Sie sind auf Seite 1von 11

Engr.

Muhammad Shafique
1. *H=D+J is:
A) Continuity Equation
B) Maxwell’s Equation
C) Poisson’s Equation
D) Fourier’s Equation
2. ________________Is A Device That Produces A Constant Voltage Across Its (V=E) No Matter What
Current Is Drawn From It.
A) Ideal Voltage Source
B) Real Voltage Source
C )Ideal Current Source
D) Real Current Source And Voltage Source
3. Complex Electronic Circuit Can Be Analyzed By Passive Models As Resistance, Inductance
And________________________
A) Current
B) Voltage
C) Capacitance
D) Both Current And Voltage
4. The Sum Of All Potential Differences In A Complete Loop Thourgh The Ciruit Shoud Be:
A) Equal To Zero
B) Equal To Individual Voltages
C) Equal To Individual Current (Nts)
D) Equal To Individual Resistance
5. Fundamental Property Used In Single Node Pair Ciruit Analyzer Is That ___________________Across All
Elements Is Same.
A) Current
B) Voltage
C) Resistance
D) Inductance
6. If We Have Two Points “A” And “B” Or Node And The Voltage Is Represented By Vab, The
______________Is Taken As Reference.
A) Node “A”
B) Node “B”
C) Origin Point
D) Both A And B
7. A Relay Used For Protection For Motors Against Overload Is.
A) Impedance Relay
B) Electromagnetic Attraction Type
C) Thermal Relay
D) Buchholz’s Relay
8. Soiled Grounding Is Used For Voltages:
A) Above 220kv
B) Above 11kv
C) Above 33kv
D) Below 660v
9. Rc Snubber Circuit Is Used To Limit The Rate Of __________________In Its Off State.
A) Rise Of Current In Scr
B) Rise Of Voltage Across Scr
C) Conduction Period
D) All Of The Above
10. _____________________Is Not A Basic Element Of Transformer.
A) Corey
B) Primary Winding
C) Secondary Winding
Engr. Muhammad Shafique
D) Mutual Flux
11. For Ideal Transformer:
A) Winding Have No Resistance
B) Core Has No Losses
C) Core Has Infinite Permeability
D) All Of The Above
12. Natural Uranium Containts_____________________________Of U-235.
A) Zero %
B) 0.1 %
C) 0.7 %
D) 0.5 %
13. Transmission Lines Mostly Use High Voltage ______________________ Alternating Current.
A) Single Phase
B) Three Phase
C) Two Phase
D) Nuetral Phase
14. _____________________Like Three Phase, Gives Constant Power Transfer To Linear Load.
A) High Voltage Direct Current
B) Split Phase Electric Power
C) Two Phase Electric Power
D) Single Phase Electric Power
15. Requirement Of Variable Speed Can Be Met By A__________________
A) Variable Frequency Device
B) Wounded Rotor
C) Traction Motor
D) Shunt Motor
16. In _____________________ The Current Leads The Voltage By 90 Degree Or The Voltage Lags The
Current By 90 Degree.
A) Resistive Circuits
B) Inductive Circuits
C) Capacitive Circuits
D) Amplifier Circuits
E) C Lamper Circuits
17. Which Of The Following Converts Thermal Energy To Kinetic Energy?
A) Thermocouples
B) Storage Battery
C) Photovoltaic Cell
D) Rocket
18. In Which Of The Following Power Plant The Availability Of Power Is Least Reliable?
A) Solar Power Plant
B) Wind Energy
C) Tidal Power Plant
D)Geothermal Power Plant
19. Which Engine Has The Highest Air Fuel Ratio?
A) Petrol Engine
B) Gas Engine
C) Diesel Engine
D) Gas Turbine
20. Norton’s Theorem Is Applicable To Resistive Circuit Having ___________________ In Parallel With
Single Resistor Non Resistive Circuits Or Ideal Impedance.
A) Single Voltage Source
B) Single Current Source
C) Single Current And Voltage Source
Engr. Muhammad Shafique
D) Double Voltage Source

