS_A R650
C688 G9
MGAIN
G10 G3
VIB_PWM MPWM OVPENB OVP_EN
F6 E5
VREG_S3A_1P8 G6
VIO VBUSDET VBUS_DET
IF_PMIC_SDA_1.8V SDA
A1
NC
F9 A10
IF_PMIC_SCL_1.8V SCL NC
J1
NC
D5 J10
PHONE_ON_N
C698
MRST1B NC
D4 1
INTB NC
D6 2
IF_PMIC_RESET_N RESETB NC
GNDFG
GND_Q
GND_D
GND_A
GND_A
GNDM
C674
F10
G4
G5
E6
E4
J8
VREG_S3A_1P8
R638
MUSB_INT
8-16
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-3-7. Sensor
1. Barcode emulator
Yes
Yes
Yes
No
Barcode
operate correctly? Change VT CAM ASSY module
Yes
END
8-17
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
VREG_L21_2P95
VREG_L20_2P95
VREG_S3A_1P8
VREG_L1_1P2_WO_DDR
C931
C914
R915
R920
B2
F6
A6
A5
A4
F1
VCC
SPI_VCC
VPP_2V5
VCCIO_0|1
VCCIO_2|3
VPP_FAST
B3 E3
A3
GBIN0|PIO0 PIO2|CBSEL0
F3
IRDA_IRQ
B4
GBIN1|PIO0 PIO2|CBSEL1 IRDA_CONTROL
T_FLASH_D(3)_3V GBIN2|PIO1
TP_TFLASH_D0
T_FLASH_CLK_3V C5
GBIN3|PIO1 PIO3|DP01A
B1
T_FLASH_D(0)
F2 A1
FPGA_MAIN_CLK GBIN4|PIO2 PIO3|DP01B T_FLASH_D(1) VREG_S3A_1P8
E2 C2
BARCODE_EN D1
PIO2 PIO3|DP05A
E1
T_FLASH_D(2)
T_FLASH_CLK TP_TFLASH_CMD C1
GBIN6|PIO3|DP06A
U926
PIO3|DP06B T_FLASH_D(3)
T_FLASH_CMD GBIN7|PIO3|DP05B
E5
A2
PIOS|SPI_SCK
F5
FPGA_SPI_CLK
C3
PIO0 PIOS|SPI_SI
E4
FPGA_SPI_SI R917 R918
PIO0 PIOS|SPI_SO
E6 D5
TP_TFLASH_CMD_3V D6
PIO1 PIOS|SPI_SS_B FPGA_SPI_EN
T_FLASH_CMD_3V PIO1
B5 C4
T_FLASH_D(1)_3V PIO1 CDONE
B6 F4
T_FLASH_D(2)_3V TP_TFLASH_D0_3V PIO1 CRESET_B CRESET_B
C6
T_FLASH_D(0)_3V PIO1
GND
GND
GND
NC
NC
R921 GES_PROX_1P8
D3
D2
D4
1
2
GES_LED_3P3
VREG_LVS1_1P8
VT_CAM_SENSOR_A2P8
VT_CAM_1P8
VREG_L19_3P3
R841
R801
HDC802
R800
2 2 1 1
BARCODE_EN 1
VT_CAM_ID Q800
4 4 3 3
VT_CAM_CLK_N_F VT_CAM_NRST
6 6 5 5
VT_CAM_CLK_P_F VT_CAM_STBY
8 8 7 7
10 10 9 9
VT_CAM_D0_N_F
12 12 11 11
VT_CAM_D0_P_F VT_CAM_SCL
R802
R803
R804
14 14 13 13
VT_CAM_SDA
R807
R808
R809
16 16 15 15
VT_CAM_D1_N_F VT_CAM_MCLK
18 18 17 17 R805
VT_CAM_D1_P_F
20 20 19 19
MIPI_GND
22 22 21 21
24 24 23 23
VT_AGND 26 26 25 25
SENSOR_I2C_SCL 28 28 27 27
30 30 29 29
SENSOR_I2C_SDA 32 32
GES_SENSOR_INT
31 31
34 34 33 33
NC NCNC NC GES_SENSOR_AGND
38 37 36 35
IRDA_CONTROL
1
Q801
C800
C801
C802
C803
C804
C805
R811
R812
R813
R814
R815
R816
R817
R818
R819
R820
8-18
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
2. IR LED
Yes
Yes
Yes
No
IRLED
operate correctly? Change VT CAM ASSY module
Yes
END
8-19
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
VREG_L21_2P95
VREG_L20_2P95
VREG_S3A_1P8
VREG_L1_1P2_WO_DDR
C931
C914
R915
R920
B2
F6
A6
A5
A4
F1
VCC
SPI_VCC
VPP_2V5
VCCIO_0|1
VCCIO_2|3
VPP_FAST
B3 E3
A3
GBIN0|PIO0 PIO2|CBSEL0
F3
IRDA_IRQ
B4
GBIN1|PIO0 PIO2|CBSEL1 IRDA_CONTROL
T_FLASH_D(3)_3V GBIN2|PIO1
TP_TFLASH_D0
T_FLASH_CLK_3V C5
GBIN3|PIO1 PIO3|DP01A
B1
T_FLASH_D(0)
F2 A1
FPGA_MAIN_CLK GBIN4|PIO2 PIO3|DP01B T_FLASH_D(1) VREG_S3A_1P8
E2 C2
BARCODE_EN D1
PIO2 PIO3|DP05A
E1
T_FLASH_D(2)
T_FLASH_CLK TP_TFLASH_CMD C1
GBIN6|PIO3|DP06A
U926
PIO3|DP06B T_FLASH_D(3)
T_FLASH_CMD GBIN7|PIO3|DP05B
E5
A2
PIOS|SPI_SCK
F5
FPGA_SPI_CLK
C3
PIO0 PIOS|SPI_SI
E4
FPGA_SPI_SI R917 R918
PIO0 PIOS|SPI_SO
E6 D5
TP_TFLASH_CMD_3V D6
PIO1 PIOS|SPI_SS_B FPGA_SPI_EN
T_FLASH_CMD_3V PIO1
B5 C4
T_FLASH_D(1)_3V PIO1 CDONE
B6 F4
T_FLASH_D(2)_3V TP_TFLASH_D0_3V PIO1 CRESET_B CRESET_B
C6
T_FLASH_D(0)_3V PIO1
GND
GND
GND
NC
NC
R921
D3
D2
D4
1
2
GES_PROX_1P8
GES_LED_3P3
VREG_LVS1_1P8
VT_CAM_SENSOR_A2P8
VT_CAM_1P8
VREG_L19_3P3
R841
R801
HDC802
R800
2 2 1 1
BARCODE_EN 1
VT_CAM_ID Q800
4 4 3 3
VT_CAM_CLK_N_F VT_CAM_NRST
6 6 5 5
VT_CAM_CLK_P_F VT_CAM_STBY
8 8 7 7
10 10 9 9
VT_CAM_D0_N_F
12 12 11 11
VT_CAM_D0_P_F VT_CAM_SCL
R802
R803
R804
14 14 13 13
VT_CAM_SDA
R807
R808
R809
16 16 15 15
VT_CAM_D1_N_F VT_CAM_MCLK
18 18 17 17 R805
VT_CAM_D1_P_F
20 20 19 19
MIPI_GND
22 22 21 21
24 24 23 23
VT_AGND 26 26 25 25
SENSOR_I2C_SCL 28 28 27 27
30 30 29 29
SENSOR_I2C_SDA 32 32
GES_SENSOR_INT
31 31
34 34 33 33
NC NCNC NC GES_SENSOR_AGND
38 37 36 35
IRDA_CONTROL
1
Q801
C800
C801
C802
C803
C804
C805
R811
R812
R813
R814
R815
R816
R817
R818
R819
R820
8-20
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
Yes
Yes
Yes
Yes
END
8-21
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
VREG_LVS1_1P8
VREG_LVS1_1P8
VREG_LVS1_1P8
VREG_S2A_2P15
C252 GES_PROX_1P8
S_HUB_VDD
VREG_LVS1_1P8
0603
C253
VREG_LVS1_1P8
U814
VREG_LVS1_1P8
4 VDD VOUT 1
R829
VREG_LVS1_1P8
VREG_LVS1_1P8 VREG_LVS1_1P8
C254
2
R228
3 CE GND
C213
GND
C824
R202
R203
R233
R234
C212
G2
B7
B2
A7
F2
F7
VDD
VDD
VDD_1
VCAP1
VDDA|VREFP
VBAT
C827
TP207 F6 G5
5
AP_MCU_INT_1.8V G7
PA0_WKUP PB0
G4
MCU_AP_INT_1_1.8V
BATT_THERM2 E5
PA1 PB1
G3
MCU_AP_INT_2_1.8V
G_SENSOR_INT PA2 PB2
E4 A3
CHG_THERM PA3 PB3 SWO
TP_SHUB_SSN G6 A4
SHUB_SPI_SSN PA4 PB4 M_SENSOR_INT
TP_SHUB_SCK F5 B4
VREG_LVS1_1P8 SHUB_SPI_SCK
TP_SHUB_MISO F4
PA5 PB5
C4
SHUB_SPI_MISO PA6 PB6 SENSOR_I2C_SCL
TP_SHUB_MOSI F3 U201 D4
SHUB_SPI_MOSI D1
PA7 PB7
B5
SENSOR_I2C_SDA
OCP_FLAG PA8 PB8
D2 C5
MCU_TXD PA9 PB9
C2 E3
MCU_RXD PA10 PB10
C1 E2
GES_SENSOR_INT C3
PA11 PB12
G1
MICBIAS_EN_HUB
GES_LED_EN B3
PA12 PB13
F1
MIC_ADC_CLK
SWDIO A1
PA13 PB14
E1
SWCLK
A2
PA14 PB15 MIC_ADC_DATA
C255
PA15
R207
R229
D5
PC13_ANTI_TAMP
A5 C7 C214
BOOT0 PC14_OSC32_IN
E7 C6
MCU_nRST_1.8V B6
NRST PC15_OSC32_OUT
PDR_ON
D7
C215 PH0_OSC_IN
R208
D6
PH1_OSC_OUT
VSSA|VREFM
OSC200
R230
VSS
VSS
VSS
NC
NC
C216
D3
E6
B1
A6
S_HUB_GND
8-22
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
4. GESTURE Sensor
Yes
Yes
Yes
Yes
END
8-23
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
VREG_LVS1_1P8
VREG_LVS1_1P8
VREG_LVS1_1P8
C252
S_HUB_VDD VPH_PWR GES_LED_3P3
0603
C253
VREG_LVS1_1P8
U817
VREG_LVS1_1P8
6 VDD 1
VREG_LVS1_1P8 VOUT
VREG_LVS1_1P8 VREG_LVS1_1P8
C254
5 2
NC VFB
4 3
R228
C213
GND
R202
R203
R233
R234 C212
G2
B7
B2
A7
F2
F7
7
VDD
VDD
VDD_1
VCAP1
VDDA|VREFP
VBAT
TP207 F6 G5
AP_MCU_INT_1.8V G7
PA0_WKUP PB0
G4
MCU_AP_INT_1_1.8V
BATT_THERM2 E5
PA1 PB1
G3
MCU_AP_INT_2_1.8V
G_SENSOR_INT PA2 PB2
E4 A3
CHG_THERM
SHUB_SPI_SSN
TP_SHUB_SSN
TP_SHUB_SCK
G6
F5
PA3
PA4
PB3
PB4
A4
B4
M_SENSOR_INT
SWO
C825 C826
VREG_LVS1_1P8 SHUB_SPI_SCK
TP_SHUB_MISO F4
PA5 PB5
C4
SHUB_SPI_MISO PA6 PB6 SENSOR_I2C_SCL
TP_SHUB_MOSI F3 U201 D4
SHUB_SPI_MOSI D1
PA7 PB7
B5
SENSOR_I2C_SDA
OCP_FLAG PA8 PB8
D2 C5
MCU_TXD PA9 PB9
C2 E3
MCU_RXD PA10 PB10
C1 E2
GES_SENSOR_INT C3
PA11 PB12
G1
MICBIAS_EN_HUB
GES_LED_EN B3
PA12 PB13
F1
MIC_ADC_CLK
SWDIO A1
PA13 PB14
E1
SWCLK
A2
PA14 PB15 MIC_ADC_DATA
C255
PA15
R207
R229
D5
PC13_ANTI_TAMP
A5 C7 C214
BOOT0 PC14_OSC32_IN
E7 C6
MCU_nRST_1.8V B6
NRST PC15_OSC32_OUT
PDR_ON
D7
C215 PH0_OSC_IN
R208
D6
PH1_OSC_OUT
VSSA|VREFM
OSC200
R230
VSS
VSS
VSS
NC
NC
C216
D3
E6
B1
A6
S_HUB_GND
8-24
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
Yes
Yes
Yes
Yes
No
Sensors working? Change U606
Yes
END
8-25
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
VREG_LVS1_1P8
VREG_LVS1_1P8
VREG_LVS1_1P8
C252
S_HUB_VDD
0603
C253
VREG_LVS1_1P8
VREG_LVS1_1P8
VREG_LVS1_1P8
VREG_LVS1_1P8 VREG_LVS1_1P8
C254
R228
C213
R202
R203
R233
R234
C212
G2
B7
B2
A7
F2
F7
VDD
VDD
VDD_1
VCAP1
VDDA|VREFP
VBAT
TP207 F6 G5
AP_MCU_INT_1.8V G7
PA0_WKUP PB0
G4
MCU_AP_INT_1_1.8V
BATT_THERM2 E5
PA1 PB1
G3
MCU_AP_INT_2_1.8V
G_SENSOR_INT PA2 PB2
E4 A3
CHG_THERM PA3 PB3 SWO
TP_SHUB_SSN G6 A4
SHUB_SPI_SSN PA4 PB4 M_SENSOR_INT
TP_SHUB_SCK F5 B4
VREG_LVS1_1P8 SHUB_SPI_SCK
TP_SHUB_MISO F4
PA5 PB5
C4
SHUB_SPI_MISO PA6 PB6 SENSOR_I2C_SCL
TP_SHUB_MOSI F3 U201 D4
SHUB_SPI_MOSI D1
PA7 PB7
B5
SENSOR_I2C_SDA
OCP_FLAG PA8 PB8
D2 C5
MCU_TXD PA9 PB9
C2 E3
MCU_RXD PA10 PB10
C1 E2
GES_SENSOR_INT C3
PA11 PB12
G1
MICBIAS_EN_HUB
GES_LED_EN B3
PA12 PB13
F1
MIC_ADC_CLK
SWDIO A1
PA13 PB14
E1
SWCLK
A2
PA14 PB15 MIC_ADC_DATA
C255
PA15
R207
R229
D5
PC13_ANTI_TAMP
A5 C7 C214
BOOT0 PC14_OSC32_IN
E7 C6
MCU_nRST_1.8V B6
NRST PC15_OSC32_OUT
PDR_ON
D7
C215 PH0_OSC_IN
R208
D6
PH1_OSC_OUT
VSSA|VREFM
OSC200
R230
VSS
VSS
VSS
NC
NC
C216
D3
E6
B1
A6
S_HUB_GND
8-26
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
VREG_LVS1_1P8
VREG_LVS1_1P8
C252
S_HUB_VDD
0603
C253
VREG_LVS1_1P8
Yes
R228
C213
R202
R203
R233
R234
C212
G2
B7
B2
A7
F2
F7
VDD_1
VDD
VDD
VCAP1
VDDA|VREFP
VBAT
TP207 F6 G5
AP_MCU_INT_1.8V G7
PA0_WKUP PB0
G4
MCU_AP_INT_1_1.8V
BATT_THERM2 E5
PA1 PB1
G3
MCU_AP_INT_2_1.8V
G_SENSOR_INT PA2 PB2
E4 A3
CHG_THERM SWO
No
PA3 PB3
TP_SHUB_SSN G6 A4
C227 = 1.8V
SHUB_SPI_MOSI D1
PA7 PB7
B5
SENSOR_I2C_SDA
OCP_FLAG PA8 PB8
D2 C5
MCU_TXD PA9 PB9
C2 E3
MCU_RXD PA10 PB10
C1 E2
GES_SENSOR_INT C3
PA11 PB12
G1
MICBIAS_EN_HUB
GES_LED_EN B3
PA12 PB13
F1
MIC_ADC_CLK
SWDIO A1
PA13 PB14
E1
SWCLK
A2
PA14 PB15 MIC_ADC_DATA
C255
PA15
R207
R229
D5
PC13_ANTI_TAMP
A5 C7 C214
BOOT0 PC14_OSC32_IN
E7 C6
MCU_nRST_1.8V B6
NRST PC15_OSC32_OUT
PDR_ON
D7
C215 PH0_OSC_IN
R208
D6
PH1_OSC_OUT
VSSA|VREFM
OSC200
Yes
R230
VSS
VSS
VSS
NC
NC
C216
D3
E6
B1
A6
2
S_HUB_GND
Yes
Yes
END
8-27
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
VREG_LVS1_1P8
R235
U204
VDD C2
TP_COMPASS_INT
A1 INT IOVDD A2
M_SENSOR_INT
B2 SCL 1
SENSOR_I2C_SCL NC
C1 SDA NC 2
SENSOR_I2C_SDA
B1 VSS
C227 C259
C261 C262
8-28
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
7. Barometer Sensor
Yes
Yes
Yes
Yes
END
8-29
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
VREG_LVS1_1P8
VREG_LVS1_1P8
VREG_LVS1_1P8
VREG_L18_2P85 C252
S_HUB_VDD
0603
VREG_LVS1_1P8 C253
VREG_LVS1_1P8
VREG_LVS1_1P8
VREG_LVS1_1P8
VREG_LVS1_1P8 VREG_LVS1_1P8
C254
U203
R228
C213
1 8
R202
R203
R233
R234
C212
GND VDD
G2
B7
B2
A7
F2
F7
VDD_1
VDD
VDD
VCAP1
VDDA|VREFP
VBAT
2 7
CSB GND TP207 F6 G5
AP_MCU_INT_1.8V G7
PA0_WKUP PB0
G4
MCU_AP_INT_1_1.8V
BATT_THERM2 PA1 PB1 MCU_AP_INT_2_1.8V
3 6 G_SENSOR_INT
E5
E4
PA2 PB2
G3
A3
VREG_LVS1_1P8 SHUB_SPI_SCK
TP_SHUB_MISO F4
PA5 PB5
C4
SHUB_SPI_MISO SENSOR_I2C_SCL
4 5 TP_SHUB_MOSI F3
PA6
U201
PB6
D4
D2
PA7
PA8
PA9
PB7
PB8
PB9
B5
C5
SENSOR_I2C_SDA
NC
C2 E3
MCU_RXD PA10 PB10
C1 E2
GES_SENSOR_INT C3
PA11 PB12
G1
MICBIAS_EN_HUB
GES_LED_EN B3
PA12 PB13
F1
MIC_ADC_CLK
9
SWDIO A1
PA13 PB14
E1
SWCLK
A2
PA14 PB15 MIC_ADC_DATA
C255
PA15
R207
R229
D5
PC13_ANTI_TAMP
A5 C7 C214
BOOT0 PC14_OSC32_IN
E7 C6
C225
C226
MCU_nRST_1.8V B6
NRST PC15_OSC32_OUT
PDR_ON
D7
C215 PH0_OSC_IN
R208
D6
PH1_OSC_OUT
VSSA|VREFM
OSC200
R230
VSS
VSS
VSS
NC
NC
C216
D3
E6
B1
A6
2
S_HUB_GND
8-30
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8. TEMP/Humidity sensor
Yes
Yes
Yes
Yes
END
8-31
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
VREG_LVS1_1P8
VREG_LVS3_1P8 VTOUCH_1P8
VREG_LVS1_1P8
VREG_LVS1_1P8
L810
C252
S_HUB_VDD
0603
C253
VREG_LVS1_1P8
VREG_S3A_1P8
VTOUCH_1P8 VREG_L13_3P3
VREG_LVS1_1P8
VREG_S3A_1P8
VREG_LVS1_1P8
VREG_LVS1_1P8 VREG_LVS1_1P8
C254
R844
OK_SW
R228
C213
C860
R202
R203
R233
R234
C212
G2
B7
B2
A7
F2
F7
HEA800
VDD
VDD
VDD_1
VCAP1
VDDA|VREFP
VBAT
1 1 2 2
TP207 F6 G5 3
AP_MCU_INT_1.8V PA0_WKUP PB0 MCU_AP_INT_1_1.8V 3 4 4
G7 G4
BATT_THERM2 PA1 PB1 MCU_AP_INT_2_1.8V L817 5 5 6 6
E5 G3
G_SENSOR_INT PA2 PB2
7 7 8 8
CHG_THERM
E4
PA3 PB3
A3
SWO 2TOUCH_ID 9 10 10
TP_SHUB_SSN G6 A4 9
SHUB_SPI_SSN
TP_SHUB_SCK F5
PA4 PB4
B4
M_SENSOR_INT TOUCH_INT TP_TOUCH_INT 11 12 12
VREG_LVS1_1P8 SHUB_SPI_SCK 11
SHUB_SPI_MISO
TP_SHUB_MISO F4
PA5
PA6
PB5
PB6
C4
SENSOR_I2C_SCL
TOUCH_I2C_SDA 13 13 14 14
SHUB_SPI_MOSI
TP_SHUB_MOSI F3
PA7
U201
PB7
D4
SENSOR_I2C_SDA TOUCH_I2C_SCL 15 15 16 16
D1 B5
OCP_FLAG
D2
PA8 PB8
C5 17 17 18 18
MCU_TXD
C2
PA9 PB9
E3
WACOM_KEY_2 19 19 20 20
MCU_RXD
C1
PA10 PB10
E2 PEN_VREF1 21 21 22 22
GES_SENSOR_INT C3
PA11 PB12
G1
MICBIAS_EN_HUB WACOM_KEY_1 SENSOR_I2C_SDA
GES_LED_EN PA12 PB13 MIC_ADC_CLK 23 23 24 24
SWDIO
B3
A1
PA13 PB14
F1
E1 NCNCNCNC SENSOR_I2C_SCL
SWCLK
A2
PA14 PB15 MIC_ADC_DATA 25 26 27 28
C255
PA15
R207
R229
D5
PC13_ANTI_TAMP
A5 C7 C214
BOOT0 PC14_OSC32_IN
E7 C6
MCU_nRST_1.8V B6
NRST PC15_OSC32_OUT
C836
C846
C837
PDR_ON
D7
C215 PH0_OSC_IN
R208
D6
PH1_OSC_OUT
VSSA|VREFM
OSC200
R230
VSS
VSS
VSS
NC
NC
C216
D3
E6
B1
A6
S_HUB_GND
8-32
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
Yes
Yes
Yes
Acceleration,Gyro Sensor No
Replace U205 or U201 using a Heatgun
operate correctly?
