Beruflich Dokumente
Kultur Dokumente
co
1
www.gradeup.co
1. For an ideal gas the value of Joule 10. In milling machine, the cutting tool is
Thomson coefficient is held in position by
A. Zero B. 0.5 A. Chuck B. Spindle
C. Unity D. Infinite C. Arbor D. Tool holder
Ans. A. Ans. C.
2. Perpetual motion machine of second 11. Collapsible tooth paste tubes are
kind violates the manufactured by
A. First law of thermodynamics A. Direct extrusion
B. Kelvin-plank statement B. Piercing
C. Clausius statement C. Impact extrusion
D. Third law of thermodynamics D. Indirect extrusion
Ans. B. Ans. C.
3. The ratio of thermal conductivity to
12. Sprue in casting refers to
electrical conductivity is equal to
A. Gate B. Runner
A. Prandtl number B. Schmidt number
C. Riser D. Vertical passage
C. Lorentz number D. Lewis number
Ans. C. Ans. D.
4. The effectiveness of a fin will be 13. In arc welding, arc is created between
maximum in a environment with the electrode and work by
A. Free convection A. Flow of current
B. Forced convection B. Voltage
C. Radiation C. Material characteristics
D. Convection and radiation D. Contact resistance
Ans. A. Ans. D.
5. With increasing temperature of intake 14. Preheating of work piece is essential in
air, IC engine efficiency welding
A. Decreases A. High speed steel
B. Increases B. Stainless steel
C. Remains same C. Cast iron
D. Depends on other factors D. Aluminium
Ans. A. Ans. C.
6. Thermal efficiency of CI engine is higher 15. An ideal voltage source should have
than that of SI engine due to A. large value of emf
A. Fuel used B. small value of emf
B. Higher compression ratio
C. zero source resistance
C. Constant pressure heat addition
D. infinite source resistance
D. Lower compression ratio
Ans. C.
Ans. B.
16. Which bulbs operates on lowest power
7. The float in the carburettor of a petrol
engine controls A. Night bulb B. Neon bulb
A. Flow rate of air C. GLS bulb D. Torch bulb
B. Flow rate of fuel Ans. D.
C. Flow rate of air-fuel mixture 17. Electrode in not consumed in the case
D. Level of the petrol in the float of
chamber A. TIG welding
Ans. D. B. MIG welding
8. Angle between the face and flank of the C. Gas welding
single point cutting tool is known as D. Resistance welding
A. Rake angle B. Clearance angle Ans. A.
C. Lip angle D. Point angle 18. DC generator are installed near the load
Ans. C. centres to reduce.
9. Which of the following is a cutting tool A. iron losses
material B. line losses
A. High speed steel B. Mild steel C. sparking
C. Cost iron D. Galvanized steel D. corona losses
Ans. A. Ans. B.
2
www.gradeup.co
19. In a DC motor, constant torque is 29. The depletion layer width of junction
produced due to A. decreases with light doping
A. rotor laminations B. end plates B. is independent of applied voltage
C. pole shoes D. commutator C. increases under reverse bias
Ans. D. D. increases with heavy doping
20. Which of the following is not a part of Ans. C.
transformer. 30. For mercury arc rectifiers, the anode is
A. Conservator B. Buccholz Relay usually made up of
C. Exciter D. Breather A. aluminium B. graphite
Ans. C. C. tungsten D. copper
Ans. B.
21. An induction motor is
31. For effective modulation, the degree of
A. self starting with zero torque
modulation should
B. self starting with high torque
A. small
C. self starting with low torque B. never exceed 100%
D. non self starting C. be large
Ans. C. D. always more than 100%
22. The term “cogging” is associated with Ans. B.
A. three phase transformer 32. Which of them radiates emission?
B. compound generators A. LED
C. DC series motor B. LCD
D. Induction motors C. Both LCD and LED
Ans. D. D. Neither LCD nor LED
23. The speed of universal motor is Ans. A.
generally reduced by using 33. Binary 101010 is equivalent to decimal
A. gear trains B. V-belts number
A. 24 B. 42
C. brakes D. chains
C. 64 D. 44
Ans. A.
Ans. B.
24. A thermal protection switch can protect
34. The number of valence electrons in
against
donor impurity are
A. short circuit B. temperature
A. 1 B. 3
C. over load D. Variable load C. 5 D. 7
Ans. C. Ans. C.
25. In a bipolar transistor which current is 35. A prismatic beam has uniform
largest A. Depth B. Width
A. collector current C. Strength D. Cross-section
B. base current Ans. D.
C. emitter current 36. A well graded soil has a coefficient of
D. base or emitter current curvature between
Ans. C. A. 10 to 12 B. 7 to 9
26. The word enhancement mode is C. 4 to 6 D. 1 to 3
associated with Ans. D.
