Beruflich Dokumente
Kultur Dokumente
0 DC Motor
STEP 1 Check Components and Details
Make sure your QNET DC Motor experiment includes the following components:
A
Ensure that the NI ELVIS II power switch
is in the off position.
D 24V 2.0A
24V 2.0A +15V
-15V
+5V
+15V
-15V
+5V
External Power
External Power
Connect the NI ELVIS II power supply
to the back panel of the NI ELVIS II.
E
Use the NI ELVIS II USB cable to connect
the NI ELVIS Unit to your computer.
PC
F
+15V
24V 2.0A
Connect the QNET DC Motor power supply.
-15V
+5V
External Power
G Power on the NI ELVIS II using the power switch on the
back of the unit. The READY and ACTIVE LEDs on the
top NI ELVIS II panel should briefly light, and the READY
LED stays on.
• Ensure that the PCI connector on the QNET board is properly connected to the female
connector on the NI ELVIS II unit.
At least one of • Check that the system power switch, located on the back panel of the NI ELVIS II unit,
the +15V, -15V, or and the prototyping power switch, situated on the top of the NI ELVIS are ON.
+5 LEDs on the
QNET DC Motor • If one or more of the +15V; -15V; or +5V LEDs is still not lit, then the 15V or +5V fuse(s)
on the Protection Board of the NI ELVIS II has been triggered. Similarly, if the External
board are not lit.
Power LED is still not lit after connecting the QNET DC Motor power, the Variable
Power Supplies Fuses on the NI ELVIS II Protection Board have been triggered. See the
Protection Board Fuses in the NI ELVIS II User Manual.
QNET 2.0 Rotary Pendulum QNET 2.0 VTOL QNET 2.0 HVAC
©2014 Quanser Inc. All rights reserved. NI ELVIS is a trademark of National Instruments. QNETs were developed by Quanser exclusively for National Instruments. V3