Yes
END
8-33
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
VREG_LVS1_1P8
VREG_LVS1_1P8 VREG_LVS1_1P8
VREG_LVS1_1P8
C252
S_HUB_VDD
0603
SENSOR_I2C_SCL C253
VREG_LVS1_1P8
SENSOR_I2C_SDA
24
23
22
21
20
19
27
26
VREG_LVS1_1P8
NCS
RESV
RESV
NC
NC
SDA|SDI
AUX_DA
SCL|SCLK
VREG_LVS1_1P8
VREG_LVS1_1P8 VREG_LVS1_1P8
C254
1 18
NC GND
2 17
NC NC
R228
C213
3 16
NC NC
R202
R203
R233
R234
U205 C212
G2
B7
B2
A7
F2
F7
4 15
NC NC
VDD
VDD
VDD_1
VCAP1
VDDA|VREFP
VBAT
5 14 AP_MCU_INT_1.8V
TP207 F6 G5
MCU_AP_INT_1_1.8V
NC NC BATT_THERM2
G7
PA0_WKUP
PA1
PB0
PB1
G4
MCU_AP_INT_2_1.8V
E5 G3
G_SENSOR_INT PA2 PB2
E4 A3
6 13 CHG_THERM PA3 PB3 SWO
SDO|AD0
REGOUT
NC VDD TP_SHUB_SSN G6 A4
AUX_CL
F5 B4
VDDIO
VREG_LVS1_1P8 SHUB_SPI_SCK
TP_SHUB_MISO F4
PA5 PB5
C4
SHUB_SPI_MISO PA6 PB6 SENSOR_I2C_SCL
TP_SHUB_MOSI F3 U201 D4
VREG_LVS1_1P8
INT
SHUB_SPI_MOSI SENSOR_I2C_SDA
C241 OCP_FLAG
D1
PA7
PA8
PB7
PB8
B5
D2 C5
MCU_TXD PA9 PB9
7
10
11
12
C2 E3
MCU_RXD PA10 PB10
C1 E2
GES_SENSOR_INT C3
PA11 PB12
G1
MICBIAS_EN_HUB
GES_LED_EN B3
PA12 PB13
F1
MIC_ADC_CLK
SWDIO A1
PA13 PB14
E1
SWCLK
A2
PA14 PB15 MIC_ADC_DATA
C255
PA15
R207
R229
D5
PC13_ANTI_TAMP
A5 C7 C214
BOOT0 PC14_OSC32_IN
E7 C6
MCU_nRST_1.8V B6
NRST PC15_OSC32_OUT
PDR_ON
D7
C215 PH0_OSC_IN
R208
D6
PH1_OSC_OUT
VSSA|VREFM
C244
OSC200
C245
R230
VSS
VSS
VSS
NC
NC
C216
G_SENSOR_INT
D3
E6
B1
A6
TP_GYRO_INT
2
S_HUB_GND
8-34
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
Yes
Yes
Yes
Yes
END
8-35
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
VPH_PWR MAIN_MICBIAS_2P8
U708
4 1
VDD VOUT
MAIN_MICBIAS_EN
3
CE GND
2 MAIN_MIC_N_CONN
GND
L813
MAIN_MIC_P_CONN
L814
U708
C726
C725
SUS600
ANT6 18
ANT619
U829
ZD604
C830 L809
C841 C832
C831 C833
R847
R835
U824
C859
ZD809
R851 R852
R843
L817
C86 0 R844
C83 6 L810 C84 6 C83 7
SUS601
HEA800
TP_TOUCH_INT
C867
C866
SUS602
C835
L814
L813
C834
C840 ZD804
C861 ZD805
C839 C406
ZD808 C405
HDC801
R833
L811
L812
TH801 TH800
ZD806
ZD803
ZD802
R845 R834
ZD801
R521
R522
8-36
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
Yes
Yes
Yes
Yes
END
8-37
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
SUB_MICBIAS_2P8
V701
MIC701
L701
1
OUT
OUT SUB_MIC_P
2
GND
GND1
3
GND
GND2
C731
4
GND
GND3 C732
5
VDD
L702
SUB_MIC_N
C733
R714
VPH_PWR CODEC_3P3
VREG_S3A_1P8 VPH_PWR
R740
U715
VREG_S2A_2P15
4 VDD VOUT 1
CODEC_3P3
2
3 CE GND
GND
C752
C753 C710
44
24
60
29
47
64
55
20
15
3
VDD_TX
VDD_IO
VDD_RX
VDD_DIG1
VDD_DIG2
VDD_TXADC
VDD_SPKDR1
VDD_SPKDR2
VDD_BUCK
VDD_VBAT
81
RCV_N 76
EAROM
48
RCV_P EAROP MODE0
40
MODE1
80 46 TP_CODEC_RESET_N
VPS_R 69
LINE_OUT1 RESET_N
28 TP_TX_GTR_THRES
CODEC_RESET_N
VPS_L 75
LINE_OUT2 RF_PA_ON
16 TP_CODEC_INT700
TX_GTR_THRES
70
LINE_OUT3 INTR1 CODEC_INT1_N
LINE_OUT4
33 TP_CODEC_INT701
77
INTR2|I2C_SDA
22
CODEC_INT2_N
EAROUT_L 82
HPH_LP I2C_SCL|GND
EAROUT_R 65
HPH_RM
41
HPH_REF HPH_REF TX_I2S_WS
5
TX_I2S_SCK
9 23
SPKR_DRVM DMIC2_CLK|TX_I2S_SD2
8 30
SPKR_DRVP DMIC2_DATA|TX_I2S_SD1
21
SPK_OUT_N 14
SPKR_VSNSM
34
SPK_OUT_P SPKR_VSNSP RX_I2S_WS
10
RX_I2S_SCK
74 18
C714 C715 MAIN_MIC_N 79
MIC1_INM SLIMBUS_CLK|RX_I2S_SD1
12
SLIMBUS_CLK
MAIN_MIC_P MIC1_INP SLIMBUS_DATA|RX_I2S_SD2 SLIMBUS_DATA
EAR_MIC_N
68
50
MIC2_INM
U707 DMIC0_CLK
36
42
EAR_MIC_P MIC2_INP DMIC0_DATA
57 11
SUB_MIC_N 43
MIC3_INM DMIC1_CLK
17
SUB_MIC_P MIC3_INP DMIC1_DATA
56 78 C718
3RD_MIC_N 62
MIC4_INM NCP_C1M
72
3RD_MIC_P MIC4_INP NCP_C1P
83
NCP_VNEG
26 C719
19
MIC5_INM
71
BUCK_GND
MIC5_INP BUCK_VOUT1
59
BUCK_VOUT2
32
MIC6_INM BUCK_VSW
54 L712
38 C720
MIC6_INP
73
31
MIC_BIAS1
61
SUB_MICBIAS_2P8
MBHC_HSDET MIC_BIAS2
25
39
MIC_BIAS3
37
3RD_MICBIAS_2P8
CCOMP MIC_BIAS4 BUCK_GND
R708
45 63
DIVCLK1_CODEC MCLK MICB_CFILT1
R742
67
MICB_CFILT2
GND_SPKDRV
GND_SPKDRV
GND_SPKDRV
GND_SPKDRV
51
GND_CCOMP
13
GND_BUCK
GND_BUCK
LDO_HI_CAP MICB_CFILT3
GND
GND
GND
GND
GND
GND
NC
NC
35
49
53
58
66
84
52
85
86
6
1
2
4
SPK_GND
BUCK_GND
8-38
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
MIC700
MIC701
BOTHHOLE701
ANT101
ANT100
TP_704 TP_706 TP_703
C736
C136
C140
C141
C105
V700 V701
C733 R714
L702
L701
TP_705
C749 C732
C153
U107
R113 R112
R740 C752 L169
R114
U715
C184
C182
L168
C756 C705
R733
R743 ZD703
R722
R728
C858
C857
L808
ZD705 TP_G_DET
U821
C727
C855
C241
L807 TP_GYRO_INT
C245
R742
L708
C828
ZD702
U709
C720
HDC700
C853
C709 C729
U818
U205
C744
L709
L805
R720 C743
C719 C747
L712
C718 V703
C912
V702 L815
TA700
U917 R710
TP_TX_GTR_THRES
TP802
C822
R300
C755
R712
C748
C862
U707
C754
R709
R645 C911
TP_CODEC_INT700
L816
C910 C909
C737
C739
C854
U714
L806
R711 ZD701
ZD704
R741
L711
U918 L703
C724
C813
C710 C722 C728
C706
C753 C707
C721 R708
C723
C714
C715
C927
F804
C806
C708
TP_ELVDD_FBS
C811
R404
C598
F803
R402
R634
C596
C563
R846
HDC800
F532 C865
F802
C759
C812
C537
C533
C555
C539
F801
TP800
C651
C648
F511
F5010
C547
C540
C552
R514
F527
TP_TSP_INT
F800
C5009
F529
F530
F531
F528
F526
8-39
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
Yes
Yes
Yes
Yes
END
8-40
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
3RD_MICBIAS_2P8
V700
MIC700
L700
1
OUT
OUT 3RD_MIC_P
2
GND
GND1
3
GND
GND2
4 C730 C749
GND
GND3
5
VDD
3RD_MIC_N
L710
C736
VPH_PWR CODEC_3P3
VREG_S3A_1P8 VPH_PWR
R740
U715
VREG_S2A_2P15
4 VDD VOUT 1
CODEC_3P3
2
3 CE GND
GND
C752
C753 C710
44
24
60
29
47
64
55
20
15
3
VDD_TX
VDD_IO
VDD_RX
VDD_DIG1
VDD_DIG2
VDD_TXADC
VDD_SPKDR1
VDD_SPKDR2
VDD_VBAT
VDD_BUCK
81
RCV_N 76
EAROM
48
RCV_P EAROP MODE0
40
MODE1
80 46 TP_CODEC_RESET_N
VPS_R 69
LINE_OUT1 RESET_N
28 TP_TX_GTR_THRES
CODEC_RESET_N
VPS_L 75
LINE_OUT2 RF_PA_ON
16 TP_CODEC_INT700
TX_GTR_THRES
70
LINE_OUT3 INTR1 CODEC_INT1_N
LINE_OUT4
33 TP_CODEC_INT701
77
INTR2|I2C_SDA
22
CODEC_INT2_N
EAROUT_L 82
HPH_LP I2C_SCL|GND
EAROUT_R 65
HPH_RM
41
HPH_REF HPH_REF TX_I2S_WS
5
TX_I2S_SCK
9 23
SPKR_DRVM DMIC2_CLK|TX_I2S_SD2
8 30
SPKR_DRVP DMIC2_DATA|TX_I2S_SD1
21
SPK_OUT_N 14
SPKR_VSNSM
34
SPK_OUT_P SPKR_VSNSP RX_I2S_WS
10
RX_I2S_SCK
74 18
C714 C715 MAIN_MIC_N 79
MIC1_INM SLIMBUS_CLK|RX_I2S_SD1
12
SLIMBUS_CLK
MAIN_MIC_P MIC1_INP SLIMBUS_DATA|RX_I2S_SD2 SLIMBUS_DATA
EAR_MIC_N
68
50
MIC2_INM
U707 DMIC0_CLK
36
42
EAR_MIC_P MIC2_INP DMIC0_DATA
57 11
SUB_MIC_N 43
MIC3_INM DMIC1_CLK
17
SUB_MIC_P MIC3_INP DMIC1_DATA
56 78 C718
3RD_MIC_N 62
MIC4_INM NCP_C1M
72
3RD_MIC_P MIC4_INP NCP_C1P
83
NCP_VNEG
26 C719
19
MIC5_INM
71
BUCK_GND
MIC5_INP BUCK_VOUT1
59
BUCK_VOUT2
32
MIC6_INM BUCK_VSW
54 L712
38 C720
MIC6_INP
73
31
MIC_BIAS1
61 SUB_MICBIAS_2P8
MBHC_HSDET MIC_BIAS2
25
39
MIC_BIAS3
37
3RD_MICBIAS_2P8
CCOMP MIC_BIAS4 BUCK_GND
R708
45 63
DIVCLK1_CODEC MCLK MICB_CFILT1
R742
67
MICB_CFILT2
GND_SPKDRV
GND_SPKDRV
GND_SPKDRV
GND_SPKDRV
51
GND_CCOMP
13
GND_BUCK
GND_BUCK
LDO_HI_CAP MICB_CFILT3
GND
GND
GND
GND
GND
GND
NC
NC
35
49
53
58
66
84
52
85
86
6
1
2
4
SPK_GND
BUCK_GND
8-41
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
MIC700
MIC701
BOTHHOLE701
ANT101
ANT100
TP_704 TP_706 TP_703
C736
C136
C140
C141
C105
V700 V701
C733 R714
L702
L701
TP_705
C749 C732
C153
U107
R113 R112
R740 C752 L169
R114
U715
C184
C182
L168
C756 C705
R733
R743 ZD703
R722
R728
C858
C857
L808
ZD705 TP_G_DET
U821
C727
C855
C241
L807 TP_GYRO_INT
C245
R742
L708
C828
ZD702
U709
C720
HDC700
C853
C709 C729
U818
U205
C744
L709
L805
R720 C743
C719 C747
L712
C718 V703
C912
V702 L815
TA700
U917 R710
TP_TX_GTR_THRES
TP802
C822 R300
C755
R712
C748
C862
U707
C754
R709
R645 C911
TP_CODEC_INT700
L816
C910 C909
C737
C739
C854
U714
L806
R711 ZD701
ZD704
R741
L711
U918 L703
C724
C813
C710 C722 C728
C706
C753 C707
C721 R708
C723
C714
C715
C927
F804
C806
C708
TP_ELVDD_FBS
C811
R404
C598
F803
R402
R634
C596
C563
R846
HDC800
F532 C865
F802
C759
C812
C537
C533
C555
C539
F801
TP800
C651
C648
F511
F5010
C547
C540
C552
R514
F527
TP_TSP_INT
F800
C5009
F529
F530
F531
F528
F526
8-42
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
Yes
Yes
END
8-43
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
USB3.0_3P3 MHL_DP
L811
V_BUS_5V VREG_L16_2P7
MAIN_MICBIAS_2P8
HDC801
R833
VREG_S3A_1P8
2 2 1 1
MUIC_DM_JTAG
MUIC_DP_JTAG
4 4 3 3
6 6 5 5
8 8 7 7
JTAG_USB_ID
L812
10 10 9 9
12 11
MUIC_ID
12 11
14 14 13 13
16 16 15 15 MHL_DM
18 18 17 17 R834
20 20 19 19
22 21
MUIC_DM
22 21 MUIC_DP
24 24 23 23 R845
26 26 25 25 SPK_OUT_N
28 28 27 27
30 30 29 29
32 31
SPK_OUT_P
32 31
34 34 33 33
36 36 35 35
HALL_SENSOR_INT 38 38 37 37
MHL_ID
40 40 39 39
42 42 41 41
44 44 43 43
USB3.0_SSTX_M 46 45
46 45
USB3.0_SSTX_P
48 48 47 47
ANT_SWITCH_SEL_1
50 50 49 49
USB3.0_SSRX_M 52 51
MAIN_MIC_N_CONN
USB3.0_SSRX_P 52 51
54 54 53 53 L813
58
57
56
55
C834 C835
58
57
56
55
MAIN_MIC_P_CONN
ZD808
C839 C840
C861 L814
ZD802
ZD801
ZD803
ZD804
ZD805
ZD806
ANT6 18
ANT619
ZD604
L817
C860 R844
C836 L810 C846 C837
HEA800
TP_TOUCH_INT
C867
C866
HDC801
8-44
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
Yes
Yes
Yes
END
8-45
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
HDC700
AXE616124AW1
1 2
1 2
3 4
3 4
L708 5 6
EAROUT_L 7
5 6
8
HPH_REF L709 9
7 8
10
EAROUT_R 11
9 10
12
11 12
RCV_P 13 13 14 14
RCV_N 15 15 16 16
17 NC
18 NC
19 NC
20 NC
V703
V702
0603
0603
C744
C745
ZD703
ZD702
C747 C748
VPH_PWR CODEC_3P3
VREG_S3A_1P8 VPH_PWR
R740
U715
VREG_S2A_2P15
4 VDD VOUT 1
CODEC_3P3
2
3 CE GND
GND
C752
C753 C710
44
24
60
29
47
64
55
20
15
3
VDD_RX
VDD_TX
VDD_IO
VDD_DIG1
VDD_DIG2
VDD_SPKDR1
VDD_SPKDR2
VDD_TXADC
VDD_BUCK
VDD_VBAT
81
RCV_N 76
EAROM
48
RCV_P EAROP MODE0
40
MODE1
80 46 TP_CODEC_RESET_N
VPS_R 69
LINE_OUT1 RESET_N
28 TP_TX_GTR_THRES
CODEC_RESET_N
VPS_L 75
LINE_OUT2 RF_PA_ON
16 TP_CODEC_INT700
TX_GTR_THRES
70
LINE_OUT3 INTR1 CODEC_INT1_N
LINE_OUT4
33 TP_CODEC_INT701
77
INTR2|I2C_SDA
22
CODEC_INT2_N
EAROUT_L 82
HPH_LP I2C_SCL|GND
EAROUT_R 65
HPH_RM
41
HPH_REF HPH_REF TX_I2S_WS
5
TX_I2S_SCK
9 23
SPKR_DRVM DMIC2_CLK|TX_I2S_SD2
8 30
SPKR_DRVP DMIC2_DATA|TX_I2S_SD1
21
SPK_OUT_N 14
SPKR_VSNSM
34
SPK_OUT_P SPKR_VSNSP RX_I2S_WS
10
RX_I2S_SCK
74 18
C714 C715 MAIN_MIC_N 79
MIC1_INM SLIMBUS_CLK|RX_I2S_SD1
12
SLIMBUS_CLK
MAIN_MIC_P MIC1_INP SLIMBUS_DATA|RX_I2S_SD2 SLIMBUS_DATA
EAR_MIC_N
68
50
MIC2_INM
U707 DMIC0_CLK
36
42
EAR_MIC_P MIC2_INP DMIC0_DATA
57 11
SUB_MIC_N 43
MIC3_INM DMIC1_CLK
17
SUB_MIC_P MIC3_INP DMIC1_DATA
56 78 C718
3RD_MIC_N 62
MIC4_INM NCP_C1M
72
3RD_MIC_P MIC4_INP NCP_C1P
83
NCP_VNEG
26 C719
19
MIC5_INM
71
BUCK_GND
MIC5_INP BUCK_VOUT1
59
BUCK_VOUT2
32
MIC6_INM BUCK_VSW
54 L712
38 C720
MIC6_INP
73
31
MIC_BIAS1
61
SUB_MICBIAS_2P8
MBHC_HSDET MIC_BIAS2
25
39
MIC_BIAS3
37
3RD_MICBIAS_2P8
CCOMP MIC_BIAS4 BUCK_GND
R708
45 63
DIVCLK1_CODEC MCLK MICB_CFILT1
R742
67
MICB_CFILT2
GND_SPKDRV
GND_SPKDRV
GND_SPKDRV
GND_SPKDRV
51
GND_CCOMP
13
GND_BUCK
GND_BUCK
LDO_HI_CAP MICB_CFILT3
GND
GND
GND
GND
GND
GND
NC
NC
35
49
53
58
66
84
52
85
86
6
1
2
4
SPK_GND
BUCK_GND
8-46
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
MIC700
MIC701
BOTHHOLE701
ANT101
ANT100
TP_704 TP_706 TP_703
C736
C136
C140
C141
C105
V700 V701
C733 R714
L702
L701
TP_705
C749 C732
C153
U107
R113 R112
R740 C752 L169
R114
U715
C184
C182
L168
C756 C705
R733
R743 ZD703
R722
R728
C858
C857
L808
ZD705 TP_G_DET
U821
C727
C855
C241
L807 TP_GYRO_INT
C245
R742
L708
C828
ZD702
U709
C720
HDC700
C853
C709 C729
U818
U205
C744
L709
L805
R720 C743
C719 C747
L712
C718 V703
C912
V702 L815
TA700
U917 R710
TP_TX_GTR_THRES
TP802
C822
R300
C755
R712
C748
C862
U707
C754
R709
R645 C911
TP_CODEC_INT700
L816
C910 C909
C737
C739
C854
U714
L806
R711 ZD701
ZD704
R741
L711
U918 L703
C724
C813
C710 C722 C728
C706
C753 C707
C721 R708
C723
C714
C715
C927
F804
C806
C708
TP_ELVDD_FBS
C811
R404
C598
F803
R402
R634
C596
C563
R846
HDC800
F532 C865
F802
C759
C812
C537
C533
C555
C539
F801
TP800
C651
C648
F511
F5010
C547
C540
C552
R514
F527
TP_TSP_INT
F800
C5009
F529
F530
F531
F528
F526
8-47
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-3-11. BT/WIFI
Yes
Yes
No
Yes
Yes
YES
Check the status(crack, missin
g, Corrosion..etc) of L217, L2 Resolder or Replace L217, L215, R209, F202,
15, R209, F202, C222, L209, C222, L209, C223, L216
C223, L216
No
Yes
END
8-48
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-49
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-3-12. GPS
Yes
No
Check GPS function ON Enable GPS Function in the setting.
