Beruflich Dokumente
Kultur Dokumente
Shield Radome
Radome
Shield
Optional
Description
This shield is designed to reduce side-lobe radiation Antenna mounting
levels of high performance, parabolic antennas. The Reflector
pipe on tower
instructions given in this bulletin apply to shields for
antennas with diameters of 1.8 meters (6ft), 2.4 meters Shield
(8ft), 3 meters (10ft) and 3.7 meters (12ft).
Radome
Notice
The installation, maintenance or removal of antenna
systems requires qualified, experienced personnel.
Andrew installation instructions have been written for such
personnel, Antenna systems should be inspected once a
year by qualified personnel to verify proper installation,
maintenance and condition of the equipment.
Air Scoop
Tools
Standard hand tools can be used for this installation. A
ratchet and deep well wrench sockets are recommended. Area and Personnel Requirements
However, combination wrenches, box or open-end type, Allow as much flat terrain as possible to assemble the
may be used. Wrench sizes for the furnished bolt hardware shield, typically four or five times the diameter of the
are as follows: antenna.
Wrench size Bolt size Use the following values to determine how many people
will be needed to life the shield assembly onto the
10mm M6 reflector.
13mm M8 Antenna Shield
16-17mm M10 Weight Weight
Other tools include: 1.8m (6ft) 35kg (78lb)
Two large standard blade head screwdrivers 2.4m (8ft) 52kg (115lb)
Four large Phillips head screwdrivers 3m (10ft) 54kg (120lb)
One pair of slip joint pliers 3.7m (12ft) 94kg (210lb
1 Top of Shield
RF absorber
2
M6 Bolt
4 Flat Washer
Lock Washer
Nut
Shield Ring
J-bolt
bracket
3
M10 bolt
Ring brace
Flat Washer
Shield Ring 30mm outer
diameter
Flat Washer
21mm outer
diameter
Lock Washer
Nut
RF absorber J-bolt
plastic fastener bracket
4 Plastic absorber
Shield ring retainer and Shield Wall
fastener Inspect
for and
replace
broken
Plastic absorber fasteners
fastener
RF absorber
5
Align tape
markers (top
of antenna)
Loosely add
6 Insert wood flange hardware
spacer at each
Red tape marker seam
indicates top of
shield
Shield Flange
Nut
Lock Washer
Flat Washer
Red tape marker
indicates top of
antenna Spacer Reflector
Thickness
Flat Washer
M8 bolt
7 Squeeze clip
onto RF gasket Remove
and hook it onto a wood spacers
flange bolt
Overlap RF gasket
ends and remove
wood spacers
2
M6-8N.m
(6lb.ft)
M8-19N.m
(14lb.ft) 1
M10-39N.m
(29lb.ft)
9
Top of shield
M6 bolt, plain
washer and
lock washer,
8Nm(6lb.ft)
Alternate Metal
Air Scoop
Air Scoop Plastic Air Scoop