Beruflich Dokumente
Kultur Dokumente
1. The injection moulding machine and cooling tower was turn on. The pattern had been set
in the machine. Once the temperature was steady, the heater was turn on.
2. The plastic powder was transfer into the hopper. The material used is homopolymer.
3. To generate product manually, the mode choose was ‘SEMIAUTO’.
4. The products that been obtained from the injection process were analysis if there were any
defects.
RESULTS
1. Unfilled section
1. Flash
1 2. Bubble
1. Bubble
2 3 2. Sink mark
1 3. Flash