Yes
Yes
Yes
Yes
Yes
Yes
END
8-50
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
VREG_L16_2P7
L200
L212 VREF_XO
GPS_LNA_EN L201
3.9nH
0603
6
2
U200 F201
F200
L213
VCC
ENABLE
L214 C202 C203 XO_THERM
3
L202 BAL 6.8nH
1 1 4 5 3 1 4 0603
1 OUT RF_IN RF_OUT UNBAL BAL
IN
6 OSC600
GND_RF
G
G GG G NC
2
2 C608
GND
4 3
2
2 3 5 5 19M_OUT
GPS_RF_P
C206 C204 L203 1 2
19M_IN GND_XOADC
1
4
L205 C207 C208
ANT200 3.9nH
0603
VDD_RF2_T_VCO_136
VDD_RF2_P_VCO_67
VDD_RF2_S_VCO_51
VDD_RF2_T_DA_111
VDD_RF2_T_BB_108
VDD_RF2_T_PLL_97
VDD_RF2_D_BB_44
VDD_RF2_P_BB_83
VDD_RF2_XO_127
VDD_RF1_D_MBLO_25
VDD_RF1_P_FELO_42
VDD_RF1_P_FELO_53
VDD_RF1_T_UPC_117
VDD_RF1_D_LBLO_28
VDD_RF1_P_VCO_76
VDD_RF1_S_VCO_40
VDD_RF1_T_SYN_98
VDD_RF1_T_DA_118
VDD_RF1_T_LO_116
VDD_RF1_G_VCO_37
VDD_RF1_P_PLL_66
VDD_RF1_S_PLL_65
VDD_RF1_G_LNA_24
VDD_RF1_G_PLL_55
VDD_RF1_G_BB_31
VDD_RF1_D_FE_26
VDD_RF1_JDET_85
VDD_DIO_87
C334
118
116
117
108
111
136
127
87
26
28
25
31
24
55
37
85
42
53
66
65
40
98
83
67
51
97
76
44
VDD_DIO
VDD_RF2_XO
VDD_RF1_D_FE
VDD_RF1_G_VCO
VDD_RF1_P_VCO
VDD_RF1_S_VCO
VDD_RF1_T_SYN
VDD_RF1_T_UPC
VDD_RF2_P_VCO
VDD_RF2_S_VCO
VDD_RF2_T_VCO
VDD_RF1_JDET
VDD_RF1_T_LO
VDD_RF1_G_BB
VDD_RF1_T_DA
VDD_RF2_D_BB
VDD_RF2_P_BB
VDD_RF2_T_DA
VDD_RF2_T_PLL
VDD_RF1_P_FELO
VDD_RF1_P_FELO
VDD_RF1_G_LNA
VDD_RF2_T_BB
VDD_RF1_G_PLL
VDD_RF1_P_PLL
VDD_RF1_S_PLL
VDD_RF1_D_MBLO
VDD_RF1_D_LBLO
7
TX_LB3
133
RF_TX_B5/8
PRX_B7_P PRX_HB_INP TX_LB4
15
PRX_B7_M PRX_HB_INM
126
TX_MB1
5 119
DRX_B5/8_P 14
DRX_LB1_INP TX_MB2
112
RF_TX_B3/4
DRX_B5/8_M DRX_LB1_INM TX_MB3
95
RF_TX_B1/2
4
TX_MB4 RF_TX_G1800/1900
DRX_B17/20_P DRX_LB2_INP
13 103
DRX_B17/20_M DRX_LB2_INM TX_HB RF_TX_B7
3 109
DRX_B1/2/3/4_P 12
DRX_MB_INP DAC_REF
96
WTR0_BB_TX_IDAC
DRX_B1/2/3/4_M DRX_MB_INM GP_CLK
2 114
DRX_B7_P 11
DRX_HB_INP GP_SYNC
DRX_B7_M DRX_HB_INM
88
GP_DATA2
10 121
GPS_RF_P 18
GNSS_INP GP_DATA1
105
GSM_TX_PHASE_D1
GPS_RF_M GNSS_INM GP_DATA0 GSM_TX_PHASE_D0
101 80 TP300 WTR0_SSBI2_PRX_DRX
WTR0_PDET_SEL PDET_IN SSBI_PRX_DRX
89 TP301
130
SSBI_TX_GNSS WTR0_SSBI1_TX_GPS
WTR0_BB_TX_IP 138
TX_BB_IP
45
WTR0_BB_TX_IM TX_BB_IM RX_ON
100
WTR0_RX_ON0
131
RF_ON
86
WTR0_RF_ON0
WTR0_BB_TX_QP 139
TX_BB_QP JAM_DET
79
WTR0_BB_TX_QM TX_BB_QM VTUNE_PRX
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
DNC
NC
NC
102
104
106
107
110
113
115
122
123
124
125
128
129
134
135
137
142
143
144
19
20
21
22
27
29
32
33
34
35
38
39
41
46
47
49
52
58
59
64
68
73
74
75
77
81
94
99
90
1
6
9
8-51
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-52
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-3-13. NFC
Yes
No
Check NFC function ON Enable NFC Function
Yes
Yes
Yes
Yes
No
Check the Status of Resolder or change OSC201
C250
Yes
Yes
Yes
END
8-53
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
NFC_SIMVCC
ANT202 ANT203
VDD_EE
1 1 VREG_L9_UIM1
1 1
NFC_ANT_2 2 2 NFC_ANT_1
2 2 C229
ZD200
ZD201
C230
C235
26
13
21
23
24
27
30
32
1
2
5
6
9
VDDIO
VDD_EE
VDD_VCO
VDDSWP_IN
VDD_SE_IN
VBAT
VDD_ANT
VDD_ADC
VDDC_CAP
VDDSWP_OUT0
VDDSWP_OUT1
VDDA_CAP
VDD_XTAL
8 3
TM2 SWPIO_0 NFC_SWP C236 C237 C238 C239
7 4 TP224
NFC_FIRMWARE NFC_WAKE SWPIO_1
TP221 10
HOST_WAKE SE_SWP_IN
18
11
CLK_REQ R220
R221 C240 L210 12
NFC_ANT_2 UART_TXD NFC_I2C_SDA
29 U206 14
28
TX1 UART_RTS_N
16
NFC_I2C_SCL VREG_S3A_1P8
TX2 UART_CTS_N NFC_IRQ
17 TP222
C242 C243
UART_RXD NFC_UART_RXD
R222 200 19
XTAL_XON
20 15
XTAL_XOP SPI_INT
VDD_EE 22 R223
OSC201 R224 33
LPO
25
GND
NC
NC
NC
3 4 R227 C249
R226 C248 L211 C250
35
31
36
37
NFC_ANT_1 C251
214
222
223
182
210
169
177
193
218
211
227
103
113
144
151
120
192
140
111
124
133
125
141
174
118
135
161
183
142
63
23
33
87
79
16
32
24
47
31
56
12
35
20
38
28
26
42
27
10
29
13
74
89
18
82
57
85
40
58
21
19
22
14
64
96
98
7
1
9
2
VREG_RF_CLK|VREG_L5
VREG_XO|VREG_L7
VDD_L13_20_23_24
VDD_L6_12_14_15
VDD_L8_16_18_19
VDD_L9_10_17_22
VDD_L2_LVS1_2_3
VOUT_5VS_HDMI
VOUT_5VS_OTG
BATFET_CP_DRV
VREG_5V_SNS
VDD_INT_BYP
VDD_MSM_IO
VDD_TORCH
VREG_FAULT
VDD_GPLED
VOUT_LVS1
VOUT_LVS2
VOUT_LVS3
BAT_THERM
VDD_FLASH
VDD_WLED
VREG_BMS
VDD_L4_11
BMS_CSM
VBAT_SNS
BMS_CSP
VREG_S1
VREG_S2
VREG_S3
VREG_L10
VREG_L11
VREG_L12
VREG_L13
VREG_L14
VREG_5V
VREG_5V
VREG_L15
VREG_L16
VREG_L17
VREG_L18
VREG_L19
VREG_L20
VREG_L21
VREG_L22
VREG_L23
VREG_L24
VDD_RGB
VREF_BAT
VDD_L1_3
VDD_L5_7
VSW_S1
VSW_S2
VSW_S2
VSW_S3
VSW_5V
VSW_5V
VREG_L1
VREG_L2
VREG_L3
VREG_L4
VREG_L6
VREG_L8
VREG_L9
VIN_5VS
VDD_S1
VDD_S2
VDD_S3
VCOIN
BAT_ID
VBAT
VBAT
VBAT
VDD_L21
152
REF_BYP
37
XO_THERM
139
OTG_IN
170 226
AMUX_1 PHY_VBUS
138
AMUX_2
154 172
AMUX_3 USB_IN
178 173
AMUX_4 USB_IN
203 181
AMUX_5 USB_IN
186 220
AMUX_PU1 DC_IN
195 221
AMUX_PU2 DC_IN
229
DC_IN
179
AMUX_USB_ID
162 189
AMUX_HW_ID OVP_OUT
205
OVP_OUT
11 212
XTAL_19M_IN DC_IN_OVP_CTL
3 228
XTAL_19M_OUT DC_IN_OVP_SNS
171
OVP_CP_DRV
69
XO_OUT_A0
84 187
XO_OUT_A1 VPRE_CAP
60
XO_OUT_A2
200
VCHG
75 216
XO_OUT_D0 VCHG
44 217
XO_OUT_D0_EN VCHG_SNS
83
XO_OUT_D1
208
VSW_SMBC
52 224
XO_OUT_DIFF_N VSW_SMBC
68 201
XO_OUT_DIFF_P VREG_SMBC
70 209
XTAL_32K_IN VDRV_P
54
XTAL_32K_OUT
30 198
SLEEP_CLK VPH_PWR
206
VPH_PWR
188 207
VREF_DDR3_CA VPH_PWR
213
VREF_DDR3_DQ
46 123
VREF_XO MPP_01|VREF_PADS
156
MPP_02|EXT_BOOST_EN
126 148
VSW_WLED MPP_03|VREF_DAC
97 132
U606
VREG_WLED MPP_04|PRIVACY_LED
150 121
WLED_CABC MPP_05|ENET_LDO_EN
127 145
WLED_SNK1 MPP_06|ENET_RST_N
119 136
WLED_SNK2 MPP_07|NFC_EXT_EN
104 153
WLED_SNK3 MPP_08|MHL_RESET_N
80 39
GPLED_SNK1 GPIO_01|KYPD_SNS1
41 53
GPLED_SNK2 GPIO_02|KYPD_SNS2
65 62
GPLED_SNK3 GPIO_03|KYPD_SNS3
49 55
GPLED_SNK4 GPIO_04|KYPD_SNS4
61
GPIO_05|KYPD_SNS5
66 71
GPLED_SRC1 GPIO_06|KYPD_SNS6
81 77
GPLED_SRC2 GPIO_07|KYPD_SNS7
73 94
GPLED_SRC3 GPIO_08|KYPD_SNS8
88 76
GPLED_SRC4 GPIO_09|KYPD_DRV1
86
GPIO_10|KYPD_DRV2
158 93
FLASH_DRV_1 GPIO_11|KYPD_DRV3
190 110
FLASH_DRV_2 GPIO_12|KYPD_DRV4
157
GPIO_13|KYPD_DRV5
176 102
RGB_BLU|GP_LED_DRV2 GPIO_14|KYPD_DRV6
167 109
RGB_GRN|GP_LED_DRV1 GPIO_15|CLK_CODEC
160 149
RGB_RED|LED_ATC|GP_LED_DRV0 GPIO_16|CLK_HAPTICS
165
GPIO_17|CLK_QPA1
72 117
VIB_DRV_N GPIO_18|CLK_QPA2
43
GPIO_19|MIPI_DSI_RST_N
180 36
CBL_PWR_N GPIO_20|GOBI_PWR_EN
155 25
KYPD_PWR_N GPIO_21|EXT_REG_EN1
191 59
OPT_1 GPIO_22|HS_DET
202 34
OPT_2 GPIO_23|KYPD_DRV7
114 105
OPT_3 GPIO_24|KYPD_DRV8
129 51
OPT_4 GPIO_25|KYPD_DRV9
197 67
PS_HOLD GPIO_26|KYPD_DRV10
163 184
RESIN_N GPIO_27|FLASH_STROBE
196 194
PON_1 GPIO_28|TX_GTR_THRESH
159
GPIO_29|SD_WP
147 90
SPMI_DATA GPIO_30|TS_CHGR_IN
131 143
SPMI_CLK GPIO_31|BAT_ALARM
204 166
PON_OUT GPIO_32|NFC_CLK_REQ
164 106
PON_RESET_N GPIO_33|PWM_LED_CTL1
GND_WLED_SMPS
128
GPIO_34|PWM_LED_CTL2
137
GND_CHG_HP
GND_CHG_HP
GPIO_35|PWM_LED_CTL3
GND_XOADC
146
GND_REF
GPIO_36|PWM_LED_CTL4
GND_5V
GND_S1
GND_S2
GND_S3
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
NC
NC
100
101
107
108
112
115
116
122
130
175
185
219
225
199
215
168
134
230
231
50
78
91
92
48
15
17
95
45
99
8-54
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-55
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-3-14. LCD
Yes
Yes
Check No
VREG_L22_3P0=3.0V(C622), Resolder or Replace the PMIC(U606)
Check No
VCC_1.8V_LCD=1.8V(C811) Resolder or Replace the Buck(U808)
Yes
Check
ELVDD_4.6V=4.6V(C862/C813) No
ELVSS_-4V=-1.4~-4.4V(C858/C806)
Resolder or Replace the DCDC(U818)
ELAVDD_7.0V=7.0V(C853)
Yes
Replace LCD
Module
Yes
END
8-56
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
GND 6
GND 5
V_TSP_IO_1P8 VREG_L22_3P0
LCD_D3_N 2
I|O I|O
3
LCD_D3_P 1
I|O I|O
4
VCC_1.8V_LCD
F800
ELVDD_4.6V TSP_AVDD_3P3
ELVSS_-4.4V
C865
GND 6
GND 5
ELAVDD_7.0V
LCD_D0_N 2
I|O I|O
3 HDC800
R846
LCD_D0_P 1
I|O I|O
4 1 2
1
0603
2
3 4
F801 5
3 4 TSP_INT
5 6
6
7 8
TP800 9
7 8
10
TS_I2C_S
11
9 10
12
TS_I2C_S
11 12 VPP
13 14
TP801 15
13 14
16
TE
GND 6
GND 5
17
15 16 EL_ON_1
18
19
17 18
20
EL_ON_2
LCD_CLK_N 2
I|O I|O
3 21
19 20
22
21 22
23 24
LCD_CLK_P 1
I|O I|O
4 25
23 24
26
25 26 PCD_INT
27 28
27 28 ERR_FG
F802 29 30 TP802
29 30 MLCD_RST
31 32
31 32 TSP_ID
33 34
TA_TOUCH_SENSE 35
33 34
36
TP_ELVDD_FBS
35 36
37 38
37 38
39 39 40
GND 6
GND 5
40
G GGG
41424344 C813
LCD_D1_N 2
I|O I|O
3
C806
C811
C812
10V
LCD_D1_P 1
I|O I|O
4
F803
GND 6
GND 5
HD OCTA CON
LCD_D2_N 2
I|O I|O
3
LCD_D2_P 1
I|O I|O
4
F804
CAM_DVDD_1P1 VREG_L1_1P2
VREG_L1_1P2_WO_DDR
VREG_L11_1P5
R636
V_TSP_IO_1P8
VREG_L18_2P85
VREG_L19_3P3
VREG_L20_2P95
VREG_L21_2P95
VREG_L22_3P0
VDD_VIB_3P0
VREG_L24_3P075
C605 C606 C607
VREG_S3A_1P8
VREG_S2A_2P15 VREG_LVS1_1P8
CAM_IO_1P8
VREG_S1A_1P3
VREG_LVS3_1P8
VPH_PWR VREG_BOOST_BYPASS
VREG_S2A_2P15
C624 C625 C626 R607
VREG_S3A_1P8
VPH_PWR
BAT600
C628
C627
TP_BAT_THERM
TP_VREF_BAT
TP_VREG_600
TP_BAT_ID
VREG_S1A_1P3
VPH_PWR C631 C632 C633
VPH_PWR
L601
L602
L603
VPH_PWR GND_S3
C639
GND_S2
214
222
223
182
210
169
177
193
218
211
227
103
113
144
151
120
192
140
111
124
133
125
141
174
118
135
161
183
142
GND_S1
63
23
33
87
79
16
32
24
47
31
56
12
35
20
38
28
26
42
27
10
29
13
74
89
18
82
57
85
40
58
98
21
19
22
14
64
96
7
VREG_L8_1P8
VDD_L13_20_23_24
VDD_L6_12_14_15
VDD_L8_16_18_19
VDD_L9_10_17_22
VDD_L2_LVS1_2_3
VREG_5V_SNS
VREG_XO|VREG_L7
VOUT_5VS_HDMI
VDD_L4_11
VDD_MSM_IO
VREG_5V
VREG_5V
VIN_5VS
VCOIN
VDD_GPLED
VREG_S1
VREG_L1
VREG_L2
VREG_L3
VREG_L4
VREG_RF_CLK|VREG_L5
VREG_L6
VREG_L8
VREG_L22
VOUT_5VS_OTG
VDD_L1_3
VDD_L21
VDD_L5_7
VDD_S1
VDD_S2
VDD_TORCH
