Beruflich Dokumente
Kultur Dokumente
Inglês Técnico
Dual DC power supply rectifier
RIO DE JANEIRO
2
2019
WANDERSON SANTOS NEVES
DIEGO PEREIRA DA SILVA
Inglês Técnico
Dual DC power supply rectifier
RIO DE JANEIRO
2019
3
Resumo:
If you are looking for a dual power supply rectifier circuit that uses only one
secondary coil. We have many ways to use.
The first section is a normal mode. Which it includes first bridge diodes (D5
through D8) they act as full wave rectifies ACV to DCV. Then, a capacitor
C4 will filter the pulsating DC into a steady direct current (DC).
The second section. Also, the AC signal from the input will flow to C1 and
C2 to the Bridge rectifier (D1 through D4)
Then, the current flow to filter the pulsating DC voltage of out others bridge
diode of the transformer. It causes we can connect directly the positive of 0
volts. Thus, the output will be symmetric both positive and negative.
If you need to have a low ripple voltage than this. We must use more
capacitance of all capacitors.
While we must use the voltage and the current rate of the diode to higher
than the power transformer and the load.
E como C3 é cobrado por impedância maior que C4. Por causa do valor
de C1 e C2. Assim, o valor de C3 deve ser maior que C4, para causar uma
ondulação de tensão DC simétrica tanto positiva quanto negativa.