Beruflich Dokumente
Kultur Dokumente
com/cadcamlessons)
(https://www.youtube.com/channel/UCMDxOMPPh5i92Bahyg8BbdQ)
cadcamlessons
(http://cadcamlessons.com/)
CAD/CAM lessons from scratch
Main Menu
In this lesson and few next we will draw simple geometry. A er that we will use this geometry to machine.
Start the Alphacam and from Geometry Tab select Rectangle command
(http://cadcamlessons.com/wp-content/uploads/2018/01/alphacam-drawing-01.png)
Commad Pick First Corner, pick point from Alphacam workspace or type XY coordinates. For the first point
we will use X0Y0. Select OK by le mouse button (LMB).
Now, we have to Pick Second Corner. Type X400 Y200, and click OK.
(http://cadcamlessons.com/wp-content/uploads/2018/01/alphacam-drawing-03.png)
(http://cadcamlessons.com/wp-content/uploads/2018/01/alphacam-drawing-04.png)
For the first point type X40 Y40, and for the second point type X360 Y160.
(http://cadcamlessons.com/wp-content/uploads/2018/01/alphacam-drawing-05.png)
Expand the menu below Circle command from Geometry Tab and select Center + Diameter command.
(http://cadcamlessons.com/wp-content/uploads/2018/01/alphacam-drawing-06.png)
(http://cadcamlessons.com/wp-content/uploads/2018/01/alphacam-drawing-07.png)
(http://cadcamlessons.com/wp-content/uploads/2018/01/alphacam-drawing-08.png)
The Center + Diameter command is still active. Accept Circle Diameter = 9 by clicking OK, and type
coordinates of the new circle X25 Y175, click OK.
Next, accept the diameter = 9 and type new coordinates X375 Y175, click OK.
And again, accept diameter = 9 and type X375 Y25, click OK.
We should get:
(http://cadcamlessons.com/wp-content/uploads/2018/01/alphacam-drawing-09.png)
(http://cadcamlessons.com/wp-content/uploads/2018/01/alphacam-drawing-10.png)
Click OK.
Now, we have to specify circle’s coordinates. We can type X and Y values or use snap to put circle’s center in
the proper place.
(http://cadcamlessons.com/wp-content/uploads/2018/01/alphacam-drawing-11.png)
(http://cadcamlessons.com/wp-content/uploads/2018/01/alphacam-drawing-12.png)
(http://cadcamlessons.com/wp-content/uploads/2018/01/alphacam-drawing-13.png)
And we will get new circle with the same center as first circle.
(http://cadcamlessons.com/wp-content/uploads/2018/01/alphacam-drawing-15.png)
(http://cadcamlessons.com/wp-content/uploads/2018/01/alphacam-drawing-16.png)