VDD_S3
BMS_CSM
VREG_S2
VREG_S3
VSW_S3
VREG_L9
VREG_L10
VREG_L11
VREG_L12
VREG_L13
VREG_L14
VREG_L15
VREG_L16
VREG_L17
VREG_L18
VREG_L19
VREG_L20
VREG_L21
VREG_L23
VREG_L24
VREG_BMS
BMS_CSP
VSW_5V
VSW_5V
VDD_INT_BYP
VDD_RGB
VDD_WLED
VSW_S1
VSW_S2
VSW_S2
VOUT_LVS1
VOUT_LVS2
VOUT_LVS3
VREG_FAULT
BAT_ID
VDD_FLASH
VBAT
VBAT
VBAT
VREF_BAT
BAT_THERM
BATFET_CP_DRV
VBAT_SNS
152 C642
37
REF_BYP GND_REF
XO_THERM XO_THERM
139
OTG_IN TP_OTG_IN
170 226
MSM_THERM 138
AMUX_1 PHY_VBUS TP_USB_PHY_VBUS
R609 R608
BATT_THERM 154
AMUX_2
172
AMUX_3 USB_IN
178 173
PA_THERM1 203
AMUX_4 USB_IN
181
AMUX_5 USB_IN
186 220
AMUX_PU1 DC_IN
195 221
AMUX_PU2 DC_IN
229
DC_IN
179
AMUX_USB_ID
R610 162 189
AMUX_HW_ID OVP_OUT
205
OVP_OUT
11 212
19M_IN 3
XTAL_19M_IN DC_IN_OVP_CTL
228
19M_OUT XTAL_19M_OUT DC_IN_OVP_SNS
171
OVP_CP_DRV
69
XO_OUT_A0 84
XO_OUT_A0
187 C645
XO_OUT_A1 VPRE_CAP
60
XO_OUT_A2
200 VPH_PWR
VCHG
R611 75 216
XO_OUT_D0 TP_605 44
XO_OUT_D0 VCHG
217
XO_OUT_D0_EN 83
XO_OUT_D0_EN VCHG_SNS
XO_OUT_D1
208
52
VSW_SMBC
224
R612
USB3.0_CLK_M 68
XO_OUT_DIFF_N VSW_SMBC
201
USB3.0_CLK_P XO_OUT_DIFF_P VREG_SMBC
70 209
XTAL_32K_IN VDRV_P C654
54
XTAL_32K_OUT
TP606 30 198
VREF_XO SLEEP_CLK SLEEP_CLK VPH_PWR
206
VREG_L11_1P5
VPH_PWR
188 207
VREF_LPDDR3_CA 213
VREF_DDR3_CA VPH_PWR
VREF_LPDDR3_DQ 46
VREF_DDR3_DQ
123
VREF_XO MPP_01|VREF_PADS
156
SDC_UIM_VBIAS
MPP_02|EXT_BOOST_EN
U606
126 148
VSW_WLED MPP_03|VREF_DAC TXDAC0_VREF
R613
97 132
150
VREG_WLED MPP_04|PRIVACY_LED
121
EAR_ADC_3.5
127
WLED_CABC MPP_05|ENET_LDO_EN
145
HDMI_EN
119
WLED_SNK1 MPP_06|ENET_RST_N
136
MHL_RST R616
104
WLED_SNK2 MPP_07|NFC_EXT_EN
153
FLASH_LED_EN
WLED_SNK3 MPP_08|MHL_RESET_N VF
80 39
41
GPLED_SNK1 GPIO_01|KYPD_SNS1
53
FLASH_LED_SET
C659
R617
R618
R620
65 62
49
GPLED_SNK3 GPIO_03|KYPD_SNS3
55
OK_SW
GPLED_SNK4 GPIO_04|KYPD_SNS4
61
ERR_FG
66
GPIO_05|KYPD_SNS5
71
VOL_UP
81
GPLED_SRC1 GPIO_06|KYPD_SNS6
77
VT_CAM_STBY
73
GPLED_SRC2 GPIO_07|KYPD_SNS7
94
CAM_SENSOR_DET
88
GPLED_SRC3 GPIO_08|KYPD_SNS8
76
VT_CAM_A_EN
GPLED_SRC4 GPIO_09|KYPD_DRV1
86
TSP_EN
158
GPIO_10|KYPD_DRV2
93
VT_CAM_IO_EN
190
FLASH_DRV_1 GPIO_11|KYPD_DRV3
110
FSA_EN VREG_S3A_1P8
FLASH_DRV_2 GPIO_12|KYPD_DRV4
157
MAIN_CAM_A_EN
176
GPIO_13|KYPD_DRV5
102
NFC_EN
LED_B 167
RGB_BLU|GP_LED_DRV2 GPIO_14|KYPD_DRV6
109
LCD_1P8_EN
LED_G 160
RGB_GRN|GP_LED_DRV1 GPIO_15|CLK_CODEC
149
DIVCLK1_CODEC
D600 LED_R RGB_RED|LED_ATC|GP_LED_DRV0 GPIO_16|CLK_HAPTICS SLEEP_CLK_WIFI
R640
165
CHG_DET 72
GPIO_17|CLK_QPA1
117
VIB_DRV_N GPIO_18|CLK_QPA2
43
CRESET_B
GPIO_19|MIPI_DSI_RST_N MLCD_RST
D601
JIG_ON_N
180
CBL_PWR_N GPIO_20|GOBI_PWR_EN
36
WACOM_SENSE
155 25
PHONE_ON_N KYPD_PWR_N GPIO_21|EXT_REG_EN1 BOOST_BYP_N
191
OPT_1 GPIO_22|HS_DET
59
EAR_DET
202 34
OPT_2 GPIO_23|KYPD_DRV7
114 105
129
OPT_3 GPIO_24|KYPD_DRV8
51
VT_CAM_NRST
R623 197
OPT_4 GPIO_25|KYPD_DRV9
67
MAIN_CAM_RST
R625 R626 MSM_PS_HOLD PS_HOLD GPIO_26|KYPD_DRV10 FUEL_ALERT
R647 163 184
PHONE_ON_N R624 196
RESIN_N GPIO_27|FLASH_STROBE
194
IRDA_IRQ
PON_1 GPIO_28|TX_GTR_THRESH
159
TX_GTR_THRES
GPIO_29|SD_WP TOUCH_INT
PMIC_SPMI_DATA 147 90 TP_TSP_INT
131
SPMI_DATA GPIO_30|TS_CHGR_IN
143
TSP_INT
PMIC_SPMI_CLK SPMI_CLK GPIO_31|BAT_ALARM
TP_PON_OUT 204 166
PON_OUT 164
PON_OUT GPIO_32|NFC_CLK_REQ
106
PM8941_PON_RESET_N PON_RESET_N GPIO_33|PWM_LED_CTL1
128
MICBIAS_EN_MSM
GPIO_34|PWM_LED_CTL2 EAR_MICBIAS_EN
GND_WLED_SMPS
137
GPIO_35|PWM_LED_CTL3 WACOM_LDO_EN
GND_CHG_HP
GND_CHG_HP
GND_XOADC
146
GPIO_36|PWM_LED_CTL4 HALL_SENSOR_INT
GND_REF
GND_5V
GND_S1
GND_S2
GND_S3
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
NC
NC
100
101
107
108
112
115
116
122
130
175
185
219
225
199
215
168
134
230
231
50
78
91
92
99
48
15
17
95
45
GND_XOADC
GND_S3
GND_S2
GND_S1
GND_REF
8-57
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
R825
U808
1 6
LCD_1P8_EN CE VFB
2 5
AGND VIN
3 4 R826
PGND LX
L804
GND
7
ELAVDD_7.0V
VPH_PWR
L815
VPH_PWR
L816
16
15
14
13
17
C855
PGND2
VO3
LX3
AVIN
GND
1 12
L806
L807
LX1 PVIN
2 PGND1 L808
U818 LX2 11
3 10
VO1 VO2
EN_VO3
4 9
FBS CTRL EL_ON_2
AGND
FD
CT
C857
C858
5
EL_ON_1
C862
HD OCTA DC-D
8-58
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
Yes
Abnormal
Yes
Check CAM_MCLK No
is 24MHz Replace the PBA.
Yes
No Resolder L801
Check L801 is OK
Replace the PBA.
Yes
Yes
END
8-59
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
CAM_DVDD_1P1 VREG_L1_1P2
VREG_L1_1P2_WO_DDR
VREG_L11_1P5
R636
V_TSP_IO_1P8
VREG_L18_2P85
VREG_L19_3P3
VREG_L20_2P95
VREG_L21_2P95
VREG_L22_3P0
VDD_VIB_3P0
VREG_L24_3P075
C605 C606 C607
VREG_S3A_1P8
VREG_S2A_2P15 VREG_LVS1_1P8
CAM_IO_1P8
VREG_S1A_1P3
VREG_LVS3_1P8
VPH_PWR VREG_BOOST_BYPASS
VREG_S2A_2P15
C624 C625 C626 R607
VREG_S3A_1P8
VPH_PWR
BAT600
C628
C627
TP_BAT_THERM
TP_VREF_BAT
TP_VREG_600
TP_BAT_ID
VREG_S1A_1P3
VPH_PWR C631 C632 C633
VPH_PWR
L601
L602
L603
VPH_PWR GND_S3
C639 GND_S2
214
222
223
182
210
169
177
193
218
211
227
103
113
144
151
120
192
140
111
124
133
125
141
174
118
135
161
183
142
GND_S1
63
23
33
87
79
16
32
24
47
31
56
12
35
20
38
28
26
42
27
10
29
13
74
89
18
82
57
85
40
58
98
21
19
22
14
64
96
7
1
9
VREG_L8_1P8
VDD_L13_20_23_24
VDD_L6_12_14_15
VDD_L8_16_18_19
VDD_L9_10_17_22
VDD_L2_LVS1_2_3
VDD_L4_11
VDD_L1_3
VDD_L5_7
VOUT_5VS_HDMI
VDD_TORCH
VSW_5V
VSW_5V
VREG_5V
VREG_5V
VREG_5V_SNS
VDD_L21
VOUT_5VS_OTG
VDD_MSM_IO
VDD_GPLED
VDD_WLED
BATFET_CP_DRV
BMS_CSP
VSW_S1
VREG_S1
VSW_S2
VSW_S2
VREG_S2
VREG_S3
VSW_S3
VREG_L1
VREG_L2
VREG_L3
VREG_L4
VREG_RF_CLK|VREG_L5
VREG_L6
VREG_L8
VREG_L9
VREG_L10
VREG_L11
VREG_L12
VREG_L13
VREG_L14
VREG_L15
VREG_L16
VREG_L17
VREG_L18
VREG_L19
VREG_L20
VREG_L21
VREG_L22
VREG_L23
VREG_L24
VOUT_LVS1
VOUT_LVS2
VOUT_LVS3
VIN_5VS
VDD_INT_BYP
VDD_RGB
VDD_S1
VDD_S2
VDD_S3
VREG_FAULT
BMS_CSM
BAT_THERM
BAT_ID
VCOIN
VDD_FLASH
VBAT_SNS
VREG_BMS
VREG_XO|VREG_L7
VBAT
VBAT
VBAT
VREF_BAT
152 C642
37
REF_BYP GND_REF
XO_THERM XO_THERM
139
OTG_IN TP_OTG_IN
170 226
MSM_THERM 138
AMUX_1 PHY_VBUS TP_USB_PHY_VBUS
R609 R608 BATT_THERM 154
AMUX_2
172
AMUX_3 USB_IN
178 173
PA_THERM1 203
AMUX_4 USB_IN
181
AMUX_5 USB_IN
186 220
AMUX_PU1 DC_IN
195 221
AMUX_PU2 DC_IN
229
DC_IN
179
AMUX_USB_ID
R610 162 189
AMUX_HW_ID OVP_OUT
205
OVP_OUT
11 212
19M_IN 3
XTAL_19M_IN DC_IN_OVP_CTL
228
19M_OUT XTAL_19M_OUT DC_IN_OVP_SNS
171
OVP_CP_DRV
69
XO_OUT_A0 84
XO_OUT_A0
187 C645
XO_OUT_A1 VPRE_CAP
60
XO_OUT_A2
200 VPH_PWR
R611 VCHG
75 216
XO_OUT_D0 TP_605 44
XO_OUT_D0 VCHG
217
XO_OUT_D0_EN 83
XO_OUT_D0_EN VCHG_SNS
XO_OUT_D1
208
52
VSW_SMBC
224
R612
USB3.0_CLK_M 68
XO_OUT_DIFF_N VSW_SMBC
201
USB3.0_CLK_P XO_OUT_DIFF_P VREG_SMBC
70 209
XTAL_32K_IN VDRV_P C654
54
XTAL_32K_OUT
TP606 30 198
VREF_XO SLEEP_CLK SLEEP_CLK VPH_PWR
206
VREG_L11_1P5
VPH_PWR
188 207
VREF_LPDDR3_CA 213
VREF_DDR3_CA VPH_PWR
VREF_LPDDR3_DQ 46
VREF_DDR3_DQ
123
VREF_XO MPP_01|VREF_PADS
156
SDC_UIM_VBIAS
MPP_02|EXT_BOOST_EN
U606
126 148
VSW_WLED MPP_03|VREF_DAC TXDAC0_VREF
R613
97 132
150
VREG_WLED MPP_04|PRIVACY_LED
121
EAR_ADC_3.5
127
WLED_CABC MPP_05|ENET_LDO_EN
145
HDMI_EN
119
WLED_SNK1 MPP_06|ENET_RST_N
136
MHL_RST R616
104
WLED_SNK2 MPP_07|NFC_EXT_EN
153
FLASH_LED_EN
WLED_SNK3 MPP_08|MHL_RESET_N VF
80 39
41
GPLED_SNK1 GPIO_01|KYPD_SNS1
53
FLASH_LED_SET
C659
R617
R618
R620
65 62
49
GPLED_SNK3 GPIO_03|KYPD_SNS3
55 OK_SW
GPLED_SNK4 GPIO_04|KYPD_SNS4
61
ERR_FG
66
GPIO_05|KYPD_SNS5
71 VOL_UP
GPLED_SRC1 GPIO_06|KYPD_SNS6 VT_CAM_STBY
81 77
73
GPLED_SRC2 GPIO_07|KYPD_SNS7
94 CAM_SENSOR_DET
88
GPLED_SRC3 GPIO_08|KYPD_SNS8
76 VT_CAM_A_EN
GPLED_SRC4 GPIO_09|KYPD_DRV1
86 TSP_EN
158
GPIO_10|KYPD_DRV2
93 VT_CAM_IO_EN
190
FLASH_DRV_1 GPIO_11|KYPD_DRV3
110 FSA_EN VREG_S3A_1P8
FLASH_DRV_2 GPIO_12|KYPD_DRV4
157 MAIN_CAM_A_EN
176
GPIO_13|KYPD_DRV5
102
NFC_EN
LED_B 167
RGB_BLU|GP_LED_DRV2 GPIO_14|KYPD_DRV6
109
LCD_1P8_EN
LED_G 160
RGB_GRN|GP_LED_DRV1 GPIO_15|CLK_CODEC
149
DIVCLK1_CODEC
D600 LED_R RGB_RED|LED_ATC|GP_LED_DRV0 GPIO_16|CLK_HAPTICS SLEEP_CLK_WIFI
R640
165
CHG_DET 72
GPIO_17|CLK_QPA1
117
VIB_DRV_N GPIO_18|CLK_QPA2
43
CRESET_B
GPIO_19|MIPI_DSI_RST_N MLCD_RST
D601 180 36
WACOM_SENSE
JIG_ON_N 155
CBL_PWR_N GPIO_20|GOBI_PWR_EN
25
PHONE_ON_N KYPD_PWR_N GPIO_21|EXT_REG_EN1 BOOST_BYP_N
191
OPT_1 GPIO_22|HS_DET
59
EAR_DET
202 34
OPT_2 GPIO_23|KYPD_DRV7
114 105
129
OPT_3 GPIO_24|KYPD_DRV8
51
VT_CAM_NRST
R623 197
OPT_4 GPIO_25|KYPD_DRV9
67
MAIN_CAM_RST
R625 R626 MSM_PS_HOLD PS_HOLD GPIO_26|KYPD_DRV10 FUEL_ALERT
R647 163 184
PHONE_ON_N R624 196
RESIN_N GPIO_27|FLASH_STROBE
194 IRDA_IRQ
PON_1 GPIO_28|TX_GTR_THRESH
159
TX_GTR_THRES
GPIO_29|SD_WP TOUCH_INT
PMIC_SPMI_DATA 147 90 TP_TSP_INT
131
SPMI_DATA GPIO_30|TS_CHGR_IN
143
TSP_INT
PMIC_SPMI_CLK SPMI_CLK GPIO_31|BAT_ALARM
TP_PON_OUT 204 166
PON_OUT 164
PON_OUT GPIO_32|NFC_CLK_REQ
106
PM8941_PON_RESET_N PON_RESET_N GPIO_33|PWM_LED_CTL1 MICBIAS_EN_MSM
128
EAR_MICBIAS_EN
GND_WLED_SMPS
GPIO_34|PWM_LED_CTL2
137
GPIO_35|PWM_LED_CTL3 WACOM_LDO_EN
GND_CHG_HP
GND_CHG_HP
GND_XOADC
146
GPIO_36|PWM_LED_CTL4 HALL_SENSOR_INT
GND_REF
GND_5V
GND_S1
GND_S2
GND_S3
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
NC
NC
100
101
107
108
112
115
116
122
130
175
185
219
225
199
215
168
134
230
231
50
78
91
92
99
48
15
17
95
45
GND_XOADC
GND_S3
GND_S2
GND_S1
GND_REF
8-60
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-3-16. VT CAM
Yes
Abnormal
Yes
Check VTCAM_MCLK No
Replace the PBA.
