Beruflich Dokumente
Kultur Dokumente
Unit and conversion (kilo, mega, gega, milli, micro, nano, pico), KV, P.D.
<< E.M.F. (internal resistance), series parallel circuit. Transformer
(mutual inductance).
DAY 2
Front panel of DMM, introduction of resistor, color code intro. Check
value on DMM and tally calculated. Capacitor concept, charging &
discharging, construction, value calculate, diff between supply and i/p,
o/p, ground and Vcc. Breadboard intro, Voltage divider rule, check AC
mains, check LDR, check thermistor, run motor with pot, LED concept,
diode p-n junction, transistor NPN, PNP, Demo power supply, relay intro.
DAY 3
Intro of op-amp, Concept of amplifier, IC concept, type of IC and package,
pin diagram, symbol of op-amp, concept of gain, feedback concept,
inverting amplifier,
DAY 4
Square wave generator, adder, binary system and conversion, L.D.R. light
sensor and alarm, Temperature sensor and alarm, lift control, IR remote
control motor, light, clap sensor motor H-bridge run it forward reverse
motion
DAY 5
IC 555 timer (astable mode, bistable mode, monostable mode )7
segment display, obstacle detector, entry counting project. Tone
generation using speker, Water level indicator.
DAY 6
DTMF-module hands on blink LED from mobile phone DTMF coding how
to read datasheet. Boost voltage using relay coil.