BODY & ACCESSORIES
ON-BOARD DIAGNOSTIC
[IMMOBILIZER SYSTEM]. ..
ON-BOARD DIAGNOSTIC
[AUDIO] .
SYMPTOM
TROUBLESHOOTING
[POWER WINDOW SYSTEMS
(WITH AUTO-OPEN/CLOSE
FUNCTION FOR
DRIVER-SIDE)]........... 09-03A
SYMPTOM
TROUBLESHOOTING
[KEYLESS ENTRY
SYSTEM]).......0200s000e 09-038
SYMPTOM
TROUBLESHOOTING
[IMMOBILIZER SYSTEM]. ..
09-02A
. 09-02B
09-03C
SYMPTOM
TROUBLESHOOTING
DOORS AND LIFTGATE .
GLASS/WINDOWS/
MIRRORS .
SEATS....
SECURITY AND LOCKS .
EXTERIOR TRIM
INTERIOR TRIM .
LIGHTING SYSTE!
WIPER/WASHER SYS"
ENTERTAINMENT .
POWER SYSTEMS. .
INSTRUMENTATION/DRIVER
TECHNICAL DATA .
SERVICE TOOLS
09-02A ON-BOARD DIAGNOSTIC [IMMOBILIZER SYSTEM]
FOREWORD
[IMMOBILIZER SYSTEM]. .
DTC TABLE
[IMMOBILIZER SYSTEM
DTC oH...
DTC 02..
DTC 03
prc 11.
DTC 2
DTC 24.
DTC 30.
09-02A-3
9-02A-4
19-0204
:09-02A-5
+09-02A-5
FOREWORD [IMMOBILIZER SYSTEM]
Caution
* When the engine does not start or stalls and the following DTCs are not indicated, go to engine
symptom troubleshooting.
Note
‘+ When the immobilizer system is defective, the engine cannot be started.
* If engine condition is normal but light stays on, inspect for short circult between security light and
immobilizer unit connector terminal M. Repair or replace the wiring harness if necessary.
+ The DDS! js installed to the FIP with set bolts and cannot be removod. if there isa possibilty that the
DDS is faulty, be sure to ask your distributor to repair it
1. Turn the ignition switch to ON position,
2. Verify the security light condition and read the DTC if indicated.
3. IF the DTC is indicated, go to troubleshooting referring to the DTC table.
09-02A-1ON-BOARD DIAGNOSTIC [IMMOBILIZER SYSTEM]
DTC TABLE [IMMOBILIZER SYSTEM]
BIC ‘Output pattern
Page
“Lt
TD number unregistered in immobiizor units | (See 09-02A-3DTC
input after engine switch is turned to ON |O1[]MMOBILIZER,
position or cranking engine. SYSTEM)
° ML
1D number mat enor (tage ange, | S000302R SOT
frequency) SYSTEM)
TD number is notinput into immobiizer unit | (See 09-02A-4 DTC,
1"
03, alter engine switch is turned to ON position |O3fIMMOBILIZER,
2 Jor cranking engine. SYSTEM)
(Gee 08-02A-5 DTC
Coil or wiring harness between immobilizer
. 7 {A[IMMOBILIZER
nit and col is open circut. SYSTEM)
:
(See 09-02A-5 DTC
Code wordID number stored in immobiizer | Temi ER
nit EEPROM cannot be read.
: SySreM)
(Gee 802K30TC
Open or short circuit in wiring harness §
Saiwonmmebtzerintandg Obst. [eaiMMOB
= IG oye of mmobize unt open ore or
| [6 creut of ODSt for short to cet
7 DDSI defect. (Malnctin of (Sesseoor sore
communication rele B58 soqsavoes
Immobilizer unit or DDS1 is defective. (Code ~
“a orcs of mmobicer unt and DDS1 dont
match)
42 iF
DDS! is defective. (Communication error
‘between immobilizer unit and DDSt)
44
DDSI is defective, (Malfunction of DDSI,
‘except for malfunctions related to DTC 80,
41, 07 42
Note
* If DTC 25 and the other DTC are indicated, go to DTC 25 first and then go to the other DTC.
Note
* Perform the following if the security light stays on:
— engine stalls, go to symptom troubleshooting *NO.4 ENGINE STALLS-AFTER START/AT IDLE”.
— engine will not start, go to symptom troubleshooting “NO.5 CRANKS NORMALLY BUT WILL NOT
START" (See 01-03A-13 NO.5 CRANKS NORMALLY BUT WILL NOT START [WL-3))
— If engine condition is normal but light stays on, inspect for continuity between the following wiring
harness and body ground:
the wiring hares.
pTco1
;ecurity light and immobilizer unit connector terminal M. Repair or replace
DTC Ot | engine cranking.
1D number unregistered In Immobilizer unit is input after engine switch Ts turned to ON position or
POSSIBLE
CAUSE |
ID number Is unregistered in immobilizer unt.
Diagnostic procedure
‘STEP INSPECTION.
ACTION
[Gots 1D number Input procedure
| (Gee 09-14-24 Key Replacement or Addition )
09-02A-2ON-BOARD DIAGNOSTIC [IMMOBILIZER SYSTEM]
prc 02
DTCO3 [ID number format error (voltage range, frequency)
POSSIBLE
OSSIBLE | «Detective transponder in the key
Diagnostic procedure
‘STEP INSPECTION. ‘ACTION
Dispose of defective key.
= - — |Duplicate key if necessary.
(See 09-14-24 Key Replacement or Addition )
DTC 03
Dic 0g | D number is not input into immobilizer unit after engine switch is turned fo ON position or cranking
engine.
~ No transponder in the key
POSSIBLE | + Defective transponder in the key (ID number is not output.)
CAUSE —_| « Defective coll at steering lock
+ Defective wiring harness between coil and immobilizer unit
(COIL HARNESS SIDE
CONNECTOR
cles
Se
Diagnostic procedure
STEP | INSPECTION. ACTION
T [+ Bos socuriy ight indicate DTC 117 Yes [Gove DTC Tt
| No_|Go tonext step
2 | Does securily light indicate DTC 30? Yes [Goto DTC 30. a
No_ Go to next step
3 INSPECT FOR OTHER PROPER KEYS Yes | Dispose of defective key. |
'* Does engine start with other proper keys? Duplicate key if necessary.
(See 09-14-24 Key Replacement or Adition )
No [Go to next step. ~
INSPECT COIL CIRCUIT FOR SHORT TO | Yes | Repair the wiring harness connected to Terminals A andlor
GND OR COIL CIRCUIT FOR CONTINUITY c
* Disconnect he col connector. To | Troubleshooting fs completed
{Inspect for short circuits botwoon coi
connector terminals A and C and ground,
and also between col connector terminals A
and.
| + Isthore a short?
09-02A-3