is 24MHz
Yes
Yes
Yes
END
8-61
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-62
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-3-17. MHL
Yes
No
Check the SUB Con to con
on Main PBA Check if HDC801 is well connected
Yes
No
Check the USB connection
is detected?(Notification alarm) Replace the SUB PCB
Yes
Yes
Replace U908
Yes
END
8-63
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
GND
5 4
CE2 GND
GND
C927 C909 C910 5
9
C911 C912
VMHL_1P8
C4
D5
D4
E5
E6
E4
E3
F5
B5
A2
CVCC12
CVCC12
VDDQ
IOVCC18
IOVCC18
AVCC12
AVCC12
AVCC12
AVCC33
RX_AVCC
G6 B6 C919
HD_TXC+ RXC_P USB_ID
HD_TXC- G7 B3 VMHL_1P8
RXC_N CM-TERM
RSVDL
B7 TP900
HD_TX0+ G4
RX0_P INT
C7
MHL_INT
G5 D6
HD_TX0- RX0_N CI2CA
D7
G2
RESET_N
C1
MHL_RST
HD_TX1+ G3
RX1_P CSCL
D1 MHL_I2C_SCL
HD_TX1- RX1_N U908 CSDA MHL_I2C_SDA
R930
R931
F1 A4
HD_TX2+ RX2_P MHL_DB MHL_DM
G1 A3
HD_TX2- RX2_N MHL_D MHL_DP
A7
C3
CBUS_ID
C6
MHL_ID
RSVD0 V_SENSE R932
B2
RSVD1 R933
C2 F4
A1
RSVD2 DSCL
E1
MHL_DSCL_1.8V
RSVD3 DSDA MHL_DSDA_1.8V
B1
RSVD4 RPWR
F3 TP902
D2 F7
RSVD5 HPD HDMI_HPD
R928
GND
GND
GND
GND
GND
GND
GND
NC
NC
NC
NC
R906
C5
D3
E2
E7
B4
F2
F6
A5
A6
1
R847
R835
V_BAT
U824
1
IN
4
OUT
3
GND
GND
C859
EN
R851
C841
2
5
C831
ZD809
R852
R843
USB3.0_3P3 MHL_DP
V_BUS_5V VREG_L16_2P7
L811
MAIN_MICBIAS_2P8
HDC801
VREG_S3A_1P8
R833
2 2 1 1
MUIC_DM_JTAG
4 4 3 3
MUIC_DP_JTAG
6 6 5 5
8 8 7 7
JTAG_USB_ID
L812
10 10 9 9
12 11
MUIC_ID
12 11
14 14 13 13
16 16 15 15 MHL_DM
18 18 17 17
20 19 R834
20 19
22 21
MUIC_DM
22 21
24 23 R845
MUIC_DP
24 23
26 26 25 25
SPK_OUT_N
28 28 27 27
30 30 29 29
32 31
SPK_OUT_P
32 31
34 34 33 33
36 36 35 35
HALL_SENSOR_INT 38 38 37 37
MHL_ID
40 40 39 39
42 42 41 41
44 44 43 43
USB3.0_SSTX_M 46 45
46 45
USB3.0_SSTX_P
48 48 47 47
ANT_SWITCH_SEL_1
50 50 49 49
USB3.0_SSRX_M MAIN_MIC_N_CONN
52 52 51 51
USB3.0_SSRX_P 54 53
54 53 L813
58
57
56
55
58
57
56
55
C834 C835
C839
MAIN_MIC_P_CONN
C840
C861 L814
ZD804
ZD806
1
ZD801
ZD802
ZD803
ZD805
1
ZD808
8-64
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-65
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-3-18. TSP
Yes
No
Check TSP Connector on Reconnect the HDC800
Main PBA
Yes
No
Check the TSP connector on
LCD Module Reconnect TSP Connector
Yes
Check the No
V_TSP_IO_1P8(C865)
Resolder or Replace the PMIC(U606)
Yes
Yes
Yes
END
8-66
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
GND 6
GND 5
V_TSP_IO_1P8 VREG_L22_3P0
LCD_D3_N 2
I|O I|O
3
LCD_D3_P 1
I|O I|O
4
VCC_1.8V_LCD
F800
ELVDD_4.6V TSP_AVDD_3P3
ELVSS_-4.4V
C865
GND 6
GND 5
ELAVDD_7.0V
LCD_D0_N 2
I|O I|O
3 HDC800
R846
LCD_D0_P 1
I|O I|O
4 1 2
1
0603
2
3 4
F801 5
3 4 TSP_INT
5 6
6
7 8
TP800 9
7 8
10
TS_I2C_S
11
9 10
12
TS_I2C_S
11 12 VPP
13 14
TP801 15
13 14
16
TE
GND 6
GND 5
17
15 16 EL_ON_1
18
19
17 18
20
EL_ON_2
LCD_CLK_N 2
I|O I|O
3 21
19 20
22
21 22
23 24
LCD_CLK_P 1
I|O I|O
4 25
23 24
26
25 26 PCD_INT
27 28
27 28 ERR_FG
F802 29 30 TP802
29 30 MLCD_RST
31 32
31 32 TSP_ID
33 34
TA_TOUCH_SENSE 35
33 34
36
TP_ELVDD_FBS
35 36
37 38
37 38
39 39 40
GND 6
GND 5
40
G GGG
41424344 C813
LCD_D1_N 2
I|O I|O
3
C806
C811
C812
10V
LCD_D1_P 1
I|O I|O
4
F803
GND 6
GND 5
HD OCTA CON
LCD_D2_N 2
I|O I|O
3
LCD_D2_P 1
I|O I|O
4
F804
CAM_DVDD_1P1 VREG_L1_1P2
VREG_L1_1P2_WO_DDR
VREG_L11_1P5
R636
V_TSP_IO_1P8
VREG_L18_2P85
VREG_L19_3P3
VREG_L20_2P95
VREG_L21_2P95
VREG_L22_3P0
VDD_VIB_3P0
VREG_L24_3P075
C605 C606 C607
VREG_S3A_1P8
VREG_S2A_2P15 VREG_LVS1_1P8
CAM_IO_1P8
VREG_S1A_1P3
VREG_LVS3_1P8
VPH_PWR VREG_BOOST_BYPASS
VREG_S2A_2P15
C624 C625 C626 R607
VREG_S3A_1P8
VPH_PWR
BAT600
C628
C627
TP_BAT_THERM
TP_VREF_BAT
TP_VREG_600
TP_BAT_ID
VREG_S1A_1P3
VPH_PWR C631 C632 C633
VPH_PWR
L601
L602
L603
VPH_PWR GND_S3
C639
GND_S2
214
222
223
182
210
169
177
193
218
211
227
103
113
144
151
120
192
140
111
124
133
125
141
174
118
135
161
183
142
GND_S1
63
23
33
87
79
16
32
24
47
31
56
12
35
20
38
28
26
42
27
10
29
13
74
89
18
82
57
85
40
58
98
21
19
22
14
64
96
7
1
9
VREG_L8_1P8
VDD_TORCH
VOUT_5VS_OTG
VDD_RGB
VCOIN
VSW_S3
VSW_5V
VSW_5V
VREG_5V
VREG_5V
VREG_5V_SNS
VIN_5VS
BAT_THERM
BAT_ID
VSW_S1
VREG_S1
VSW_S2
VSW_S2
VREG_S2
VREG_S3
VREG_L1
VREG_L2
VREG_L3
VREG_L4
VREG_L6
VREG_XO|VREG_L7
VREG_L8
VREG_L9
VREG_L10
VREG_L11
VREG_L12
VREG_L13
VREG_L14
VREG_L15
VREG_L16
VREG_L17
VREG_L18
VREG_L19
VREG_L20
VREG_L21
VREG_L22
VREG_L23
VREG_L24
VOUT_LVS1
VOUT_LVS2
VOUT_LVS3
VOUT_5VS_HDMI
VDD_GPLED
VDD_L1_3
VDD_L21
VDD_L4_11
VDD_L5_7
VDD_S1
VDD_S2
VDD_S3
VDD_WLED
VREG_FAULT
VDD_MSM_IO
BATFET_CP_DRV
VREG_BMS
BMS_CSM
BMS_CSP
VDD_INT_BYP
VDD_L13_20_23_24
VDD_FLASH
VDD_L6_12_14_15
VDD_L8_16_18_19
VDD_L9_10_17_22
VBAT
VBAT
VBAT
VREF_BAT
VBAT_SNS
VREG_RF_CLK|VREG_L5
VDD_L2_LVS1_2_3
152 C642
37
REF_BYP GND_REF
XO_THERM XO_THERM
139
OTG_IN TP_OTG_IN
170 226
MSM_THERM 138
AMUX_1 PHY_VBUS TP_USB_PHY_VBUS
R609 R608
BATT_THERM 154
AMUX_2
172
AMUX_3 USB_IN
178 173
PA_THERM1 203
AMUX_4 USB_IN
181
AMUX_5 USB_IN
186 220
AMUX_PU1 DC_IN
195 221
AMUX_PU2 DC_IN
229
DC_IN
179
AMUX_USB_ID
R610 162 189
AMUX_HW_ID OVP_OUT
205
OVP_OUT
11 212
19M_IN 3
XTAL_19M_IN DC_IN_OVP_CTL
228
19M_OUT XTAL_19M_OUT DC_IN_OVP_SNS
171
OVP_CP_DRV
69
XO_OUT_A0 84
XO_OUT_A0
187 C645
XO_OUT_A1 VPRE_CAP
60
XO_OUT_A2
200 VPH_PWR
R611 VCHG
75 216
XO_OUT_D0 TP_605 44
XO_OUT_D0 VCHG
217
XO_OUT_D0_EN 83
XO_OUT_D0_EN VCHG_SNS
XO_OUT_D1
208
52
VSW_SMBC
224
R612
USB3.0_CLK_M 68
XO_OUT_DIFF_N VSW_SMBC
201
USB3.0_CLK_P XO_OUT_DIFF_P VREG_SMBC
70 209
XTAL_32K_IN VDRV_P C654
54
XTAL_32K_OUT
TP606 30 198
VREF_XO SLEEP_CLK SLEEP_CLK VPH_PWR
206
VREG_L11_1P5
VPH_PWR
188 207
VREF_LPDDR3_CA 213
VREF_DDR3_CA VPH_PWR
VREF_LPDDR3_DQ 46
VREF_DDR3_DQ
123
VREF_XO MPP_01|VREF_PADS
156
SDC_UIM_VBIAS
MPP_02|EXT_BOOST_EN
U606
126 148
VSW_WLED MPP_03|VREF_DAC TXDAC0_VREF
R613
97 132
150
VREG_WLED MPP_04|PRIVACY_LED
121
EAR_ADC_3.5
127
WLED_CABC MPP_05|ENET_LDO_EN
145
HDMI_EN
119
WLED_SNK1 MPP_06|ENET_RST_N
136
MHL_RST R616
104
WLED_SNK2 MPP_07|NFC_EXT_EN
153
FLASH_LED_EN
WLED_SNK3 MPP_08|MHL_RESET_N VF
80 39
41
GPLED_SNK1 GPIO_01|KYPD_SNS1
53
FLASH_LED_SET
C659
R617
R618
R620
65 62
49
GPLED_SNK3 GPIO_03|KYPD_SNS3
55
OK_SW
GPLED_SNK4 GPIO_04|KYPD_SNS4
61
ERR_FG
66
GPIO_05|KYPD_SNS5
71
VOL_UP
81
GPLED_SRC1 GPIO_06|KYPD_SNS6
77
VT_CAM_STBY
73
GPLED_SRC2 GPIO_07|KYPD_SNS7
94
CAM_SENSOR_DET
88
GPLED_SRC3 GPIO_08|KYPD_SNS8
76
VT_CAM_A_EN
GPLED_SRC4 GPIO_09|KYPD_DRV1
86
TSP_EN
158
GPIO_10|KYPD_DRV2
93
VT_CAM_IO_EN
190
FLASH_DRV_1 GPIO_11|KYPD_DRV3
110
FSA_EN VREG_S3A_1P8
FLASH_DRV_2 GPIO_12|KYPD_DRV4
157
MAIN_CAM_A_EN
176
GPIO_13|KYPD_DRV5
102
NFC_EN
LED_B 167
RGB_BLU|GP_LED_DRV2 GPIO_14|KYPD_DRV6
109
LCD_1P8_EN
LED_G 160
RGB_GRN|GP_LED_DRV1 GPIO_15|CLK_CODEC
149
DIVCLK1_CODEC
D600 LED_R RGB_RED|LED_ATC|GP_LED_DRV0 GPIO_16|CLK_HAPTICS SLEEP_CLK_WIFI
R640
165
CHG_DET 72
GPIO_17|CLK_QPA1
117
VIB_DRV_N GPIO_18|CLK_QPA2
43
CRESET_B
GPIO_19|MIPI_DSI_RST_N MLCD_RST
D601
JIG_ON_N
180
CBL_PWR_N GPIO_20|GOBI_PWR_EN
36
WACOM_SENSE
155 25
PHONE_ON_N KYPD_PWR_N GPIO_21|EXT_REG_EN1 BOOST_BYP_N
191
OPT_1 GPIO_22|HS_DET
59
EAR_DET
202 34
OPT_2 GPIO_23|KYPD_DRV7
114 105
129
OPT_3 GPIO_24|KYPD_DRV8
51
VT_CAM_NRST
R623 197
OPT_4 GPIO_25|KYPD_DRV9
67
MAIN_CAM_RST
R625 R626 MSM_PS_HOLD PS_HOLD GPIO_26|KYPD_DRV10 FUEL_ALERT
R647 163 184
PHONE_ON_N R624 196
RESIN_N GPIO_27|FLASH_STROBE
194
IRDA_IRQ
PON_1 GPIO_28|TX_GTR_THRESH
159
TX_GTR_THRES
GPIO_29|SD_WP TOUCH_INT
PMIC_SPMI_DATA 147 90 TP_TSP_INT
131
SPMI_DATA GPIO_30|TS_CHGR_IN
143
TSP_INT
PMIC_SPMI_CLK SPMI_CLK GPIO_31|BAT_ALARM
TP_PON_OUT 204 166
PON_OUT 164
PON_OUT GPIO_32|NFC_CLK_REQ
106
PM8941_PON_RESET_N PON_RESET_N GPIO_33|PWM_LED_CTL1
128
MICBIAS_EN_MSM
GPIO_34|PWM_LED_CTL2 EAR_MICBIAS_EN
GND_WLED_SMPS
137
GPIO_35|PWM_LED_CTL3 WACOM_LDO_EN
GND_CHG_HP
GND_CHG_HP
GND_XOADC
146
GPIO_36|PWM_LED_CTL4 HALL_SENSOR_INT
GND_REF
GND_5V
GND_S1
GND_S2
GND_S3
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
NC
NC
100
101
107
108
112
115
116
122
130
175
185
219
225
199
215
168
134
230
231
50
78
91
92
99
48
15
17
95
45
GND_XOADC
GND_S3
GND_S2
GND_S1
GND_REF
8-67
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
VPH_PWR TSP_AVDD_3P3
U821
4 VDD VOUT 1
2
TSP_EN 3 CE GND
GND
C828 C829
8-68
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-3-19. S-pen
Yes
Abnormal
Yes
Yes
Yes
Yes
Yes
END
8-69
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
HDC901
VREG_S3A_1P8 PEN_VD
VDD_EXTJIG
L902 PEN_VD
1 1 2 2
PEN_VREF1 PEN_VREF1 WACOM_3.3V
3 3 4 4
CL00 5 5 6
CL01
6 PEN_VA
CL02 7 7 8
CL03 L903
1
R913 R914
VCCA
15 15 16 16
CL12 17 17 18
CL13 PEN_SCL_1.8V
2
A0 VCCB
8
OE
CL18 23 24
CL19
5
CL20 23 24 CL21
WACOM_LDO_EN
25 25 26 26
CL22 27 28
CL23 C916 U925 C917
37 37 38 38
CL34 39 40
CL35 VREG_S3A_1P8
CL36 39 40 CL37 WACOM_LDO_EN 3 CE GND
2
GND
41 41 42 42
CL38 43 44
CL39 5
CL40 43 44 CL41 C928
C929
45 45 46 46
CL42 47 48
CL43
PEN_VREF1 47 48 PEN_VREF1
49 NC
50 NC
51 NC
52 NC
R923 R924
PEN_PDCT_1.8V PEN_PDCT
PEN_IRQ_1.8V PEN_IRQ
PEN_VA
C903
GND to L1
L2
L9
AVDD
AVDD
AVDD
AVDD
VDD
GND to L1
K1 L4
CL00 K2
ASW0 VREF1
L5 C920 PEN_VREF1
CL01 K3
ASW1 VREFC
CL02 K4
ASW2
A10 C921 C922
CL03 K5
ASW3 LDO15
CL04 K6
ASW4
K8
CL05 K7
ASW5 P00_ANI17_TI00_TxD1
K9
GND to A9 GND to L1
CL06 J1
ASW6 P01_ANI16_TO00_RxD1
F11
CL07 J2
ASW7 P10_SCK00_SCL00
E11
PEN_FWE1
CL08 J3
ASW8 P11_SI00_RXD0_TOOLRXD_SDA00
F9 PEN_RXD
CL09 J4
ASW9 P12_SO00_TXD0_TOOLTXD
E10
PEN_TXD R903
CL10 J5
ASW10 P13_TXD2_SO20
D10
PEN_SDA
CL11 J6
ASW11 P14_RXD2_SI20_SDA20
B10
PEN_SCL R904
CL12 J7
ASW12 P15_SCK20_SCL20
B9
CL13 J8
ASW13 P16_TI01_TO01_INTP5
D11
TP_PEN_IRQ
CL14 J9
ASW14 P17_TI02_TO02
C11
CL15 H1
ASW15 P20_ANI0_AVREFP
K10
CL16 H2
ASW16 P21_ANI1_AVREFM
L11 R925
CL17 H3
ASW17 P22_ANI2
J10
CL18 G1
ASW18 P23_ANI3
E9
CL19 G2
ASW19 P30_INTP3_SCK11_SCL11
D9
CL20 G3
ASW20 P31_TI03_TO03_INTP4
H11
CL21 F3
ASW21 P40_TOOL0
C9
PEN_FWE0 OSC900 C923
CL22 F2
ASW22 P50_INTP1_SI11_SDA11
C10
CL23 E3
ASW23 P51_INTP2_SO11
G9
CL24 E2
ASW24
U915 P60_SCLA0
F10
PEN_PDCT C924
CL25 D1
ASW25 P61_SDAA0
G11 PEN_IRQ
CL26
4
ASW26 P120_ANI19
D2 K11
CL27 D3
ASW27 P121_X1
J11
CL28 C7
ASW28 P122_X2_EXCLK
H9
CL29 C6
ASW29 P137_INTP0
G10
CL30 C5
ASW30 P147_ANI18 PEN_#UART
CL31 C4
ASW31
A8 GND to L10
CL32
3
CL34 C1
ASW34 TMODE2
CL35 B7
ASW35
L8
CL36 B6
ASW36 TIN
CL37 B5
ASW37
L7 R929
CL38 B4
ASW38 REGC
CL39 B3
ASW39
L3
CL40 B2
ASW40 CAL
CL41 B1
ASW41
H10
CL42 A7
ASW42 _RESET PEN_RESET_N
CL43 A6
ASW43
L6
WACOM_KEY_1 A5
ASW44 AOUT PEN_TP_AOUT C908
WACOM_KEY_2 A4
ASW45
1
PEN_VREF1 A3
ASW46 NC
2
ASW47 NC
DGND
AGND
AGND
AGND
AGND
VSS
A11
L10
A1
A9
F1
L1
8-70
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-3-20. Motor
Yes
No
Check the Motor_P, Motor_N. Resolder or Replace : Motor_P, Motor_N.