21. An Active Device Is One Which _______________________ ?


A) Supplies Energy To Rise
B) Absorbs Energy
C) Convert Energy From One Form To Other
D) Supplies And Absorbs Energy
E) Supplies Energy To Circuit And Converts Energy From One Form To Another
22. Voltage Is Difference In ________________________ Between Two Points.
A) Magnetic Pressure
B) Lorentz Pressure
C) Electric Pressure
D) Ohm’s Pressure
23. The Oscilloscope Is ________________________ Measuring Device.
A) Current
B) Voltage
C) Resistance
D) Capacitance
24. In The Super Position Theorem All Voltage Sources Are Replaced By:
A) Close Circuit
B) Open Circuit
C) Short Circuit
D) Parallel Circuit That Is Open
25. The Superposition Theorem Is Use In Converting Any Circuit Into.
A) Thevenin Equivalent
B) Norton Equivalent
C) Thevenin And Norton Equivalent
D) Norton Equivalent
26. Fly back converter is a:
A) AC to AC Converter
B) AC to DC Converter
C) DC to AC Converter
D) DC to DC Converter
27. Series capacitors in a transmission line are used to:
A) Reduce Line Loading
B) Improve Steady State Stability
C) Improve Protection Of Line
D) Reduce The Voltage Of Buses At The Two Ends
28. The Load Carrying Capacity Of A Long Ac Line Is:
A) Limited By Conductor Size
B) Limited By Stability Considerations
C) Limited By Thermal Consideration
D) Decreased By Using Bundle Conductors
29. Generally In Load Flow Solutions The Load Is Modeled As A:
A) Constant Impedance Load
B) Constant Power Load
C) Constant Current Load
D) Dynamically Varying Load
30. The _____________________ State That The Induced E.M.F ( In Volts ) In Any Closed Circuit Is Equal To
The Time Rate Of Change Of Magnetic Flux Linkage.
A) Stoker’s Theorem
B) Gauss’s Law
C) Faraday’s Law
Engr. Muhammad Shafique
D) Ampere’s Law
E) Biot- Savart’s Law

31. An Orthogonal System Is One In Which The Coordinates Are.


A) Parallel
B) Perpendicular
C) Similar
D) Both Parallel And Perpendicular
32. Advance Mobile Phone System ( Amps ) Uses ________________ For Modulations Technique.
A) Fm
B) Fsk
C) Pm
D) Both A And B
33. The Torque Of Induction Motor Is.
A) Proportional To Slip
B) Inversely Proportional To Slip
C) Proportional To The Square Of Slip
D) Proportional To The Rotor Current
34. If An Alternator Has 8 Poles In One Revolution It Will Generate ___________________ Hz Frequency.
A) 10
B) 4
C) 8
D) 16
35. Normally The Torque Angle Of The Alternator Is Degrees.
A) 3 To 5
B) 2 To 3
C) 15 To 30
D) 1 To 3
36. If The Resistance Of Field Winding Is Increased The Output Voltage Will.
A) Increased
B) Decreased
C) Remain Same
D) Decrease Proportional To The Resistance Of The Field
37. If The Frequency Of Signal Increased The Transformer The Iron Loss Will.
A) Decrease
B) Increase
C) Not Change
D) Reach Nearly Zero
38. The Advantage Of Larger Phase Mercury Arc Rectifier Is That:
A) They Are Easily Available
B) They Are Noise Less
C) They Are Very Cheap
D) The Output Is Much Smoother
39. The Mercury Arc Rectifier Is Used As.
A) Convertor Only
B) Inventor Only
C) Transducer
D) Both A And B
40. Hollow Conductor Are Used In Transmission Lines To.
A) Reduce The Weight Of The Conductor
B) Improve Power Transfer Capability
C) Reduce Corona
D) Increase The Stability
Engr. Muhammad Shafique

