Beruflich Dokumente
Kultur Dokumente
8 Which three phase Star- Star Star- Delta Delta -Delta Zig Zag
connection can be used
on a transformer to
introduce a phase
difference of 30 0
between its output and
input?
9 A transformer is Unity Zero 0.9 Lagging 0.95 Leading
supplying pure resistive
load. The power factor on
primary side will be
10 The inputs to the state Perfect power system Imperfect power system Voltage and frequency of active power generation
estimation are measurements measurements the system and load
11 Making capacity of a Symmetrical breaking rated voltage and rated o.c. voltage and s. c. s. c. voltage and o. c.
circuit breaker is current and rated voltage current current current
expressed in terms of
12 The RRRV of the circuit Type of circuit breaker capacitance of the inductance of the system inductance and
breaker depends upon system only only capacitance of the
the… system only
13 SF6 Circuit breakers sealing problem of gas ingress of moisture in the deterioration of SF6 with both (a) and (b)
have drawback(s) of gas system is dangerous time
14 The rating of a circuit Symmetrical line to line single line to ground double line to ground
breaker is usually
determined on the basis
of __fault
15 Capacitor switching in air blast vacuum minimum oil SF6
33kV power system is
better done with
____circuit breaker
16 The resistance of the low High the minimum possible infinite
earth should be
17 The transmission of 20-30 km 40-60 km 80-100 km 200 km
power using cable is
impossible beyond …
18 The insulation resistance megger ohmmeter earth tester any of these
test is performed on
power line using
19 Load frequency control Proportional controller Integral controller both proportional and either proportional or
uses integral control integral
20 If the generating unit is unity less than one zero more than one
situated far from the load
centre the penalty factor
for the unit will be
21 The principle of sequence of adding unit load allocation between total plant capacity to be All the above
incremental cost is the units operated
employed for deciding
the…
22 Which method is used for incremental fuel cost loss coefficient Dynamic programming kron's method
Unit commitment ?
23 Load duration curve gives variation in the load average load duration of the rated load none of the above
information of during different hours of
the day
24 The load factor is equal to average load/peak load peak load/average load average load/ connected average load/base load
load
25 A generating station has 5MW 4MW 6MW 10MW
a maximum demand of
30 MW, a load factor of
60% and a plant capacity
factor of 50%. The
reverse capacity of the
plant is
26 The power which must be spinning reserve firm reserve cold reserve hot reserve
available under
emergency condition is
known as ….
27 A 3 phase Y connected 3.22 5.33 10 90
alternator is rated at
1600KVA, 13500 V. The
armature effective
resistance and
synchronous reactance
are 1.5 and 30 Ohm
respectively per phase.
Calculate the %
regulation for a load of
1280 kW at unity p.f.
28 If the input to the prime reactive power active power both active and reactive voltage
mover of an alternator power
connected to infinite bus
is kept constant but the
excitation is changed,
then the _______out put
changes
29 In a transmission system, E 1/E<SUP>2</SUP> E<SUP>2</SUP> 1/E
the weight of copper used
is proportional to
30 String efficiency of potential cross each disc Short circuit current of dielectric strength of losses in each disc
insulator gives indication insulator Insulator disc
of ...
31 The string efficiency of a 100% 60% 10% 80%
high voltage line is
around
32 The effect of corona is …. increased energy loss increased inductance increased reactance All the above
33 The skin effect in increase in d c resistance decrease in ac resistance increase in ac resistance decrease in d c
conductor results in resistance
34 The inductance of the decrease in line length increase in diameter of increase in spacing increase in load current
power transmission line the conductor between conductors
increases with
35 Bundled conductors are reduce the inductance of reduce the corona loss reduce the inductance reduce the inductance
used to the line and capacitance and corona loss
36 The values of A B C and Z,0,1 and 1 0,1,1 and Z 1,Z,0 and 1 1,1,Z and 0
D constants of a short
transmission line are
respectively
37 A cable has inductance of 28Ὠ 20Ὠ 42Ὠ 32Ὠ
0.22 mH per km and
capacitance of 0.202 μF
per km. The surge
impedance of the cable is
44 In inverse definite Saturation of the Appropriate time delay Proper mechanical Electro-magnetic
minimum time relays, the magnetic circuit. element. design. damping.
minimum time feature is
achieved because of
45 In over current protection, Equal to phase fault Less than phase fault More than phase fault The two setting are not
the setting of earth fault relays. relays. relays. related to each other.
relays is
46 MHO relay is normally Short transmission lines Medium transmission Long transmission lines Distribution lines
used for the protection of lines
57 Booster is connected in Parallel with feeder Series or parallel Star connection Series with feeder
58 Which fault gives rise to Single line to ground fault Three phase fault Line to line fault Double line to ground
symmetrical fault current? fault
86 Which of the following is Right against exploitation Right to constitutional Right to property Cultural and Educational
not a fundamental Right remedis Rights
in India?
87 What is the approximate( 70% 79% 90% 85%
letest) literacy rate in
Gujarat state?
88 Which satellite has been Mars Orbiter Mission GSAT-14 INSAT 7 ARYABHATA
launch by India recently?
89 Who is the energy Bhupendra sinh Narottam bhai Patel Saurabh Patel Nitinbhai Patel
minister of Gujarat ? Chudasama
90 How far is the moon from 384,400 km 38,000 km 153400 km 60,000km
the earth?
91 He was offered a part turned back turned out turned over turned down
time job but he
________it _______
because he wanted to
concentrate on his
studies.
92 Our manager gave us the worked on worked to worked over worked in
general plan and we
_______ the minor details
93 As they approaching to they approaching the they will be approaching they approach the they approach to the
the house, the colonel's the
wife calls him for tea
94 Centuries of servility has has been making him have made him has made him has been made him
been making him tame
and passive, incapable of
any resentment or revolt