(soldering crack, open, dent etc)
Yes
Yes
Replace Motor
Yes
END
8-71
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
MOT700
L706
1
1 MOTOR_P
2
2
MOT701
1 L707
1 MOTOR_N
2
2
OSC600
UME500
C601
C601
R637
637
C602
C6 0 2
C688
688
U601
U601
01
C5
C5004
500
000
044
L707
707
HEA500
TP_608
P 6
608
08
08
C559
C559
758
C758
L706
706
C
L7
R721
R721
C6 9 8
58
R458
R647
7
R647
R45
R613
613
C684
C684
C683
R620
620
459
R4599
R927
R927
R45
C664
C6 6 4
C659
659
59
TP_JTAG_RTCK
JTAG
JT
TA
AG RT
AG R
RTCK
T
TC
CK R413
413
41
D602
602
D601
601
D600
600
R415
415
41
D
R650
650
50
R220
220 R223
223
685
BOTHH
O H
HH
HHOLE700
HOL
OLE
LE7
E7000
0
TP221
21
R2
22
2227
7
C230
C2 3 0
C236
C2 3 6
C247
24
T
235
C235
R225
R225
R224
R224
C228
228
C
C234
234
06
U206
C232
232
TP222
P22
P2
222
22
NFC UART
UAR
UAR
AR
RTT R
RXD
XD
C229
22
22
299
L211
211
OSC201
C627
627
R612
612
12 C617
617
17
R609
C639
639
63
608
08
C625
R618
618
18
C621
L602
C623
C632
632 C620
620
MOT701
C610
610
10
C615
615
C624
4
7
MOT7
C695
95
R643
64
64
433
C605
605
C69
PWR
PWR P
WR
C622
C606
C
C
C697
U604
U604
604
L600
MOT700
OT700
PWR
PWR G
WR
O
R642
C696
TA6
TA600
600
600
00
ZD
ZD603
D603
D6 03
8-72
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
NORMAL CONDITION
catch the channel?
NO
YES
YES
YES
NO
Check L104 Resolder or change
≥ -65dBm L104, L103, L107
YES
YES
NO Resolder or change
WB1/LB1 Receiver is O.K?
U300
END
8-73
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
RFS100
3
G
2 G G 4
RFIN
1
RFS101
L170
2 COMMON 1 C101
ANT
3
1
2
3
4
L102
IN
OUT
GND1
L105 VDD_SWITCH_2P7
L103
F100
PRX_B1/4_M
TRM_PORT
COUPLING
C103 L104
GND2
L107
PRX_B1/4_P
C109
6
5
4
0603
C113
WTR0_PDET_IN PRX_B2/3_M
R101
L108 L109
C117
PRX_B2/3_P
16
21 VDD
ANT
2 B1_TX
TX_B1_PA_OUT L112
6 B2_TX
TX_B2_PA_OUT PRX_GSM850_B5_M
4 B3_TX L111
TX_B3/4_PA_OUT 8 B5_TX 26 L113
B1_RX
TX_B5_PA_OUT 9 27
TX_B8_PA_OUT B8_TX B1_RX
42 B20_TX B2|B3_RX 28 L115
TX_B17/20_PA_OUT_S PRX_GSM850_B5_P
B2|3_RX 29
23 TRX1 B5_RX 32
TRX_B7 F104 33
24 TRX2 B5_RX
B20_RX 37 L117
PRX_B17/20_M
12 GSM_HB_TX B20_RX 38
TX_GSMHB_PA_OUT L120
13 GSM_LB_TX L118
TX_GSMLB_PA_OUT 30
D|PCS_RX
20 CTL1 D|PCS_RX 31 L121
ANT_SW_SEL0 19
PRX_B17/20_P
ANT_SW_SEL1 CTL2
18 CTL3 B8|EGSM_RX 34
ANT_SW_SEL2
17 CTL4 B8|EGSM_RX 35
ANT_SW_SEL3 L123
RX_GSMHB_P
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
L122 L166
41
43
44
45
46
47
48
1
3
5
7
10
11
14
15
22
25
36
39
40
L125
RX_GSMHB_M
C172
C169
C170
C171
L127
PRX_GSM900_B8_M
L126 L128
L129
PRX_GSM900_B8_P
VREF_XO
C604 R603
XO_THERM
OSC600 C608
4 3
19M_OUT
1 2
19M_IN GND_XOADC
VDD_RF2_T_VCO_136
VDD_RF2_P_VCO_67
VDD_RF2_S_VCO_51
VDD_RF2_T_DA_111
VDD_RF2_T_BB_108
VDD_RF2_T_PLL_97
VDD_RF2_D_BB_44
VDD_RF2_P_BB_83
VDD_RF2_XO_127
VDD_RF1_D_MBLO_25
VDD_RF1_P_FELO_42
VDD_RF1_P_FELO_53
VDD_RF1_T_UPC_117
VDD_RF1_D_LBLO_28
VDD_RF1_P_VCO_76
VDD_RF1_S_VCO_40
VDD_RF1_T_SYN_98
VDD_RF1_T_DA_118
VDD_RF1_T_LO_116
VDD_RF1_P_PLL_66
VDD_RF1_S_PLL_65
VDD_RF1_G_VCO_37
VDD_RF1_G_LNA_24
VDD_RF1_G_PLL_55
VDD_RF1_G_BB_31
VDD_RF1_D_FE_26
VDD_RF1_JDET_85
VDD_DIO_87
C334
118
116
117
108
111
136
127
87
26
28
25
31
24
55
37
85
42
53
66
76
65
40
98
44
83
67
51
97
VDD_DIO
VDD_RF2_XO
VDD_RF1_D_FE
VDD_RF1_P_VCO
VDD_RF1_S_VCO
VDD_RF2_P_VCO
VDD_RF2_S_VCO
VDD_RF2_T_VCO
VDD_RF1_T_SYN
VDD_RF1_T_UPC
VDD_RF1_G_VCO
VDD_RF1_JDET
VDD_RF1_T_LO
VDD_RF1_T_DA
VDD_RF2_T_DA
VDD_RF1_P_FELO
VDD_RF1_P_FELO
VDD_RF2_T_PLL
VDD_RF1_G_BB
VDD_RF1_G_LNA
VDD_RF2_D_BB
VDD_RF2_P_BB
VDD_RF2_T_BB
VDD_RF1_D_MBLO
VDD_RF1_G_PLL
VDD_RF1_P_PLL
VDD_RF1_S_PLL
VDD_RF1_D_LBLO
7
TX_LB3
133
RF_TX_B5/8
PRX_B7_P PRX_HB_INP TX_LB4
15
PRX_B7_M PRX_HB_INM
126
TX_MB1
5 119
DRX_B5/8_P 14
DRX_LB1_INP TX_MB2
112
RF_TX_B3/4
DRX_B5/8_M DRX_LB1_INM TX_MB3
95
RF_TX_B1/2
4
TX_MB4 RF_TX_G1800/1900
DRX_B17/20_P DRX_LB2_INP
13 103
DRX_B17/20_M DRX_LB2_INM TX_HB RF_TX_B7
3 109
DRX_B1/2/3/4_P 12
DRX_MB_INP DAC_REF
96
WTR0_BB_TX_IDAC
DRX_B1/2/3/4_M DRX_MB_INM GP_CLK
2 114
DRX_B7_P 11
DRX_HB_INP GP_SYNC
DRX_B7_M DRX_HB_INM
88
GP_DATA2
10 121
GPS_RF_P 18
GNSS_INP GP_DATA1
105
GSM_TX_PHASE_D1
GPS_RF_M GNSS_INM GP_DATA0 GSM_TX_PHASE_D0
101 80 TP300 WTR0_SSBI2_PRX_DRX
WTR0_PDET_SEL PDET_IN SSBI_PRX_DRX
89 TP301
130
SSBI_TX_GNSS WTR0_SSBI1_TX_GPS
WTR0_BB_TX_IP 138
TX_BB_IP
45
WTR0_BB_TX_IM TX_BB_IM RX_ON
100
WTR0_RX_ON0
131
RF_ON
86
WTR0_RF_ON0
WTR0_BB_TX_QP 139
TX_BB_QP JAM_DET
79
WTR0_BB_TX_QM TX_BB_QM VTUNE_PRX
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
DNC
NC
NC
102
104
106
107
110
113
115
122
123
124
125
128
129
134
135
137
142
143
144
19
20
21
22
27
29
32
33
34
35
38
39
41
46
47
49
52
58
59
64
68
73
74
75
77
81
94
99
90
1
8-74
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-75
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
NORMAL CONDITION
catch the channel?
NO
YES
YES
YES
NO
Check L109 Resolder or change
≥ -65dBm L108,C113,C117
YES
YES
NO Resolder or change
WB2 / LB3 Receiver is O.K?
U300
END
8-76
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
RFS100
3
G
2 G G 4
RFIN
1
RFS101
L170
2 COMMON 1 C101
ANT
3
1
2
3
4
L102
IN
OUT
GND1
L105 VDD_SWITCH_2P7
L103
F100
PRX_B1/4_M
TRM_PORT
COUPLING
C103 L104
GND2
L107
PRX_B1/4_P
C109
6
5
4
0603
C113
WTR0_PDET_IN PRX_B2/3_M
R101
L108 L109
C117
PRX_B2/3_P
16
21 VDD
ANT
2 B1_TX
TX_B1_PA_OUT L112
6 B2_TX
TX_B2_PA_OUT PRX_GSM850_B5_M
4 B3_TX L111
TX_B3/4_PA_OUT 8 B5_TX 26 L113
B1_RX
TX_B5_PA_OUT 9 27
TX_B8_PA_OUT B8_TX B1_RX
42 B20_TX B2|B3_RX 28 L115
TX_B17/20_PA_OUT_S PRX_GSM850_B5_P
B2|3_RX 29
23 TRX1 B5_RX 32
TRX_B7 F104 33
24 TRX2 B5_RX
B20_RX 37 L117
PRX_B17/20_M
12 GSM_HB_TX B20_RX 38
TX_GSMHB_PA_OUT L120
13 GSM_LB_TX L118
TX_GSMLB_PA_OUT 30
D|PCS_RX
20 CTL1 D|PCS_RX 31 L121
ANT_SW_SEL0 19
PRX_B17/20_P
ANT_SW_SEL1 CTL2
18 CTL3 B8|EGSM_RX 34
ANT_SW_SEL2
17 CTL4 B8|EGSM_RX 35
ANT_SW_SEL3 L123
RX_GSMHB_P
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
L122 L166
41
43
44
45
46
47
48
1
3
5
7
10
11
14
15
22
25
36
39
40
L125
RX_GSMHB_M
C172
C169
C170
C171
L127
PRX_GSM900_B8_M
L126 L128
L129
PRX_GSM900_B8_P
VREF_XO
C604 R603
XO_THERM
OSC600 C608
4 3
19M_OUT
1 2
19M_IN GND_XOADC
VDD_RF2_T_VCO_136
VDD_RF2_P_VCO_67
VDD_RF2_S_VCO_51
VDD_RF2_T_DA_111
VDD_RF2_T_BB_108
VDD_RF2_T_PLL_97
VDD_RF2_D_BB_44
VDD_RF2_P_BB_83
VDD_RF2_XO_127
VDD_RF1_D_MBLO_25
VDD_RF1_P_FELO_42
VDD_RF1_P_FELO_53
VDD_RF1_T_UPC_117
VDD_RF1_D_LBLO_28
VDD_RF1_P_VCO_76
VDD_RF1_S_VCO_40
VDD_RF1_T_SYN_98
VDD_RF1_T_DA_118
VDD_RF1_T_LO_116
VDD_RF1_P_PLL_66
VDD_RF1_S_PLL_65
VDD_RF1_G_VCO_37
VDD_RF1_G_LNA_24
VDD_RF1_G_PLL_55
VDD_RF1_G_BB_31
VDD_RF1_D_FE_26
VDD_RF1_JDET_85
VDD_DIO_87
C334
118
116
117
108
111
136
127
87
26
28
25
31
24
55
37
85
42
53
66
76
65
40
98
44
83
67
51
97
VDD_DIO
VDD_RF2_XO
VDD_RF1_D_FE
VDD_RF1_P_VCO
VDD_RF1_S_VCO
VDD_RF2_P_VCO
VDD_RF2_S_VCO
VDD_RF2_T_VCO
VDD_RF1_T_SYN
VDD_RF1_T_UPC
VDD_RF1_G_VCO
VDD_RF1_JDET
VDD_RF1_T_LO
VDD_RF1_T_DA
VDD_RF2_T_DA
VDD_RF1_P_FELO
VDD_RF1_P_FELO
VDD_RF2_T_PLL
VDD_RF1_G_BB
VDD_RF1_G_LNA
VDD_RF2_D_BB
VDD_RF2_P_BB
VDD_RF2_T_BB
VDD_RF1_D_MBLO
VDD_RF1_G_PLL
VDD_RF1_P_PLL
VDD_RF1_S_PLL
VDD_RF1_D_LBLO
7
TX_LB3
133
RF_TX_B5/8
PRX_B7_P PRX_HB_INP TX_LB4
15
PRX_B7_M PRX_HB_INM
126
TX_MB1
5 119
DRX_B5/8_P 14
DRX_LB1_INP TX_MB2
112
RF_TX_B3/4
DRX_B5/8_M DRX_LB1_INM TX_MB3
95
RF_TX_B1/2
4
TX_MB4 RF_TX_G1800/1900
DRX_B17/20_P DRX_LB2_INP
13 103
DRX_B17/20_M DRX_LB2_INM TX_HB RF_TX_B7
3 109
DRX_B1/2/3/4_P 12
DRX_MB_INP DAC_REF
96
WTR0_BB_TX_IDAC
DRX_B1/2/3/4_M DRX_MB_INM GP_CLK
2 114
DRX_B7_P 11
DRX_HB_INP GP_SYNC
DRX_B7_M DRX_HB_INM
88
GP_DATA2
10 121
GPS_RF_P 18
GNSS_INP GP_DATA1
105
GSM_TX_PHASE_D1
GPS_RF_M GNSS_INM GP_DATA0 GSM_TX_PHASE_D0
101 80 TP300 WTR0_SSBI2_PRX_DRX
WTR0_PDET_SEL PDET_IN SSBI_PRX_DRX
89 TP301
130
SSBI_TX_GNSS WTR0_SSBI1_TX_GPS
WTR0_BB_TX_IP 138
TX_BB_IP
45
WTR0_BB_TX_IM TX_BB_IM RX_ON
100
WTR0_RX_ON0
131
RF_ON
86
WTR0_RF_ON0
WTR0_BB_TX_QP 139
TX_BB_QP JAM_DET
79
WTR0_BB_TX_QM TX_BB_QM VTUNE_PRX
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
DNC
NC
NC
102
104
106
107
110
113
115
122
123
124
125
128
129
134
135
137
142
143
144
19
20
21
22
27
29
32
33
34
35
38
39
41
46
47
49
52
58
59
64
68
73
74
75
77
81
94
99
90
1
8-77
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-78
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
NORMAL CONDITION
catch the channel?
NO
YES
YES
YES
NO
Check L113 Resolder or change
≥ -65dBm L113, L112, L115
YES
YES
NO Resolder or change
WB5 / LB5 / G850 Receiver is O.K?
U300
END
8-79
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
RFS100
3
G
2 G G 4
RFIN
1
RFS101
L170
2 COMMON 1 C101
ANT
3
1
2
3
4
L102
IN
OUT
GND1
L105 VDD_SWITCH_2P7
L103
F100
PRX_B1/4_M
TRM_PORT
COUPLING
C103 L104
GND2
L107
PRX_B1/4_P
C109
6
5
4
0603
C113
WTR0_PDET_IN PRX_B2/3_M
R101
L108 L109
C117
PRX_B2/3_P
16
21 VDD
ANT
2 B1_TX
TX_B1_PA_OUT L112
6 B2_TX
TX_B2_PA_OUT PRX_GSM850_B5_M
4 B3_TX L111
TX_B3/4_PA_OUT 8 B5_TX 26 L113
B1_RX
TX_B5_PA_OUT 9 27
TX_B8_PA_OUT B8_TX B1_RX
42 B20_TX B2|B3_RX 28 L115
TX_B17/20_PA_OUT_S PRX_GSM850_B5_P
B2|3_RX 29
23 TRX1 B5_RX 32
TRX_B7 F104 33
24 TRX2 B5_RX
B20_RX 37 L117
PRX_B17/20_M
12 GSM_HB_TX B20_RX 38
TX_GSMHB_PA_OUT L120
13 GSM_LB_TX L118
TX_GSMLB_PA_OUT 30
D|PCS_RX
20 CTL1 D|PCS_RX 31 L121
ANT_SW_SEL0 19
PRX_B17/20_P
ANT_SW_SEL1 CTL2
18 CTL3 B8|EGSM_RX 34
ANT_SW_SEL2
17 CTL4 B8|EGSM_RX 35
ANT_SW_SEL3 L123
RX_GSMHB_P
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
L122 L166
41
43
44
45
46
47
48
1
3
5
7
10
11
14
15
22
25
36
39
40
L125
RX_GSMHB_M
C172
C169
C170
C171
L127
PRX_GSM900_B8_M
L126 L128
L129
PRX_GSM900_B8_P
VREF_XO
C604 R603
XO_THERM
OSC600 C608
4 3
19M_OUT
1 2
19M_IN GND_XOADC
VDD_RF2_T_VCO_136
VDD_RF2_P_VCO_67
VDD_RF2_S_VCO_51
VDD_RF2_T_DA_111
VDD_RF2_T_BB_108
VDD_RF2_T_PLL_97
VDD_RF2_D_BB_44
VDD_RF2_P_BB_83
VDD_RF2_XO_127
VDD_RF1_D_MBLO_25
VDD_RF1_P_FELO_42
VDD_RF1_P_FELO_53
VDD_RF1_T_UPC_117
VDD_RF1_D_LBLO_28
VDD_RF1_P_VCO_76
VDD_RF1_S_VCO_40
VDD_RF1_T_SYN_98
VDD_RF1_T_DA_118
VDD_RF1_T_LO_116
VDD_RF1_P_PLL_66
VDD_RF1_S_PLL_65
VDD_RF1_G_VCO_37
VDD_RF1_G_LNA_24
VDD_RF1_G_PLL_55
VDD_RF1_G_BB_31
VDD_RF1_D_FE_26
VDD_RF1_JDET_85
VDD_DIO_87
C334
118
116
117
108
111
136
127
87
26
28
25
31
24
55
37
85
42
53
66
76
65
40
98
44
83
67
51
97
VDD_DIO
VDD_RF2_XO
VDD_RF1_D_FE
VDD_RF1_P_VCO
VDD_RF1_S_VCO
VDD_RF2_P_VCO
VDD_RF2_S_VCO
VDD_RF2_T_VCO
VDD_RF1_T_SYN
VDD_RF1_T_UPC
VDD_RF1_G_VCO
VDD_RF1_JDET
VDD_RF1_T_LO
VDD_RF1_T_DA
VDD_RF2_T_DA
VDD_RF1_P_FELO
VDD_RF1_P_FELO
VDD_RF2_T_PLL
VDD_RF1_G_BB
VDD_RF1_G_LNA
VDD_RF2_D_BB
VDD_RF2_P_BB
VDD_RF2_T_BB
VDD_RF1_D_MBLO
VDD_RF1_G_PLL
VDD_RF1_P_PLL
VDD_RF1_S_PLL
VDD_RF1_D_LBLO
7
TX_LB3
133
RF_TX_B5/8
PRX_B7_P PRX_HB_INP TX_LB4
15
PRX_B7_M PRX_HB_INM
126
TX_MB1
5 119
DRX_B5/8_P 14
DRX_LB1_INP TX_MB2
112
RF_TX_B3/4
DRX_B5/8_M DRX_LB1_INM TX_MB3
95
RF_TX_B1/2
4
TX_MB4 RF_TX_G1800/1900
DRX_B17/20_P DRX_LB2_INP
13 103
DRX_B17/20_M DRX_LB2_INM TX_HB RF_TX_B7
3 109
DRX_B1/2/3/4_P 12
DRX_MB_INP DAC_REF
96
WTR0_BB_TX_IDAC
DRX_B1/2/3/4_M DRX_MB_INM GP_CLK
2 114
DRX_B7_P 11
DRX_HB_INP GP_SYNC
DRX_B7_M DRX_HB_INM
88
GP_DATA2
10 121
GPS_RF_P 18
GNSS_INP GP_DATA1
105
GSM_TX_PHASE_D1
GPS_RF_M GNSS_INM GP_DATA0 GSM_TX_PHASE_D0
101 80 TP300 WTR0_SSBI2_PRX_DRX
WTR0_PDET_SEL PDET_IN SSBI_PRX_DRX
89 TP301
130
SSBI_TX_GNSS WTR0_SSBI1_TX_GPS
WTR0_BB_TX_IP 138
TX_BB_IP
45
WTR0_BB_TX_IM TX_BB_IM RX_ON
100
WTR0_RX_ON0
131
RF_ON
86
WTR0_RF_ON0
WTR0_BB_TX_QP 139
TX_BB_QP JAM_DET
79
WTR0_BB_TX_QM TX_BB_QM VTUNE_PRX
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
DNC
NC
NC
102
104
106
107
110
113
115
122
123
124
125
128
129
134
135
137
142
143
144
19
20
21
22
27
29
32
33
34
35
38
39
41
46
47
49
52
58
59
64
68
73
74
75
77
81
94
99
90
1
8-80
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-81
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
NORMAL CONDITION
catch the channel?
