Beruflich Dokumente
Kultur Dokumente
a. The three bend tests are acceptable and the fourth one
is not acceptable
b. The test result overall is acceptable
c. The test result is not acceptable due to the linear
indication
d. The bend test result is indeterminable, carry out re-
test.
a. 200° F
b. 100° F
c. 75° F
d. 150° F
a. GTAW
b. SMAW
c. GMAW
d. SAW
5. What is the P number and the tensile strength of SA-106-C?
/conversion/tmp/scratch/407044185.doc
1/18/2019 / 12:32:28 PM /NCD
Professional Training and Consultation
API 570 Preparatory
3 – 8 Sep05, Al-Khobar, Saudi Arabia
Page 2 of 5
a. F No. 4
b. F No. 3
c. F No. 2
d. F No. 1
8. The welder who welded the test plate for PQR 101 is qualified to
weld in what position?
a. Flat
b. Flat and horizontal
c. Flat and vertical
d. Flat, vertical and horizontal
9. The bend test specimen used are side bend. They are:
/conversion/tmp/scratch/407044185.doc
1/18/2019 / 12:32:28 PM /NCD
Professional Training and Consultation
API 570 Preparatory
3 – 8 Sep05, Al-Khobar, Saudi Arabia
Page 3 of 5
10. As far as thickness ranges for Base Metal (B.M.) and weld metal
(W.M.) as shown on WPS are concerned, your decision about the
qualified range is:
11. PWHT of PQR test coupon shows “No PWHT”. It means that the
PWHT for ____________:
13. Based on the specimen areas provided in PQR, are the ultimate
stress calculations correct (as rounded up to 100 psi) for
specimen T1 and T2:
/conversion/tmp/scratch/407044185.doc
1/18/2019 / 12:32:28 PM /NCD
Professional Training and Consultation
API 570 Preparatory
3 – 8 Sep05, Al-Khobar, Saudi Arabia
Page 4 of 5
14. Which condition below best describes the result of tensile tests
reported on the PQR?
--------------------------------End-----------------------------
ANSWER KEY
/conversion/tmp/scratch/407044185.doc
1/18/2019 / 12:32:28 PM /NCD
Professional Training and Consultation
API 570 Preparatory
3 – 8 Sep05, Al-Khobar, Saudi Arabia
Page 5 of 5
/conversion/tmp/scratch/407044185.doc
1/18/2019 / 12:32:28 PM /NCD