41. Shunt Reactors Are Needed To.


A) Boost Receiving End Voltage Under Light Loads
B) Boost Receiving End Voltage Under Heavy Loads
C) Bring Down Receiving End Voltage Under Light Loads
D) Bring Down Receiving End Voltage Under Heavy Loads
42. GSM Uses ______________________________ Techniques For Multiplexing.
A) CDMA
B) TDMA
C) FDMA
D) Both TDMA And FDMA
43. In A Line Ground Fault On A System, The Fault Current Is 1500ampere. The Zero Sequence Current Is.
A) 1500ampere
B) 0ampere
C) 750ampere
D) 500ampere
44. In Order To Reduce The Cost Of Power Generation.
A) The Load Factor And Diversity Factor Should Be Low
B) The Load Factor And Diversity Factor Should Be High
C) The Load Factor Should Be High And Diversity Factor Should Be Low
D) The Load Factor Should Be Low And Diversity Factor Should Be High
45. Find The Voltage Drops Across A Toaster That Gives Off 7500 J Of Heat When A 13.64 Ampere Current
Flows Through It For 5 Seconds.
A) 20 V
B) 100 V
C) 10 V
D) 110 V
E) 120 V
46. In A Transformer When There Is No Load Current The Applied Voltage Will Be.
A) Lag By 90 Degree
B) Lag By Somewhat Less Than 90 Degree
C) Leads By 90 Degree
D) Lead By Somewhat Less Than 90 Degree
47. What Is The Resistance Of A Soldering Iron That Draws A Current Of 0.6 Ampere At 120 V.
A) 100 Ω
B) 150 Ω
C) 200 Ω
D) 250 Ω
E) 300 Ω
48. Power Input To A Transformer Having No Load At Rated Voltage Comprises Predominantly Of:
A) Copper Loss
B) Hysteresis Loss
C) Core Loss
D) Eddy Current Loss
49. In A DC Machine, The Angle Between The Stator And Rotor Field Is:
A) Dependent Upon The Load
B) 45˚
C) 90˚
D) 180˚
50. Why Are Pole Tips In A DC Machine Chamfered?
Engr. Muhammad Shafique
A) To Improve Commutation Characteristics
B) To Reduce Armature Reaction Effect
C) To Achieve Nearly Sinusoidal Air Gap Flux Density Distribution
D) To Increase Induce E.M.F Per Coil

51. The Main Task Of Power Electronics Is:


A) Rectification
B) DC To AC Convertor
C) AC To AC Convertor
D) DC To DC Convertor
E) All Of The Above
52. Boost Strapping Circuit Is Also Used As An Isolation To Get.
A) High Input Impedance
B) Low Input Impedance
C) High Gain
D) High Bandwidth
53. In A Series Dc Motor The Highest.
A) Torque
B) Weight
C) Speed
D) Power Consumption
54. It Is Not Recommended To Run The ____________________ Motor When Load Is Removed.
A) Shunt
B) Series
C) Compound
D) Long Shunt
55. An Ideal Voltage Source Has The Internal Resistance Of.
A) Zero Ohm
B) Low Resistance
C) High Resistance
D) Open Circuit
56. An Ideal Current Source Has The Internal Resistance Of.
A) Zero Ohm
B) Low Resistance
C) High Resistance
D) Open Circuit
57. Which Of The Following Is The Functionality Of The Diode?
A) Filtration
B) Rectification
C) Demodulation
D) Conversion
58. What Is Power Factor?
A) True Power Divided By Apparent Power
B) Peak Power Multiplied By 0.707
C) Sine Difference Between f And I
D) Cos Difference Between f And I
59. Time Division Multiplexing Use:
A) Continuous Wave Modulation.
B) Pulse Modulation
C) Amplitude Modulation
D) Frequency Modulation
60. For Analysis Of Continuous Time Signals Which Type Of Equations Are Used?
A) Differential Equation
Engr. Muhammad Shafique
B) Difference Equation
C) Algebra Equation
D) Simple Equation