NO
YES
YES
YES
NO
Check L128 Resolder or change
≥ -65dBm L126, L127, L129
YES
YES
NO Resolder or change
WB8 / LB8 / G900 Receiver is O.K?
U300
END
8-82
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
RFS100
3
G
2 G G 4
RFIN
1
RFS101
L170
2 COMMON 1 C101
ANT
3
1
2
3
4
L102
IN
OUT
GND1
L105 VDD_SWITCH_2P7
L103
F100
PRX_B1/4_M
TRM_PORT
COUPLING
C103 L104
GND2
L107
PRX_B1/4_P
C109
6
5
4
0603
C113
WTR0_PDET_IN PRX_B2/3_M
R101
L108 L109
C117
PRX_B2/3_P
16
21 VDD
ANT
2 B1_TX
TX_B1_PA_OUT L112
6 B2_TX
TX_B2_PA_OUT PRX_GSM850_B5_M
4 B3_TX L111
TX_B3/4_PA_OUT 8 B5_TX 26 L113
B1_RX
TX_B5_PA_OUT 9 27
TX_B8_PA_OUT B8_TX B1_RX
42 B20_TX B2|B3_RX 28 L115
TX_B17/20_PA_OUT_S PRX_GSM850_B5_P
B2|3_RX 29
23 TRX1 B5_RX 32
TRX_B7 F104 33
24 TRX2 B5_RX
B20_RX 37 L117
PRX_B17/20_M
12 GSM_HB_TX B20_RX 38
TX_GSMHB_PA_OUT L120
13 GSM_LB_TX L118
TX_GSMLB_PA_OUT 30
D|PCS_RX
20 CTL1 D|PCS_RX 31 L121
ANT_SW_SEL0 19
PRX_B17/20_P
ANT_SW_SEL1 CTL2
18 CTL3 B8|EGSM_RX 34
ANT_SW_SEL2
17 CTL4 B8|EGSM_RX 35
ANT_SW_SEL3 L123
RX_GSMHB_P
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
L122 L166
41
43
44
45
46
47
48
1
3
5
7
10
11
14
15
22
25
36
39
40
L125
RX_GSMHB_M
C172
C169
C170
C171
L127
PRX_GSM900_B8_M
L126 L128
L129
PRX_GSM900_B8_P
VREF_XO
C604 R603
XO_THERM
OSC600 C608
4 3
19M_OUT
1 2
19M_IN GND_XOADC
VDD_RF2_T_VCO_136
VDD_RF2_P_VCO_67
VDD_RF2_S_VCO_51
VDD_RF2_T_DA_111
VDD_RF2_T_BB_108
VDD_RF2_T_PLL_97
VDD_RF2_D_BB_44
VDD_RF2_P_BB_83
VDD_RF2_XO_127
VDD_RF1_D_MBLO_25
VDD_RF1_P_FELO_42
VDD_RF1_P_FELO_53
VDD_RF1_T_UPC_117
VDD_RF1_D_LBLO_28
VDD_RF1_P_VCO_76
VDD_RF1_S_VCO_40
VDD_RF1_T_SYN_98
VDD_RF1_T_DA_118
VDD_RF1_T_LO_116
VDD_RF1_P_PLL_66
VDD_RF1_S_PLL_65
VDD_RF1_G_VCO_37
VDD_RF1_G_LNA_24
VDD_RF1_G_PLL_55
VDD_RF1_G_BB_31
VDD_RF1_D_FE_26
VDD_RF1_JDET_85
VDD_DIO_87
C334
118
116
117
108
111
136
127
87
26
28
25
31
24
55
37
85
42
53
66
76
65
40
98
44
83
67
51
97
VDD_DIO
VDD_RF2_XO
VDD_RF1_D_FE
VDD_RF1_P_VCO
VDD_RF1_S_VCO
VDD_RF2_P_VCO
VDD_RF2_S_VCO
VDD_RF2_T_VCO
VDD_RF1_T_SYN
VDD_RF1_T_UPC
VDD_RF1_G_VCO
VDD_RF1_JDET
VDD_RF1_T_LO
VDD_RF1_T_DA
VDD_RF2_T_DA
VDD_RF1_P_FELO
VDD_RF1_P_FELO
VDD_RF2_T_PLL
VDD_RF1_G_BB
VDD_RF1_G_LNA
VDD_RF2_D_BB
VDD_RF2_P_BB
VDD_RF2_T_BB
VDD_RF1_D_MBLO
VDD_RF1_G_PLL
VDD_RF1_P_PLL
VDD_RF1_S_PLL
VDD_RF1_D_LBLO
7
TX_LB3
133
RF_TX_B5/8
PRX_B7_P PRX_HB_INP TX_LB4
15
PRX_B7_M PRX_HB_INM
126
TX_MB1
5 119
DRX_B5/8_P 14
DRX_LB1_INP TX_MB2
112
RF_TX_B3/4
DRX_B5/8_M DRX_LB1_INM TX_MB3
95
RF_TX_B1/2
4
TX_MB4 RF_TX_G1800/1900
DRX_B17/20_P DRX_LB2_INP
13 103
DRX_B17/20_M DRX_LB2_INM TX_HB RF_TX_B7
3 109
DRX_B1/2/3/4_P 12
DRX_MB_INP DAC_REF
96
WTR0_BB_TX_IDAC
DRX_B1/2/3/4_M DRX_MB_INM GP_CLK
2 114
DRX_B7_P 11
DRX_HB_INP GP_SYNC
DRX_B7_M DRX_HB_INM
88
GP_DATA2
10 121
GPS_RF_P 18
GNSS_INP GP_DATA1
105
GSM_TX_PHASE_D1
GPS_RF_M GNSS_INM GP_DATA0 GSM_TX_PHASE_D0
101 80 TP300 WTR0_SSBI2_PRX_DRX
WTR0_PDET_SEL PDET_IN SSBI_PRX_DRX
89 TP301
130
SSBI_TX_GNSS WTR0_SSBI1_TX_GPS
WTR0_BB_TX_IP 138
TX_BB_IP
45
WTR0_BB_TX_IM TX_BB_IM RX_ON
100
WTR0_RX_ON0
131
RF_ON
86
WTR0_RF_ON0
WTR0_BB_TX_QP 139
TX_BB_QP JAM_DET
79
WTR0_BB_TX_QM TX_BB_QM VTUNE_PRX
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
DNC
NC
NC
102
104
106
107
110
113
115
122
123
124
125
128
129
134
135
137
142
143
144
19
20
21
22
27
29
32
33
34
35
38
39
41
46
47
49
52
58
59
64
68
73
74
75
77
81
94
99
90
1
8-83
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-84
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-3-25. LTE B7 RX
CONTINUOUS RX ON
RF INPUT : 3100 CH
AMP : -50dBm
NORMAL CONDITION
catch the channel?
NO
YES
YES
YES
NO
Check C187, F102 6PIN Resolder or change
≥ -65dBm C187, F102
YES
NO
Check L164 Resolder or change
≥ -65dBm C179,C180,L141
YES
YES
NO Resolder or change
LB7 Receiver is O.K?
U300
END
8-85
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
RFS100
3
G
2 G G 4
RFIN
1
RFS101
L170
2 COMMON 1 C101
ANT
G
G
3
1
2
3
4
L102
OUT
GND1
IN
L105 VDD_SWITCH_2P7
L103
F100
PRX_B1/4_M
TRM_PORT
COUPLING
C103 L104
GND2
L107
PRX_B1/4_P
C109
6
5
4
0603
C113
WTR0_PDET_IN PRX_B2/3_M
R101
L108 L109
C117
PRX_B2/3_P
16
21 VDD
ANT
2 B1_TX
TX_B1_PA_OUT L112
6 B2_TX
TX_B2_PA_OUT PRX_GSM850_B5_M
4 B3_TX L111
TX_B3/4_PA_OUT 26 L113
8 B5_TX B1_RX
TX_B5_PA_OUT 27
9 B1_RX
TX_B8_PA_OUT B8_TX
42 B20_TX B2|B3_RX 28 L115
TX_B17/20_PA_OUT_S PRX_GSM850_B5_P
B2|3_RX 29
23 TRX1 B5_RX 32
TRX_B7 F104 33
24 TRX2 B5_RX
B20_RX 37 L117
38
PRX_B17/20_M
12 GSM_HB_TX B20_RX
TX_GSMHB_PA_OUT L120
13 GSM_LB_TX L118
TX_GSMLB_PA_OUT 30
D|PCS_RX
20 CTL1 D|PCS_RX 31 L121
ANT_SW_SEL0 19
PRX_B17/20_P
ANT_SW_SEL1 CTL2
18 CTL3 B8|EGSM_RX 34
ANT_SW_SEL2
17 CTL4 B8|EGSM_RX 35
ANT_SW_SEL3 L123
GND
GND
GND
GND
GND
GND
GND
RX_GSMHB_P
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
L122 L166
46
47
48
15
22
25
36
39
40
41
43
44
45
1
3
5
7
10
11
14
L125
RX_GSMHB_M
C169
C170
C171
C172
L127
PRX_GSM900_B8_M
L126 L128
L129
PRX_GSM900_B8_P
VREF_XO
C604 R603
VPA
XO_THERM
OSC600 C608
4 3
19M_OUT
1 2
VPA_BATT
19M_IN GND_XOADC C187
R104 TRX_B7
L176 C179
C147
C148 C149 PRX_B7_M
PA100 F102
4
ANT
1 10 L141
VCC1 VCC2 L164
6
L177 RX_B C180
C150 C188 C151 C189 2 9 1 VREF_XO 7
RF_TX_B7 RFIN RFOUT TX RX_A
PRX_B7_P
3 8
VBAT NC
G
G
G
G
G
L151 C155 L152 C156 L153
2
3
5
8
9
4 7 C604
R603
VREG0_1P8 VIO GND
5 6
RFFE1_DATA SDTA SCLK RFFE1_CLK
GND
XO_THERM
OSC600
11
C608
4 3
19M_OUT
1 2
19M_IN GND_XOADC
VDD_RF2_T_VCO_136
VDD_RF2_P_VCO_67
VDD_RF2_S_VCO_51
VDD_RF2_T_DA_111
VDD_RF2_T_BB_108
VDD_RF2_T_PLL_97
VDD_RF2_D_BB_44
VDD_RF2_P_BB_83
VDD_RF2_XO_127
VDD_RF1_D_MBLO_25
VDD_RF1_T_UPC_117
VDD_RF1_P_FELO_42
VDD_RF1_P_FELO_53
VDD_RF1_D_LBLO_28
VDD_RF1_P_VCO_76
VDD_RF1_S_VCO_40
VDD_RF1_T_SYN_98
VDD_RF1_T_DA_118
VDD_RF1_T_LO_116
VDD_RF1_P_PLL_66
VDD_RF1_S_PLL_65
VDD_RF1_G_VCO_37
VDD_RF1_G_LNA_24
VDD_RF1_G_PLL_55
VDD_RF1_D_FE_26
VDD_RF1_G_BB_31
VDD_RF1_JDET_85
VDD_DIO_87
C334
118
116
117
108
111
136
127
87
26
28
25
31
24
55
37
85
42
53
66
76
65
40
98
44
83
67
51
97
VDD_RF1_T_SYN
VDD_RF1_G_VCO
VDD_RF1_P_VCO
VDD_RF1_S_VCO
VDD_RF2_P_VCO
VDD_RF2_S_VCO
VDD_RF2_T_VCO
VDD_RF1_T_UPC
VDD_RF1_D_FE
VDD_RF1_P_FELO
VDD_RF1_P_FELO
VDD_RF2_XO
VDD_RF1_T_DA
VDD_RF2_T_DA
VDD_DIO
VDD_RF1_D_MBLO
VDD_RF1_JDET
VDD_RF1_T_LO
VDD_RF1_G_PLL
VDD_RF1_P_PLL
VDD_RF1_S_PLL
VDD_RF1_G_LNA
VDD_RF2_D_BB
VDD_RF2_P_BB
VDD_RF2_T_PLL
VDD_RF1_G_BB
VDD_RF2_T_BB
VDD_RF1_D_LBLO
7
TX_LB3
133
RF_TX_B5/8
PRX_B7_P PRX_HB_INP TX_LB4
15
PRX_B7_M PRX_HB_INM
126
TX_MB1
5 119
DRX_B5/8_P 14
DRX_LB1_INP TX_MB2
112
RF_TX_B3/4
DRX_B5/8_M DRX_LB1_INM TX_MB3
95
RF_TX_B1/2
4
TX_MB4 RF_TX_G1800/1900
DRX_B17/20_P DRX_LB2_INP
13 103
DRX_B17/20_M DRX_LB2_INM TX_HB RF_TX_B7
3 109
DRX_B1/2/3/4_P 12
DRX_MB_INP DAC_REF
96
WTR0_BB_TX_IDAC
DRX_B1/2/3/4_M DRX_MB_INM GP_CLK
2 114
DRX_B7_P 11
DRX_HB_INP GP_SYNC
DRX_B7_M DRX_HB_INM
88
GP_DATA2
10 121
GPS_RF_P 18
GNSS_INP GP_DATA1
105
GSM_TX_PHASE_D1
GPS_RF_M GNSS_INM GP_DATA0 GSM_TX_PHASE_D0
101 80 TP300 WTR0_SSBI2_PRX_DRX
WTR0_PDET_SEL PDET_IN SSBI_PRX_DRX
89 TP301
130
SSBI_TX_GNSS WTR0_SSBI1_TX_GPS
WTR0_BB_TX_IP 138
TX_BB_IP
45
WTR0_BB_TX_IM TX_BB_IM RX_ON
100
WTR0_RX_ON0
131
RF_ON
86
WTR0_RF_ON0
WTR0_BB_TX_QP 139
TX_BB_QP JAM_DET
79
WTR0_BB_TX_QM TX_BB_QM VTUNE_PRX
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
DNC
NC
NC
102
104
106
107
110
113
115
122
123
124
125
128
129
134
135
137
142
143
144
19
20
21
22
27
29
32
33
34
35
38
39
41
46
47
49
52
58
59
64
68
73
74
75
77
81
94
99
90
1
8-86
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-87
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
NORMAL CONDITION
catch the channel?
NO
YES
YES
YES
NO
Check L118 Resolder or change
≥ -65dBm L117, L120, L121
YES
YES
NO Resolder or change
LB20 Receiver is O.K?
