Beruflich Dokumente
Kultur Dokumente
Issue V1.2
Date 2011-02-28
All other trademarks and trade names mentioned in this document are the property of their respective
holders.
Notice
The purchased products, services and features are stipulated by the contract made between Huawei and
the customer. All or part of the products, services and features described in this document may not be
within the purchase scope or the usage scope. Unless otherwise specified in the contract, all statements,
information, and recommendations in this document are provided "AS IS" without warranties, guarantees
or representations of any kind, either express or implied.
The information in this document is subject to change without notice. Every effort has been made in the
preparation of this document to ensure accuracy of the contents, but all statements, information, and
recommendations in this document do not constitute the warranty of any kind, express or implied.
Website: http://www.huawei.com
Email: support@huawei.com
Contents
1 Introduction....................................................................................................................................1
2 Technical Specifications..............................................................................................................3
2.1 Frequency Band.................................................................................................................................................3
2.2 Capacity.............................................................................................................................................................4
2.3 Receiver Sensitivity...........................................................................................................................................4
2.4 Output Power.....................................................................................................................................................5
2.5 Power Consumption...........................................................................................................................................8
1 Introduction
The MRFU can be used in an indoor cabinet or a protective outdoor cabinet. The MRFU
performs modulation, demodulation, data processing, and combination and division of
baseband signals and RF signals. With the Software Defined Radio (SDR) technology, the
MRFU can work either in GU or GL dual-mode through software configuration modification.
Figure a.1 shows the MRFU.
To meet the requirements for radio network deployment, the BBU3900 and MRFU are
connected through a CPRI interface that uses an electrical or optical cable to transmit CPRI
signals.
The BBU3900 and the MRFU are connected in dual-star topology. That is, the CPRI port on
the GTMU is connected to CPRI0 on the MRFU, and the CPRI port on the WBBP or LBBP is
connected to CPRI1 on the MRFU, as shown in Figure a.2.
2 Technical Specifications
2.2 Capacity
Table 2.4 Capacity
Mode Capacity
The GSM power is measured when the modulation scheme is GMSK. If the modulation scheme is
8PSK, the output power is 1.8 dB less than that in GMSK mode.
Only MRFU V2 modules support the V2 specifications.
The MRFU at 1800 MHz supports the LTE mode in terms of hardware.
*: The UMTS mode is supported in terms of hardware.
The output power is 1 dB lesser than the standard power when the MRFU is located at a height of
3500 m to 4500m; and is 2 dB lesser than the standard power when the MRFU is located at a height
of 4500 m to 6000m.
Factors such as the site-to-site distance, frequency-reuse factor, power control algorithm, and
traffic model affect the gain achieved by dynamic power allocation. Therefore, in most cases, the
network planning can be based on the power specification achieved by dynamic power allocation.
Power sharing cannot be used together with RAN sharing with BSS and RAN, concentric cell, Co-
BCCH, and IBCA.
In power sharing mode, the power control and DTX must be set to ON.
Power sharing assumes a random distribution of UEs in the cell.
Table 2.6 lists the typical configurations of the MRFU V2 at 850MHz, 900 MHz or 1800
MHz in compliance with the specifications for multi-carrier base station in EN 301 502
V9.2.1.
Table 2.6 Typical configurations of the MRFU V2 (850MHz /900 MHz /1800 MHz)
Number Number Number Output Output Sharing Output Output
of GSM of UMTS of LTE Power per Power per GSM Power per Power per
Carriers Carriers Carriers GSM Carrier Carrier (W) UMTS LTE Carrier
(W) Carrier (W) (W)
1 0 0 60 60 0 0
2 0 0 40 40 0 0
3 0 0 27 31 0 0
4 0 0 20 27 0 0
5 0 0 16 20 0 0
6 0 0 12 20 0 0
0 1 0 0 0 60 0
0 1 0 0 0 2 x 60 (MIMO 0
with two
MRFUs)
0 2 0 0 0 40 0
0 2 0 0 0 2 x 40 (MIMO 0
with two
MRFUs)
0 3 0 0 0 27* 0
0 3 0 0 0 2 x 27 (MIMO 0
with two
MRFUs) *
0 4 0 0 0 20* 0
0 4 0 0 0 2 x 20 (MIMO 0
with two
MRFUs) *
0 0 1 0 0 0 1 x 60
Table 2.7 lists the typical configurations of the MRFU at 1900 MHz in compliance with the
specifications for multi-carrier base station in EN 301 502 V9.2.1.
1 0 60 60 0
2 0 40 40 0
3 0 27 31 0
4 0 20 27 0
5 0 12 20 0
6 0 10 16 0
0 1 0 0 60
0 2 0 0 40
0 3 0 0 27*
0 4 0 0 20*
The typical power consumption for GSM is reached when the base station works with 30% load
and power control and DTX are enabled. The maximum power consumption for GSM is reached
when the base station works with 100% load.
The typical power consumption for UMTS is reached when the base station works with 40% load.
The maximum power consumption for UMTS is reached when the base station works with 100%
load.
The typical power consumption for LTE is reached when the base station works with 50% load.
The maximum power consumption for LTE is reached when the base station works with 100% load.
The power consumption for GSM is calculated based on the sharing power.
Item Specification
BTS3900 Mode (900MHz) Configuration Output Power Typical Power Maximum Power
(–48V) per Carrier (W) Consumption (W) Consumption (W)
GSM 3×2 20 570 830
3×4 20 690 1,240
3×6 12 620 1,160
UMTS 3×1 20 450 660
3×2 20 590 900
LTE 3×1 2 x 60 1,425 2,040
BTS3900A Mode (900 MHz) Configuration Output Power Typical Power Maximum Power
(AC per Carrier (W) Consumption (W) Consumption (W)
power) GSM 3×2 20 570 850
3×4 20 690 1,250
3×6 12 620 1,180
UMTS 3×1 20 450 670
3×2 20 590 920
LTE 3×1 2 x 60 1,600 2,290
BTS3900L Mode (900 MHz) Configuration Output Power Typical Power Maximum Power
(–48V) per Carrier (W) Consumption (W) Consumption (W)
GSM 3×2 20 600 890
3×4 20 710 1,290
3×6 12 640 1,220
UMTS 3×1 20 470 710
3×2 20 570 910
LTE 3×1 2 x 60 1,470 2,100