the bag, you organized in a purse. will need: Scissors %yard of lightweight fusible interfacing Cut a 7x17-inch piece of D interfacing. Pin the interfacing, fusible side up, to the cardboard. Pins Cardboard Various ribbons totaling Cut enough 17-inch-long approximately II strips of ribbon to cover 9 yards, some 17 inches long and the interfacing. Pin the ribbons side some 7 inches by side on the interfacing, as shown long, % to 1Y2 at right. inches wide Fusible hemming _ Cut several ribbons 7 inches tape - long. Pin fusible hemming tape Iron to the ribbon backs. 7x17-inch piece of lining fabric _ Weave short ribbons Thread to match IioI through the ribbons pinned to ribbons Snap the cardboard. Pin ribbon ends. Decorative button
r.. Using an iron, fuse the ribbons
- to the interfacing, removing the pins. Trim the edges even.
r.. Place the lining fabric on the
I:rI woven ribbon piece, right sides facing. Stitch together using a y,-inch seam allowance and leaving one short end open. Trim the seams and turn to the right side.
n Measure 6Yz inches from the
. . stitched short end. Fold the woven piece at this point, right sides facing. Hand-stitch both side seams. Turn right side out. 1 more idea _" • For an extra-special gift, use the bag to r.II To make the flap point, wrap a piece of jewelry I:rI measure 3 inches from the open end on each side. Fold the corners together. Hand-stitch the also try this .. . corners to the center of the flap. • Decorate the point of the bag flap with r.tI Sew a snap closure to the a lapel pin. .... flap point and the bag. Sew a decorative button on the flap.