Sie sind auf Seite 1von 4

No Question Option A Option B Option C Option D

1 Cross arms are made of Iron rod Angle iron Asbestos sheet Steel
2 Multicore cables are used upto 2000V 5000 V 11000 V 33000 V
3 A lead sheath in the underground To protect against the To protect the cable To provide strength to To provide proper
cable is provided entry of moisture from mechanical injury cable insulation

4 Open circuit fault in the cable is Induction test Murray loop test Capacity test Fall of potential test
found by
5 The function of conservator in a to prevent flow of to prevent flow of air to improve the power to take care of
transformer moisture into the tank into the tank factor expansion and
contraction of oil
6 The chemical used in breather is sodium chloride silica gel copper sulphate silica sand
7 Buchholz relay is generally not 5 kVA 100 kVA 50 kVA 500 kVA
provided on transformers below
8 Main equipments required for High vacuum filtering Oil storage tank with Oil dielectric strength All of these above
filling the oil in transformers plant silica gel breather tester
9 Lightning arresters are located at the tower top at the generator at the transformer at the line entry point
terminal terminal of the power house
10 Control and relays panels are in open space in control room in the switch yard in close space
always located
11 The fault clearing time of a circuit few minutes few seconds one second few cycles of supply
breaker is usually voltage
12 The power factor of the arc in always zero always unity always lagging always leading
circuit breaker is
13 Main causes of electrical lack of earthing lack of proper not obeying Working on live
accidents are protective device instructions equipment
14 Painful electric shock is felt when less than 1 ma from 1 to 8 ma from 8 to 15 ma from 15 to 50 ma
magnitude of current passing
through human body is
15 The magnitude of fault current total impedence upto voltage at the fault load current being both (a) and (b)
depends upon fault point supplied before
occurance of fault
16 The Z per phase of a 3-ɸ 1.5 pu. 1.0 pu 0.5 pu 0.25 pu
transmission line on a base of 100
MVA 100 kV is 2 pu. The value of
this Z on a base of 400 MVA and
400 kV would be
17 Zero-sequence currents can flow grounded star/delta delta/star star/grounded star delta/delta
from a line to transformer bank if
the windings are in
18 Zero-sequence currents flow in a double line to ground an overvoltage in the a line to line faults. a fault across all the
transmission line when there is fault line caused by charged three lines.
loads.
19 The contact resistance of a circuit 20 Ω 2Ω 20 m Ω 20 µ Ω
breaker is about
20 The recovery voltage will be zero 0.5 0.707 unity
maximum forpower factor of
21 The pressure of SF6 gas in a 0.25kg/cm2 1 kg/cm2 4 kg/cm2 40 kg/cm2
circuit breaker is around
22 In a vacuum circuit breaker, the 1 torr 10-6 torr 10-12 torr 10-16 torr
vacuum is of the order of
23 A thermal protection switch overload temperature short-circuit over-voltage
provides protection against
24 Circuit breakers with reliability and Air-blast SF6 oil Vacuum
negligible maintenance is
25 The most suitable circuit breaker oil air-blast SF6 air-break
for short line fault without
switching resistor is
26 Making capacity of a circuit 2.55 times symmetrical 1.5 times symmetrical √2 times symmetrical symmetrical breaking
breaker is equal to breaking current. breaking current. breaking current. current.

27 Current ratingisnot necessary in isolators circuit breakers load break switches circuit breakers and
case of load break switches
28 Protective relays can be designed light intensity temperature resistance, reactance all of the above
to respond to or impedance.
29 Under voltage relays are mostly transformer protection busbar protection motor protection feeder protection
used for
30 A reactance relay is voltage restrained over- voltage restrained directional restrained directional restrained
current relay. directional relay. over-current relay. over-voltage relay.
31 Mho relays have an R-X plane a straight line passing a straight line parallel a straight line parallel a circle passing
characteristic depicted by through origin. to X-axis. to R-axix. through origin.
32 For phase fault the relay used is distance relay thermal relay over-current relay induction relay.
33 Where severe synchronising impedance relay mho relay reactance relay induction relay.
swing occurs, the relay employed
is
34 In three-phase system, what is the three one six two
minimum number of relays used to
detect phase-to-phase faults

