Beruflich Dokumente
Kultur Dokumente
®
Sika ViscoCrete -5930 room temperature and intensively mixed.
®
Combinations Sika ViscoCrete -5930 may be combined with the following Sika products:
®
Sika Pump .
®
Sika Rapid .
®
Sika Ferrogard -901.
®
Sikafume .
®
Sika Fro -V5A
®
Sika Retarder
Pre-trials are recommended if combinations with the above products are being
made. Please consult our technical service.
Important Sika ViscoCrete® -5930 is also used to produce flowing and self compacting
Flowing Concrete concrete (S.C.C.) For these, special mix designs are required, contact our
Technical Service division.
S.C.C
Safety Instructions
Ecology Do not dispose of into water or soil, but according to local regulations.
Transport Non-hazardous.
Safety Precautions In contact with skin, wash off with soap & water. In contact with eyes or mucous
membrane, rinse immediately with clean warm water and seek medical attention
without delay.
Toxicity Non-Toxic under relevant health and safety codes.
Legal notes The information and in particular the recommendations relating to the application and end-use of Sika
products, are given in good faith based on Sika’s current knowledge and experience of products when
properly stored, handled and applied under normal conditions. In practice, the differences in materials,
substrates and actual site conditions are such that no warranty in respect of merchantability or of fitness for
a particular purpose, nor any liability arising out of any legal relationship whatsoever, can be inferred either
from this information, or from any written recommendations, or from any other advice offered. The
proprietary rights of third parties must be observed. All orders are accepted subject to our current terms of
sale and delivery. Users should always refer to the most recent issue of the technical data sheet for the
product concerned, copies of which will be supplied on request.
For further technical information, please consult our technical service department.