0 Bewertungen0% fanden dieses Dokument nützlich (0 Abstimmungen)
1K Ansichten3 Seiten
The document summarizes the specifications of the Flexi 3-Sector Sector RF Module 2100 (FRGT). It can operate with bandwidths up to 60MHz for transmission and 60MHz for reception. It supports WCDMA configurations up to 4+4+4 carriers and concurrent WCDMA and LTE operation defined by software. The radio has three 80W power amplifiers at the antenna connectors and supports chaining of multiple units. It has dimensions of 25kg and operates in temperatures from -35 to +55 degrees Celsius.
The document summarizes the specifications of the Flexi 3-Sector Sector RF Module 2100 (FRGT). It can operate with bandwidths up to 60MHz for transmission and 60MHz for reception. It supports WCDMA configurations up to 4+4+4 carriers and concurrent WCDMA and LTE operation defined by software. The radio has three 80W power amplifiers at the antenna connectors and supports chaining of multiple units. It has dimensions of 25kg and operates in temperatures from -35 to +55 degrees Celsius.
The document summarizes the specifications of the Flexi 3-Sector Sector RF Module 2100 (FRGT). It can operate with bandwidths up to 60MHz for transmission and 60MHz for reception. It supports WCDMA configurations up to 4+4+4 carriers and concurrent WCDMA and LTE operation defined by software. The radio has three 80W power amplifiers at the antenna connectors and supports chaining of multiple units. It has dimensions of 25kg and operates in temperatures from -35 to +55 degrees Celsius.
•Bandwidth Tx: • 40MHz (RU30EP2) • 60MHz (RU40), depending on output power •Bandwidth Rx 60MHz •WCDMA configurations up to 4+4+4 •HW supports chaining of the radios •Three 6Gbps OBSAI interfaces • 25 kg • IP65 •Concurrent operation WCDMA and LTE • -35 to +55 °C defined by SW AN2429 FRGT Tx BW in RU40
FRGT Tx BW up to 60MHz, depending on output power (RU40 on top)
Tx BW Output power 0-20MHz 80W FRGT Tx BW in RU40 20MHz-45MHz 70W* 45MHz-60MHz 60W
= BTS will be commissioned as 80W (e.g. 4x20W
x20W per pipe) and RFM internal power control will mit the total power to 70W when needed 3x80W RFM interfaces FRGT 8-Pin Male Connector, Circular 8F IEC 60130-9 (RET) Sector 3 Sector 2 Sector 1, 7/16 connector DivRx 80 W / Rx DivRx 80 W / Rx DivRx 80 W / Rx
Sector 3 Sector 2 Sector 1
Ext RX Out Ext RX Out Ext RX Out
GND EAC, RJ45 2xLED, Unit 3 x RP3 optical FAN connector
& Fan status DC IN connector (RFM internal use, enables FAN unit replacement)