35 A static coincidence circuit is used phase comparison amplitude comparison starting an impedance biasing a mho relay
for relay
36 The percent bias for a generator 5 to 10 10to 15 15 to 20 20 to 25
protection lies between
37 Magnetising in-rush current in a 3rd harmonic 5th harmonic 2nd harmonic all odd harmonic
transformer in rich is component component component components
38 Bus-coupler is very essential in single bus-bar ring bus-bar double bus, double main and transfer bus
arrangement arrangement breaker arrangement
39 For complete protection of a 3- three phase and three three phase and two two phase and two two phase and one
phase transmission line we earth fault relays. earth fault relays. earth fault relays. earth fault relay.
require
40 Impulse ratios of insulators and both low. high and low low and high both high.
lightning arresters should be respectively. respectively.
41 In a thyrite lightning arrester the varies linearly with the increases with the decreases linearly with is high at low current
resistance applied voltage. applied voltage. the applied voltage. and low at high
current.
42 A thyrite type lightning arrester blocks the surge absorbs the surge offers a low resistance returns the surge back
voltage appearing in a voltage appearing in a path to the surge to the source.
line. line. appearing in a line.

43 Steepness of the travelling waves line resistance. line inductance. line capacitance. both (b) and (c )
is attenuated by
44 The insulation level of a 400 kV lightning over-voltage switching over-voltage. corona inception radio and TV
EHV overhead transmission line is voltage. interference.
decided on the basis of
45 The advantage of neutral earthing safety of personnel. reduction of earth fault elimination of arcing none ofhte above.
is current. fault current.
46 Resistance earthing is employed 3.3 and 11 kV. 11 and 33 kV. 33 and 66 kV. 66 kV and 132 kV.
for voltages between
47 The method of neutral grounding positive-sequence negative-sequence zero-sequence both positive-and zero-
affects the network. network. network. sequence networks.
48 The voltage of a transmission line excitation control. using induction reactive VAR injection any of the above
can be controlled by regulator. methods.
49 Shunt compensation in an EHV improve stability. reduce fault level. improve the voltage substitute for
line is used to profile. synchronous phase
modifier.
50 For cost and safety the outdoor 11 kV and above. 33 kV and above. 66 kV and above. 110 kV and above.
substations are employed for
voltages
51 AC network analyser isemployed load flow. load flow and stability. load flow and short- load flow, stability and
for solving the problems of circuit. short-circuit.
52 The load carrying capability of a always limited by the limited by stability reduced at low ambient decreased by the use
long ac transmission line is conductor size. considerations. temperatures. of bundled conductors
of single conductors.
53 Steady-state stability of a power reducing fault clearing using double circuit single pole switching. decreasing generator
system is improved by time. line instead of single inertia.
circuit line.
54 The critical clearing time of a fault reactive power limit. short-circuit limit. steady-state stability transient stability limit.
in power system is realated to limit.

55 The transient stability limit of a series inductance. shunt inductance. series capacitance. shunt capacitance.
power system can be appreciably
increased by introducing

56 Load-flow study is carried out forload-frequency control. planning of power fault calculations. study of stability of the
system. system.
57 In load-flow analysis, the load constant current drawn constant impedance voltage and frequency constant real and
connected at a bus is represented from the bus. connected at the bus. dependent source at reactive power drawn
as the bus. from the bus.
58 In a load-flow study a PV bus is voltage limit is violated. active power limit is phase angle is high. reactive power limit is
treated as a PQ bus when violated. violated.
59 A 12-bus power system has 3 21 X 21 21 X 19 19 X 19 19 X 21
voltage controlled buses. The
dimensions of the Jacobian matrix
will be
60 Transmission efficiency increases voltage increases but voltage decreases but voltage and power voltage and power
as power factor power factor increases factor both increase factor both decrease.
decreases
61 What type of insulators will be strain type shackle type Pin type. suspension type
used if the direction of the
transmission line is changed?
62 Feeders are used to link receiving end distribution transformer line in the consumer generating station with
substation to to consumer's area area to the premises of receiving end
distribution transformer the consumer substation.

63 The secondary distribution system 3.0 kV, 3-phase, 3 wire 6.6 kV, 3-phase, 3 wire 1 kV, 3-phase, 3 wire 400/230 V, 3-phase, 4
(A.C.) employs system system system wire system
64 In order to increase the limit of synchronous series resistances are series capacitors and shunt capacitors and
distance of transmission line condensers are used used shunt reactors are series reactors are
used. used.
65 A power system load bus usually unity power factor leading power factor lagging power factor zero power factor
run with
66 To compensate Ferranti effect shunt capacitors are series capacitors are shunt inductors are series inductors are
used used used used
67 Connection of shunt capacitors at increases regulation decreases regulation does not affect maximise the
the receiving end bus of power regulation regulation
line
68 In a power system reactive power for power transmission for stabilizing voltage for stabilizing for counter acting the
is necessary level frequency effect of reactance in
the transmission
system
69 In Fast Decoupled Load Flow singular zero square unity
method, the matrices [H] and [L]
are
70 The characteristic impedance of a conductivity of the shape of the conductor surface treatment of geometrical
transmission line depends upon material the conductors configuaration of the
conductors
71 A capacitor connected in parallel neutral displacement Ferranti effect loss of stability surges.
with an equipment provides some
degree of protection against