61. Laplace Transform Of A Unit Step Function Is.


A) 1
B) S
C) 1/S
D) 1/S^2
62. When All Initial Conditions Of The State Are Zero The Response Occurring Due To Input Only Is Called.
A) Zero Input
B) Zero State
C) Zero Input And Zero State
D) None Of The Above
63. In Root Locus When K=0 Points On The Root Loci Are At The Of G(S)H(S).
A) Roots
B) Poles
C) Both Poles And Zeros
D) None Of The Above
64. Coupling Capacitor are Chosen Ensure That The Value ______________ At The Amplifier’s Operating
Frequency.
A) Very Small
B) Small
C) Large
D) Very Large
65. The Common Mode Rejection Ratio ( CMRR ) Is The Ratio Of:
A) The Difference Mode Gain To The Common Mode Gain
B) Non Inverting Gain To Inverting Gain
C) Inverting Gain To Non Inverting Gain
D) None Of The Above
66. Replacing A Standard Transistor With A Darlington Pair In An Emitter Follower Configuration For BJTS
Causes The Voltage Gain To:
A) Decrease
B) Increase
C) Remain The Same
D) Be Exactly Equal To 1
67. The Controlling Torque In Indicating Instrument Is Obtained By
A) Spring Control
B) Gravity Control
C) Both A And B
D) None Of The Above
68. Which Of The Following Equations Can Be Used To Define Accuracy?
A) Precision + Calibration Error
B) Precision + Sensitivity
C) Sensitivity + Reproducibility
D) Precision + Significant Figure
69. It Is Difficult To Measure The Efficiency Of A Transformer By Output-Input Measurement Methods
Because:
A) The Output Is Sinusoidal And Hence Cannot Be Measured
B) Losses Are Abnormally High
C) Efficiency Of Transformer Is Usually High And Hence Extremely
Engr. Muhammad Shafique
Accurate Measurements Will Be Necessary
D) Output Is Out Of The Phase With Respect To Input
70. The Phase Difference Between The Primary And Secondary Voltage Of A Transformer Is
A) 0˚
B) 90˚
C) 180˚
D) 360˚
71. In Case Of 0 Hz Frequency The Maximum Current Will Pass Through
A) Resistor
B) Inductor
C) Capacitor
D) Mem- Restor
72. A Lamp Of 200w At 400 V Supplies Current At 200 Volts, Which Would Be Equivalent To The Lamp Of:
A) 100 W
B) 80 W
C) 50 W
D) 25 W
73. Normally, The Temperature Coefficient Of A Doped Semiconductor Resistor Is:
A) Negative
B) Positive
C) Zero
D) Infinity
74. The Magnetic Field On A Current Carrying Conductor Is Directly Proportional To:
A) Current Of The Conductor
B) Resistance Of The Conductor
C) Thickness Of The Conductor
D) Distance From The Source
75. The Force Of Repulsion Between Two Like Magnetic Poles Depends On The:
A) Distance Of The Poles From Each Other
B) Strength Of Poles
C) Nature Of The Medium Between Them
D) Nature Of The Magnetic Material
E) All Of The Above
76. The Total Number Of Lines Of Magnetic Induction Passing Through Any Surface Placed Perpendicular To
The Field Is Called:
A) Magnetic Induction
B) Magnetic Flux
C) Self Induction
D) Flux Density
77. In A Shift Register, In Oder To Serially Shift Abyte Of Data, There Must Be.
A) One Clock Pulse
B) One Load Pulse
C) One Clock Pulse For Each 1 In The Data
D) 8 Clock Pulses
78. Which Of The Following Flag Has A Special Role In Debugging?
A) Sign Flag
B) Direction Flag
C) Interrupt Flag
D) Trap Flag
79. The Minimum Number Of 2-Input Nand Gates Required To Perform The Function Of 2-Input Or Gate Is:
A) 4
B) 2
C) 6
Engr. Muhammad Shafique
D) 3
80. Which Of The Following Expression Is Not Equal To X?
A) X Nor 1
B) X Nand X
C) X Nand 1
