Beruflich Dokumente
Kultur Dokumente
2. HAZARDS IDENTIFICATION
3. COMPOSITION/INFORMATION ON INGREDIENTS
Inhalation: Remove patient from exposure, keep warm and at rest. Obtain medical
attention, treatment is symptomatic.
Skin Contact: Wash immediately with water followed by soap & water.
Eye Contact: Immediately irrigate with eyewash solution or clean water, holding the
eyelids apart, for at least 10 minutes. Obtain medical attention.
On ingestion: Immediately rinse mouth and then drink plenty of water, do not induce
vomiting, obtain medical attention.
Unsuitable extinguishing
media for safety reasons: none.
Special protective
equipment: Fire/explosion fumes should not be inhaled. Wear
self-contained breathing apparatus and protective
suit.
7.1 HANDLING
7.2 STORAGE
Store indoors, or keep away from direct sunlight and avoid water build up on top of
the containers. This material is hygroscopic. Avoid ingress of moisture by keeping
containers properly sealed when not in use
MSDS 227
Page 3 of 4 TRIPOR 227 COMPONENT A REVISED JULY 2008
Acute toxicity: This product contains tertiary amine catalyst, to which the
following data apply LD50/oral/rat 1810 mg/kg
Additional information: The product has not been tested. The statements are
based on the properties of the individual components.
Toxicity: No Data.
MSDS 227
Page 4 of 4 TRIPOR 227 COMPONENT A REVISED JULY 2008
S-Phrases
S26 In case of contact with eyes, rinse immediately with plenty of water and seek
medical advice.
S27 Take off immediately all contaminated clothing.
S28 After contact with skin, wash immediately with water followed by soap and
water
S36/37/39 Wear suitable protective clothing, gloves and eye/face protection.
National legislation/regulations
This product is not classified under the 1993 Chemicals (Hazard Information and
Packaging) Regulations, SI No 1746.
16 OTHER INFORMATION
The information herein is based on the present state of our knowledge and does not
therefore guarantee certain properties. Recipients of our product must take
responsibility for observing existing laws and regulations.
MSDS 227