72 Apart from the 'skin effect' the non- Faraday's effect Bundledconductor Proximity effect Ferranti effect
uniformity of the current
distribution is also caused by
73 If we increase the length of Decreases Increases Remains the same Not affected
transmission line, the charging
current
74 The method of images originally Calculationof Calculation of Effect of earth on line None of the above
suggested by Lord Kelvin is used inductance resistance capacitance
in
75 The capacitance becomes short transmission medium transmission Both (a) and (b) Long transmission
increasingly important for lines. lines. lines
76 A long line under no load Shunt resistance at Shunt reactors at the Shunt capacitors at all of the above
conditions, for a good voltage receiving-end receiving-end receiving-end
profile needs
77 With 100% series compensation Low transient voltage High transient current The current is series both (b) and (c )
of lines resonant at power
frequency
78 In Gauss-Seidel method of power Gauss constant Acceleration constant Blocking factor Deceleration constant
flow problem, the number of
iterations may be reduced if the
correction in voltage at each bus
is multiplied by
79 For accurate load flow calculations Newton Raphson Gauss Seidel method Decoupled method Fast Decoupled Load
on large power systems, the best method Flow
method is
80 Which one of the following is not Corona loss is more Back-to-back Distance limitation Extra reactor power
true for HVDC transmission? than a HVAC connection is possible exists has to be supplied

81 The Parliament of India consists of Rajya Sabha and Lok Rajya Sabha, Lok Rajya Sabha, Lok Rajya Sabha, Lok
Sabha only Sabha and the Prime Sabha and the Sabha and the Chief
Minister President Justice of India
82 Which of the following is an Deuterium Nitrogen Calcium Magnesium
element of Heavy Water?
83 Which bird is considered to be the Black Eagle Swift Peregrine Falcon Silver Hawk
fastest in the world?
84 Which part of the human body is skin lungs eyes bone marrow
most vulnerable to nuclear
radiation?
85 Find the correct Combination DC motor - Nikolo Laptop - Sinclair Computer - Digital CD - Sony
Telsa Corp.
86 Name India's first electric car Reva RAV4 Pirus RAV 6
manufactured by Maini Group
87 Which sportsman promoted the Geet Sethi Sunil Gavaskar Anil Kumble Mahesh Bhupathi
portal kheladi.com, which was
eventually acquired by Sify?
88 An android is any robot that Has more than one Has the ability to make Is built by other robots Looks and acts like a
basic function decisions and human
formulate plans
89 When is Martyr's Day celebrated 2nd October 30th January 22nd March 24th January
90 Who is the first and fastest indian Parmjeet Singh Mihir Sen Narayan Karthikeyan Saloo - Neha
to circumnavigate the earth by Choudhari
car?
91 <b>Choose the meaning of the Behaves dishonestly. Works for both sides. Creates discord among Argues in support of
idiom or phrase :-</b> Cut both friends both sides
ends
92 <b>Choose the meaning of the Ridiculed him Suspended him Reprimanded him Grinned him
idiom or phrase :-</b> Took him to
task
93 <b>Choose the meaning of the Resigned Got fired of Was demoted by Was dismissed from
idiom or phrase :-</b> Got the
sack from
94 <b>Find part of sentence with Since I meet Dinesh last Saturday he has been contacting everday over phone
grammatical or idiomatic error in it me
:- </b> Since I meet Dinesh last
Saturday he has been contacting
me everday over phone

95 <b>Find part of sentence with Had you informed me I would have certainly purchase the car from you
grammatical or idiomatic error in it earlier
:- </b> Had you informed me
earlier I would have certainly
purchase the car from you
96 <b>Find part of sentence with We have carefully considered the importance of issues in the report
grammatical or idiomatic error in it raised
:- </b> We have carfully
considered the importance of
issues raised in the report
97 <b>Find part of sentence with Due to his health Mani retired from the service last year
grammatical or idiomatic error in it problem
:- </b> Due to his health problem
Mani retired from the service last
year
98 The Judge used legal discretionary special absolute
his________________power and
let him off with reprimand.
99 Man is exaggerated astonished instrumental accountable
sometimes______________in
destroying something that is most
precious to him
100 It is time that both modernists and essentially indispensability justification implications
traditionalists reconsidered the
______________ of secularism in
political life.

Das könnte Ihnen auch gefallen