D X Nor X
81. Which Combination Of Gates Does Not Allow The Implementation Of An Arbitrary Boolean Function?
A) Or Gates And Xor Gates Only
B) Or Gates And Not Gates Only
C) Or Gates And And Gates Only
D) Nand Gates Only
82. Convert The Decimal Number 151.75 To Binary.
A) 10010111.10
B) 00010111.11
C) 11010111.11
D) 10010111.11
83. The Peak Vale Of A Sine Wave Is 200 V. Its Average Value Is :
A) 141.4 V
B) 127.4 V
C) 200 V
D) 282.8 V
84. If The Sinusoidal Wave Has A Frequency Of 50 Hz With 30 A RMS, Then The Equation Representing This
Wave Is Given By:
A) 60 Sin 25t
B) 42.42 Sin 314t
C) 30 Sin 50t
D) 84.84 Sin 25t
85. The Input Of Ac Circuit Is 40 KVA Having A Power Factor 0.8 Lagging, Than The Power Drawn By The
Circuit Is:
A) 12 KW
B) 22 KW
C) 64 KW
D) 32 KW
86. Compared With Full Wave Rectifier Using 2 Diodes, A 4-Diodes Bridge Rectifier Has The Advantage Of:
A) Lower Peak Inverse Voltage Requirement
B) Higher Current Carrying
C) Lower Ripple Factor
D) Higher Efficiency
87. In An AC Circuit, A Low Value Of KVAR Compared With KW Indicates:
A) High Power Factor
B) Low Efficiency
C) Unity Power Factor
D) Maximum Load Current
88. A SCR Is Rated At 75 A Peak, 20 A Average, The Greatest Possible Delay In The Trigger Angle If The Dc
Is At Rated Value Is:
A) 47.5˚
B) 30˚ To 40˚
C) 74.5˚
D) 137˚
89. A Sine Voltage Of 200 Vrms, 50hz Is Applied To An SCR Through 100 Ω Resistor. The Firing Angle Is
60˚, Consider No Voltage Drop.
A) 89.7 V
B) 166.7 V
Engr. Muhammad Shafique
C) 200√2 V
D) 126.7 V
90. The SCR Can Be Turned On By:
I. Applying Anode Voltage At A Sufficiently Fast Rate
II. Applying The Sufficiently Large Anode Voltage
III. Increase The Temperature Of SCR To A Sufficiently Large Value
IV. Applying Sufficiently Large Gate Current
A) I, II
B) III, IV
C) I, III, IV
D) I, II, III, IV
91. Laminated Insulation Coated With Varnish Are Norm Ally Used In The Transformer:
A) To Reduce The Effect Of Eddy Current
B) To Reduce Reluctance Of Magnetic Path
C) To Increase Reluctance Of Magnetic Path
D) To Reduce The Hysteresis Effect
92. If 90 % Of Normal Voltage And 90 % Of Normal Frequency Are Applied To A Transformer, The Percent
Change In Hysteresis Losses Will Be
A) 4.7 %
B) 14.7 %
C) 47 %
D) 24.7 %
93. Inter Poles In DC Machines Are Provided To Reduce:
A) Armature Reaction
B) Sparking
C) Iron Loss
D) Efficiency
94. Which One Of The Following Is Not Application Of Electro Acoustic Transducer?
A) Loudspeaker
B) Microphone
C) Sonar Sensor
D) Electro Galvanic Fuel Cell
95. Waveform Generator Is Used To Generate _______________________ Waveform.
A) Electrical
B) Electromechanical
C) Electrochemical
D) Mechatronic
96. Ten Microamperes Can Be Expressed In:
A) 10 Ma
B) 10 Ka
C) 10 Ma
D) 10 µa
97. Magnetic Deflection Is:
A) Directly Proportional To Voltage
B) Inversely Proportional To Voltage
C) Directly Proportional To (Voltage)0.5
D) Inversely Proportional To (Voltage)0.5
98. The Function Of Hunt In Ammeter Is To:
A) By Pass The Current
B) Increase Sensitivity Of Meter
C) Increase Resistance Of Meter
D) Increase Current In Meter
99. Electron Gun In CRO Consists Of
Engr. Muhammad Shafique
A) Cathode And Grid
B) Accelerating Anode, Cathode And Grid
C) Accelerating Anode And Grid
D) X – Y Plates
100. A Modulus 4 Counter Has A Total Of ___________________ States
A) 1
B) 2
C) 4
D) 16

Das könnte Ihnen auch gefallen