Beruflich Dokumente
Kultur Dokumente
A. Apparatus
Isoteniscope assembly (Pakisulat na lang na kaparehas ng format sa manual)
Isoteniscope
Thermometer
3-way stopcock
Rubber tubing
Vacuum pump
Water bath with heater and stirrer
Manometer
Condenser
Suction flask
Barometer
B. Reagents
Acetone
Methanol
C. Procedure
Isoteniscope
Clean with acetone.
Rinse with experimental liquid.
Fill the main bulb with more than half full of the test liquid.
Place some liquid in the U-trap.
Place a small amount of grease on the tip of the condenser.
Attach on the assembly as shown in Figure 4.1.
Isoteniscope assembly
Close all the holes of both the 3-way stopcocks.
Turn on the vacuum pump.
Test for leaks.
Apply a little vacuum.
Enclose stopcock.
Observe for change in mercury levels in the manometer.
Locate leak and fix the system.
Adjust properly the 3-way stopcock for 2-3 minutes while avoiding to
evaporate too much of the liquid in the U-tube.
Admit air carefully through the stopcock until the liquid levels in both arms of
the U-tube are equal while making sure that the air will not bubble back to the
isoteniscope.
Record vapor pressure at different increasing and decreasing temperatures
and its corresponding temperature starting at 20° below that of the normal
boiling point of the test liquid at 2° intervals every five minutes.
Open all holes of both the 3-way stopcocks.
Turn off vacuum pump.
Record atmospheric pressure and room temperature.
Perform two trials for each reagent.
Ung step 4, 5, and 6, baka kaya mong sabihin in better words… D ako cgurado kung tama
pagkaintindi ko…