Beruflich Dokumente
Kultur Dokumente
3 2
In Work
A
3
4
A = 5 mm
1 Nut
2 Drive shaft
3 Frame
Note! This procedure is only valid for machines equipped with Design
Correction.
a) Place the position mark (3) on the film (4) in front of the photocell beam
as shown in figure 1.
The colour of the photocell beam (2) can vary between red, blue and
green depending on the contrast of the mark.
b) Press and hold the button (1) for more than 1 second until the yellow
LED flashes slowly.
c) Place the film (5) in front of the photocell beam as shown in figure 2.
d) Press and hold the button (1) for more than 1 second until the yellow
LED goes out.
The photocell is now set.
e) Repeat for both photocells.
In Work
3 4 5
2
1
Figure 1 Figure 2
1 Button 4 Film
2 Beam 5 Film
3 Position mark