Beruflich Dokumente
Kultur Dokumente
Ans: C
2.A mass of 1200g is accelerated at 200 cm/s2by a force. The value of the force
required is:
a.2.4N
b.2400N
c.240kN
d. 0.24N
Ans: A
a. 0.4W
b. 20W
c. 40W
d. 200W
Ans: C
4.Find the Thevenin equivalent (VTH and RTH) between terminals A and B of the
circuit given below.
5.A certain current source has the values IS = 4 μA and RS= 1.2 M ohm. The values
for an equivalent voltage source are
A.4.8microV, 1.2 Mohm
B.1 V, 1.2 M ohm
C.4.8 V, 4.8 M ohm
D.4.8 V, 1.2 M ohm
Ans:D
A.7.3 mA
B.5.5 mA
C.12.8 mA
D.1.8 mA
Ans: D
7.A 680 ohm load resistor,RL, is connected across a constant current source of 1.2 A.
The internal source resistance,RS, is 12 k . The load current,RL, is
A. 0 A
B. 1.2 A
C.114 mA
D.1.14 A
Ans: D
8.Determine IN for the circuit consisting of VS,R1,R2, and R3 shown in the given
circuit.
A.676 mA
B.245 mA
C.431 mA
D.75 mA
Ans:B
9.A 120 V voltage source has a source resistance,RS, of 60 ohm. The equivalent
current source is
A.2 A
B.4 A
C.200 mA
D.400 mA
Ans:A
Ans:C
Ans:D
12. When compared a 1st order LPF with a 2nd order LPF has
a. lower voltage gain.
b. higher voltage gain.
c. higher cut off frequency.
d. faster drop in filter response.
Ans:c
Ans:a
Ans:b
Ans:b
Ans:b
17. If the percentage reactance of an element is 20 % and the full load current is 50
Amp, the short circuit current will be
a. 250 Amp.
b.300 Amp.
c. 200 Amp.
d. 350 Amp.
Ans:a
Ans:d
19. A circuit with resistor, inductor, capacitor in series is resonant of 50 Hz. If all the
values are now doubled, the new resonant frequency is
a. f0 / 2.
b. f0 / 4.
c. 2f0.
d. still f0.
Ans:a
20. Can a 250 V, 5 A single way switch be used in place of a 250 V, 15 A Switch?
a. Single way switch doesn't exist.
b. Yes.
c. No.
d. Single way switch doesn't operate at such current ratings.
Ans:c
21. A periodic voltage having the Fourier series V(t)= {1 + 4sinωt + 2cosωt} V is
applied across a one ohm resistor. The power dissipated in the one ohm resistor is
a. 1 W.
b. 21 W.
c. 11 W.
d. 24.5 W.
Ans:c
Ans:a
23. An AC power source will supply maximum power to a load when
a. XL = XS.
b. ZL = ZS.
c. ZL= ZS *.
d. None of them.
Ans:c
a.VC >VL.
b.VL > VC.
c. XL > X C.
d. None of above.
Ans:a
25. A two terminal black box contains a series combination of a resistor and
unknown two terminal linear device. As soon as the battery is connected to the
black box the current is found to be zero. The device is
a. an inductor.
b. a resistor .
c. a diode.
d. an unknown.
Ans:a