U300
END
8-88
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
RFS100
3
G
2 G G 4
RFIN
1
RFS101
L170
2 COMMON 1 C101
ANT
G
G
3
1
2
3
4
L102
OUT
GND1
IN
L105 VDD_SWITCH_2P7
L103
F100
PRX_B1/4_M
TRM_PORT
COUPLING
C103 L104
GND2
L107
PRX_B1/4_P
C109
6
5
4
0603
C113
WTR0_PDET_IN PRX_B2/3_M
R101
L108 L109
C117
PRX_B2/3_P
16
21 VDD
ANT
2 B1_TX
TX_B1_PA_OUT L112
6 B2_TX
TX_B2_PA_OUT PRX_GSM850_B5_M
4 B3_TX L111
TX_B3/4_PA_OUT 26 L113
8 B5_TX B1_RX
TX_B5_PA_OUT 27
9 B1_RX
TX_B8_PA_OUT B8_TX
42 B20_TX B2|B3_RX 28 L115
TX_B17/20_PA_OUT_S PRX_GSM850_B5_P
B2|3_RX 29
23 TRX1 B5_RX 32
TRX_B7 F104 33
24 TRX2 B5_RX
B20_RX 37 L117
38
PRX_B17/20_M
12 GSM_HB_TX B20_RX
TX_GSMHB_PA_OUT L120
13 GSM_LB_TX L118
TX_GSMLB_PA_OUT 30
D|PCS_RX
20 CTL1 D|PCS_RX 31 L121
ANT_SW_SEL0 19
PRX_B17/20_P
ANT_SW_SEL1 CTL2
18 CTL3 B8|EGSM_RX 34
ANT_SW_SEL2
17 CTL4 B8|EGSM_RX 35
ANT_SW_SEL3 L123
GND
GND
GND
GND
GND
GND
GND
RX_GSMHB_P
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
L122 L166
46
47
48
15
22
25
36
39
40
41
43
44
45
1
3
5
7
10
11
14
L125
RX_GSMHB_M
C172
C169
C170
C171
L127
PRX_GSM900_B8_M
L126 L128
L129
PRX_GSM900_B8_P
VREF_XO
C604 R603
XO_THERM
OSC600 C608
4 3
19M_OUT
1 2
19M_IN GND_XOADC
VDD_RF2_T_VCO_136
VDD_RF2_P_VCO_67
VDD_RF2_S_VCO_51
VDD_RF2_T_DA_111
VDD_RF2_T_BB_108
VDD_RF2_T_PLL_97
VDD_RF2_D_BB_44
VDD_RF2_P_BB_83
VDD_RF2_XO_127
VDD_RF1_D_MBLO_25
VDD_RF1_P_FELO_42
VDD_RF1_P_FELO_53
VDD_RF1_T_UPC_117
VDD_RF1_D_LBLO_28
VDD_RF1_P_VCO_76
VDD_RF1_S_VCO_40
VDD_RF1_T_SYN_98
VDD_RF1_T_DA_118
VDD_RF1_T_LO_116
VDD_RF1_P_PLL_66
VDD_RF1_S_PLL_65
VDD_RF1_G_VCO_37
VDD_RF1_G_LNA_24
VDD_RF1_G_PLL_55
VDD_RF1_D_FE_26
VDD_RF1_G_BB_31
VDD_RF1_JDET_85
VDD_DIO_87
C334
118
116
117
108
111
136
127
87
26
28
25
31
24
55
37
85
42
53
66
76
65
40
98
44
83
67
51
97
VDD_RF1_G_VCO
VDD_RF1_P_VCO
VDD_RF1_S_VCO
VDD_RF2_P_VCO
VDD_RF2_S_VCO
VDD_RF2_T_VCO
VDD_RF1_T_SYN
VDD_RF1_T_UPC
VDD_RF1_D_FE
VDD_RF1_P_FELO
VDD_RF1_P_FELO
VDD_RF2_XO
VDD_RF1_T_DA
VDD_RF2_T_DA
VDD_DIO
VDD_RF1_D_MBLO
VDD_RF1_JDET
VDD_RF1_T_LO
VDD_RF1_G_PLL
VDD_RF1_P_PLL
VDD_RF1_S_PLL
VDD_RF1_G_LNA
VDD_RF2_D_BB
VDD_RF2_P_BB
VDD_RF2_T_PLL
VDD_RF1_G_BB
VDD_RF2_T_BB
VDD_RF1_D_LBLO
7
TX_LB3
133
RF_TX_B5/8
PRX_B7_P PRX_HB_INP TX_LB4
15
PRX_B7_M PRX_HB_INM
126
TX_MB1
5 119
DRX_B5/8_P 14
DRX_LB1_INP TX_MB2
112
RF_TX_B3/4
DRX_B5/8_M DRX_LB1_INM TX_MB3
95
RF_TX_B1/2
4
TX_MB4 RF_TX_G1800/1900
DRX_B17/20_P DRX_LB2_INP
13 103
DRX_B17/20_M DRX_LB2_INM TX_HB RF_TX_B7
3 109
DRX_B1/2/3/4_P 12
DRX_MB_INP DAC_REF
96
WTR0_BB_TX_IDAC
DRX_B1/2/3/4_M DRX_MB_INM GP_CLK
2 114
DRX_B7_P 11
DRX_HB_INP GP_SYNC
DRX_B7_M DRX_HB_INM
88
GP_DATA2
10 121
GPS_RF_P 18
GNSS_INP GP_DATA1
105
GSM_TX_PHASE_D1
GPS_RF_M GNSS_INM GP_DATA0 GSM_TX_PHASE_D0
101 80 TP300 WTR0_SSBI2_PRX_DRX
WTR0_PDET_SEL PDET_IN SSBI_PRX_DRX
89 TP301
130
SSBI_TX_GNSS WTR0_SSBI1_TX_GPS
WTR0_BB_TX_IP 138
TX_BB_IP
45
WTR0_BB_TX_IM TX_BB_IM RX_ON
100
WTR0_RX_ON0
131
RF_ON
86
WTR0_RF_ON0
WTR0_BB_TX_QP 139
TX_BB_QP JAM_DET
79
WTR0_BB_TX_QM TX_BB_QM VTUNE_PRX
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
DNC
NC
NC
102
104
106
107
110
113
115
122
123
124
125
128
129
134
135
137
142
143
144
19
20
21
22
27
29
32
33
34
35
38
39
41
46
47
49
52
58
59
64
68
73
74
75
77
81
94
99
90
1
8-89
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-90
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
NORMAL CONDITION
catch the channel?
NO
YES
YES
YES
NO
Check L166 Resolder or change
≥ -65dBm L166, L122, L123, L125
YES
YES
NO Resolder or change
DCS / PCS Receiver is O.K?
U300
END
8-91
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
RFS100
3
G
2 G G 4
RFIN
1
RFS101
L170
2 COMMON 1 C101
ANT
G
G
3
1
2
3
4
L102
OUT
GND1
IN
L105 VDD_SWITCH_2P7
L103
F100
PRX_B1/4_M
TRM_PORT
COUPLING
C103 L104
GND2
L107
PRX_B1/4_P
C109
6
5
4
0603
C113
WTR0_PDET_IN PRX_B2/3_M
R101
L108 L109
C117
PRX_B2/3_P
16
21 VDD
ANT
2 B1_TX
TX_B1_PA_OUT L112
6 B2_TX
TX_B2_PA_OUT PRX_GSM850_B5_M
4 B3_TX L111
TX_B3/4_PA_OUT 26 L113
8 B5_TX B1_RX
TX_B5_PA_OUT 27
9 B1_RX
TX_B8_PA_OUT B8_TX
42 B20_TX B2|B3_RX 28 L115
TX_B17/20_PA_OUT_S PRX_GSM850_B5_P
B2|3_RX 29
23 TRX1 B5_RX 32
TRX_B7 F104 33
24 TRX2 B5_RX
B20_RX 37 L117
38
PRX_B17/20_M
12 GSM_HB_TX B20_RX
TX_GSMHB_PA_OUT L120
13 GSM_LB_TX L118
TX_GSMLB_PA_OUT 30
D|PCS_RX
20 CTL1 D|PCS_RX 31 L121
ANT_SW_SEL0 19
PRX_B17/20_P
ANT_SW_SEL1 CTL2
18 CTL3 B8|EGSM_RX 34
ANT_SW_SEL2
17 CTL4 B8|EGSM_RX 35
ANT_SW_SEL3 L123
GND
GND
GND
GND
GND
GND
GND
RX_GSMHB_P
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
L122 L166
46
47
48
15
22
25
36
39
40
41
43
44
45
1
3
5
7
10
11
14
L125
RX_GSMHB_M
C172
C169
C170
C171
L127
PRX_GSM900_B8_M
L126 L128
L129
PRX_GSM900_B8_P
VREF_XO
C604 R603
XO_THERM
OSC600 C608
4 3
19M_OUT
1 2
19M_IN GND_XOADC
VDD_RF2_T_VCO_136
VDD_RF2_P_VCO_67
VDD_RF2_S_VCO_51
VDD_RF2_T_DA_111
VDD_RF2_T_BB_108
VDD_RF2_T_PLL_97
VDD_RF2_D_BB_44
VDD_RF2_P_BB_83
VDD_RF2_XO_127
VDD_RF1_D_MBLO_25
VDD_RF1_P_FELO_42
VDD_RF1_P_FELO_53
VDD_RF1_T_UPC_117
VDD_RF1_D_LBLO_28
VDD_RF1_P_VCO_76
VDD_RF1_S_VCO_40
VDD_RF1_T_SYN_98
VDD_RF1_T_DA_118
VDD_RF1_T_LO_116
VDD_RF1_P_PLL_66
VDD_RF1_S_PLL_65
VDD_RF1_G_VCO_37
VDD_RF1_G_LNA_24
VDD_RF1_G_PLL_55
VDD_RF1_D_FE_26
VDD_RF1_G_BB_31
VDD_RF1_JDET_85
VDD_DIO_87
C334
118
116
117
108
111
136
127
87
26
28
25
31
24
55
37
85
42
53
66
76
65
40
98
44
83
67
51
97
VDD_RF1_G_VCO
VDD_RF1_P_VCO
VDD_RF1_S_VCO
VDD_RF2_P_VCO
VDD_RF2_S_VCO
VDD_RF2_T_VCO
VDD_RF1_T_SYN
VDD_RF1_T_UPC
VDD_RF1_D_FE
VDD_RF1_P_FELO
VDD_RF1_P_FELO
VDD_RF2_XO
VDD_RF1_T_DA
VDD_RF2_T_DA
VDD_DIO
VDD_RF1_D_MBLO
VDD_RF1_JDET
VDD_RF1_T_LO
VDD_RF1_G_PLL
VDD_RF1_P_PLL
VDD_RF1_S_PLL
VDD_RF1_G_LNA
VDD_RF2_D_BB
VDD_RF2_P_BB
VDD_RF2_T_PLL
VDD_RF1_G_BB
VDD_RF2_T_BB
VDD_RF1_D_LBLO
7
TX_LB3
133
RF_TX_B5/8
PRX_B7_P PRX_HB_INP TX_LB4
15
PRX_B7_M PRX_HB_INM
126
TX_MB1
5 119
DRX_B5/8_P 14
DRX_LB1_INP TX_MB2
112
RF_TX_B3/4
DRX_B5/8_M DRX_LB1_INM TX_MB3
95
RF_TX_B1/2
4
TX_MB4 RF_TX_G1800/1900
DRX_B17/20_P DRX_LB2_INP
13 103
DRX_B17/20_M DRX_LB2_INM TX_HB RF_TX_B7
3 109
DRX_B1/2/3/4_P 12
DRX_MB_INP DAC_REF
96
WTR0_BB_TX_IDAC
DRX_B1/2/3/4_M DRX_MB_INM GP_CLK
2 114
DRX_B7_P 11
DRX_HB_INP GP_SYNC
DRX_B7_M DRX_HB_INM
88
GP_DATA2
10 121
GPS_RF_P 18
GNSS_INP GP_DATA1
105
GSM_TX_PHASE_D1
GPS_RF_M GNSS_INM GP_DATA0 GSM_TX_PHASE_D0
101 80 TP300 WTR0_SSBI2_PRX_DRX
WTR0_PDET_SEL PDET_IN SSBI_PRX_DRX
89 TP301
130
SSBI_TX_GNSS WTR0_SSBI1_TX_GPS
WTR0_BB_TX_IP 138
TX_BB_IP
45
WTR0_BB_TX_IM TX_BB_IM RX_ON
100
WTR0_RX_ON0
131
RF_ON
86
WTR0_RF_ON0
WTR0_BB_TX_QP 139
TX_BB_QP JAM_DET
79
WTR0_BB_TX_QM TX_BB_QM VTUNE_PRX
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
DNC
NC
NC
102
104
106
107
110
113
115
122
123
124
125
128
129
134
135
137
142
143
144
19
20
21
22
27
29
32
33
34
35
38
39
41
46
47
49
52
58
59
64
68
73
74
75
77
81
94
99
90
1
8-92
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-93
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-3-28. GSM850/GSM900 TX
CONTINUOUS TX ON CONDITION
TX POWER IDX1 APPLIED
GSM850 CH : 190
GSM900 CH : 62
RBW : 100KHz
VBW : 100KHz
SPAN : 10MHz
REF LEV. : 10dBm
ATT. : 20dB
YES
YES
YES
YES
YES
NO Resolder or change
GSM850/900 Transmitte
is O.K? UCP404-1
END
8-94
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
RFS100
3
G
2 G G 4
RFIN
1
RFS101
L170
2 COMMON 1 C101
ANT
G
G
3
1
2
4
3
L102
IN
OUT
GND1
L105 VDD_SWITCH_2P7
L103
F100
PRX_B1/4_M
TRM_PORT
COUPLING
C103 L104
GND2
L107
PRX_B1/4_P
C109
6
5
4
0603
C113
WTR0_PDET_IN PRX_B2/3_M
R101
L108 L109
C117
PRX_B2/3_P
16
21 VDD
ANT
2 B1_TX
TX_B1_PA_OUT L112
6 B2_TX
TX_B2_PA_OUT PRX_GSM850_B5_M
4 B3_TX L111
TX_B3/4_PA_OUT 26 L113
8 B5_TX B1_RX
TX_B5_PA_OUT 27
9 B1_RX
TX_B8_PA_OUT B8_TX
42 B20_TX 28 L115
TX_B17/20_PA_OUT_S B2|B3_RX PRX_GSM850_B5_P
B2|3_RX 29
23 TRX1 B5_RX 32
TRX_B7 F104 33
24 TRX2 B5_RX
37 L117
B20_RX PRX_B17/20_M
12 GSM_HB_TX B20_RX 38
TX_GSMHB_PA_OUT L120
13 GSM_LB_TX L118
TX_GSMLB_PA_OUT 30
D|PCS_RX
20 CTL1 D|PCS_RX 31 L121
ANT_SW_SEL0
19
PRX_B17/20_P
ANT_SW_SEL1 CTL2
18 CTL3 B8|EGSM_RX 34
ANT_SW_SEL2
17 CTL4 B8|EGSM_RX 35
ANT_SW_SEL3 L123
RX_GSMHB_P
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
L122 L166
48
1
3
5
7
15
22
25
36
39
40
41
43
44
45
46
47
10
11
14
L125
RX_GSMHB_M
C170
C171
C172
C169
L127
PRX_GSM900_B8_M
L126 L128
L129
PRX_GSM900_B8_P
L100 L101
L171 VPA VPA_GSM VPA_BATT RF_TX_B1/2
TX_B1_PA_OUT
C106
C107 L106
C104
C110 C178 C111 C183
C112
RF_TX_B3/4
L172
TX_B2_PA_OUT C116
C118
L110
26
11
27
28
1
35 F101
VCC2
VCC1
VCC_GSM
VBATT
RFOUT_B1 RFIN_B1_B2
32 2
L173 RFOUT_B2 RFIN_B3_B4 L114
C121 34 4 C122 2 4
TX_B3/4_PA_OUT R103 33
RFOUT_B3 RFIN_B5_B8
3
OUT IN RF_TX_B5/8
RFOUT_B4 RFIN_B26
31
RFOUT_B5_B26 GND2 GND1
L116 C123 29 U100 RFIN_GSM_HB
13
RFOUT_B8
RFIN_GSM_LB
14 3 1
24
RFOUT_GSM_HB
22 6
VIO VREG0_1P8
NC
RFOUT_GSM_LB
8
SCLK
9
RFFE1_CLK
C185
37
SDATA RFFE1_DATA
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
TX_B5_PA_OUT
C124
19
18
17
16
15
12
10
RF_TX_G1800/1900
43
42
41
40
39
38
36
30
25
23
21
20
54
53
52
51
50
49
48
47
46
45
44
7
5
C125 C126
C128
C186
TX_B8_PA_OUT
C130
RF_TX_G850/900
L174 C132
C133
L130
TX_GSMHB_PA_OUT
C134 C135
L131
TX_GSMLB_PA_OUT
L133 C139
VREF_XO
C604 R603
XO_THERM
VDD_RF2_T_VCO_136
VDD_RF2_P_VCO_67
VDD_RF2_S_VCO_51
VDD_RF2_T_DA_111
VDD_RF2_T_BB_108
VDD_RF2_T_PLL_97
VDD_RF2_D_BB_44
VDD_RF2_P_BB_83
OSC600 C608
VDD_RF2_XO_127
4 3
19M_OUT
VDD_RF1_D_MBLO_25
VDD_RF1_T_UPC_117
VDD_RF1_P_FELO_42
VDD_RF1_P_FELO_53
VDD_RF1_D_LBLO_28
VDD_RF1_P_VCO_76
VDD_RF1_S_VCO_40
VDD_RF1_T_SYN_98
VDD_RF1_T_DA_118
VDD_RF1_T_LO_116
VDD_RF1_P_PLL_66
VDD_RF1_S_PLL_65
VDD_RF1_G_VCO_37
VDD_RF1_G_LNA_24
VDD_RF1_G_PLL_55
1 2
19M_IN GND_XOADC
VDD_RF1_D_FE_26
VDD_RF1_G_BB_31
VDD_RF1_JDET_85
VDD_DIO_87
C334
118
116
117
108
111
136
127
87
26
28
25
31
24
55
37
85
42
53
66
76
65
40
98
44
83
67
51
97
VDD_DIO
VDD_RF2_XO
VDD_RF1_D_FE
VDD_RF1_P_VCO
VDD_RF1_S_VCO
VDD_RF1_T_LO
VDD_RF2_P_VCO
VDD_RF2_S_VCO
VDD_RF1_T_SYN
VDD_RF1_JDET
VDD_RF1_G_VCO
VDD_RF2_T_VCO
VDD_RF1_T_UPC
VDD_RF1_T_DA
VDD_RF2_D_BB
VDD_RF2_T_DA
VDD_RF1_P_FELO
VDD_RF1_P_FELO
VDD_RF2_T_PLL
VDD_RF1_G_BB
VDD_RF1_G_LNA
VDD_RF2_P_BB
VDD_RF2_T_BB
VDD_RF1_G_PLL
VDD_RF1_P_PLL
VDD_RF1_S_PLL
VDD_RF1_D_MBLO
VDD_RF1_D_LBLO
2 114
DRX_B7_P 11
DRX_HB_INP GP_SYNC
DRX_B7_M DRX_HB_INM
88
GP_DATA2
10 121
GPS_RF_P 18
GNSS_INP GP_DATA1
105
GSM_TX_PHASE_D1
GPS_RF_M GNSS_INM GP_DATA0 GSM_TX_PHASE_D0
101 80 TP300 WTR0_SSBI2_PRX_DRX
WTR0_PDET_SEL PDET_IN SSBI_PRX_DRX
89 TP301
130
SSBI_TX_GNSS WTR0_SSBI1_TX_GPS
WTR0_BB_TX_IP 138
TX_BB_IP
45
WTR0_BB_TX_IM TX_BB_IM RX_ON
100
WTR0_RX_ON0
131
RF_ON
86
WTR0_RF_ON0
WTR0_BB_TX_QP 139
TX_BB_QP JAM_DET
79
WTR0_BB_TX_QM TX_BB_QM VTUNE_PRX
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
DNC
NC
NC
102
104
106
107
110
113
115
122
123
124
125
128
129
134
135
137
142
143
144
19
20
21
22
27
29
32
33
34
35
38
39
41
46
47
49
52
58
59
64
68
73
74
75
77
81
94
99
90
1
6
8-95
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
VDD_MIPI_DSI_LDO_0P4
VT_CAM_CLK_N
VT_CAM_CLK_P
VT_CAM_D0_N
VT_CAM_D1_N
VT_CAM_D0_P
VT_CAM_D1_P
MAIN_CAM_CLK_N
MAIN_CAM_CLK_P
MAIN_CAM_D0_N
MAIN_CAM_D1_N
MAIN_CAM_D2_N
MAIN_CAM_D3_N
MAIN_CAM_D0_P
MAIN_CAM_D1_P
MAIN_CAM_D2_P
MAIN_CAM_D3_P
MCU_AP_INT_1_1.8V
PEN_RESET_N_1.8V
T_FLASH_DETECT
CODEC_RESET_N
FPGA_MAIN_CLK
BT_HOST_WAKE
SHUB_SPI_MISO
EAR_SEND_END
SHUB_SPI_MOSI
NFC_FIRMWARE
PEN_FWE1_1.8V
EXT_BUCK_SDA
EXT_BUCK_SCL
BT_PCM_SYNC
BT_PCM_OUT
BT_PCM_CLK
BTP_RST_N
LCD_CLK_N
LCD_CLK_P
BT_PCM_IN
HW_REV(1)
HW_REV(2)
LCD_D0_N
LCD_D1_N
LCD_D2_N