A. tunnel diode B. MOSFET 37. How is the deflection in RC beams
C. photodiode D. varactor diode controlled as per IS : 456?
A. By using large aspect ratio
Ans. B.
B. By using small modular ratio
27. Which of the following has highest
resistivity? C. By controlling span/depth ratio
D. By moderating water-cement ratio
A. Mica B. Paraffin
Ans. C.
C. Air D. Mineral oil
38. A steel beam supporting loads from the
Ans. C. floor slab as well as from wall is termed
28. Power diodes are generally as
A. silicon diodes A. Stringer beam
B. germanium diodes B. Lintel beam
C. carbon diodes C. Spandrel beam
D. carbon or germanium diodes D. Header beam
Ans. A. Ans. C.
3
www.gradeup.co
39. The dimensions of dynamic viscosity μ Reason (R): Capacitors are mostly
are perfect.
A. ML–1 T–2 B. ML–1 T–1 A. Both A and R are true and R is correct
C. MLT –2 D. M°L°T° explanation of A
Ans. B. B. Both A and R are true but R is not
40. The representative fraction 1/2500 correct explanation of A
means that the scale 1 cm is equal to C. A is true R is false
A. 0.25 m B. 2.5 m D. A is false R is true
C. 25 m D. 2.5 km Ans. C.
Ans. C. 50. A voltmeter using thermocouples
41. CPM is the measures
A. time oriented technique A. RMS value B. Peak value
C. Average value D. Peak of peak
B. event oriented technique
value
C. activity oriented technique
Ans. A.
D. target oriented technique
51. To increase Q factor of a coil, the wire
Ans. C. should be
42. Which of the following cement has A. Thin B. Thick
maximum percentage of C3S C. Long D. Long and thin
A. Ordinary portland cement Ans. B.
B. Low heat cement 52. The undesirable taste and odours
C. Sulphate resisting cement caused by dissolved gases may be
D. Rapid hardening cement removed by
Ans. D. A. chemical treatment
43. Consistency as applied to cohesive soils B. aeration
is an indicator of its C. disinfection
A. Density B. Moisture content D. reverse osmosis
C. Shear strength D. Porosity Ans. B.
Ans. C. 53. The biochemical oxygen demand of
44. The needle of a magnetic compass is treated water should be
generally supported on a A. nil
A. Bush bearing B. Ball bearing B. less than 30 mg/I
C. Needle bearing D. Jewel bearing C. less than 150 mg/I
Ans. D. D. always more than 9 mg/I
45. Stainless steel resist corrosion due to Ans. A.
A. Carbon B. Manganese 54. The function of sluice valve provided in
pipe line is
C. Chromium D. Sulphur
A. to reduce the chances of pollution
Ans. C.
reaching into the pipe
46. A barometer is used to measure B. to reduce the pressure on pipes
A. Very low pressure C. to regulate the flow of water through
B. Very High pressure the pipes
C. Pressure difference between two D. to allow the air to enter the pipe
points Ans. C.
D. Atmospheric pressure 55. The source of lead in urban atmosphere
Ans. D. is
47. The household energy meter is A. bursting of cracker in festive season
A. indicating instrument B. road traffic
B. recording instrument C. construction works
C. integrating instrument D. small scale industries
D. visible instrument Ans. B.
Ans. C. 56. The noise level decreases with distance
48. Magnetic flux density has the following
dimensions A. inverse square law
A. MI–1 T–2 B. M–1 I–2 T–2 B. power law
C. ML T
–3 –2 D. MI–1 T–3 C. directly proportional to intensity
square
Ans. A.
D. inversely proportional to intensity
49. Assertion (A): De sauty’s bridge is
Ans. A.
suitable only for pure capacitor.
4
www.gradeup.co
5
www.gradeup.co
6
www.gradeup.co
7
www.gradeup.co
A. 40 3 m ( )
B. 10 3 + 3 m
A. Zoji La Pass
B. Bara Lacha Pass
1. Sikkim
2.
C. 20 ( )
3 –1 m D. 20 ( 3 – 3 ) m Uttarakhand
C. Jelep La Pass 3. Himachal Pradesh
Ans. B.
D. Niti Pass 4.Jammu and
112. If (x + 1) is a factor of x4 – 2ax3 + x2 – Kashmir
4, then a is equal to
A. A-4 B-1 C-2 D-3
A. –1 B. 2
B. A-2 B-3 C-4 D-1
C. 1 D. –2
Ans. C. C. A-4 B-3 C-1 D-2
113. One of the factor of (5x – 7x)3 – (3y – D. A-2 B-1 C-4 D-3
4x)3 is Ans. C.
A. (x – 10y) B. (x – 4y) 121. The Karakoram highway connects which
C. (9x + 4y) D. (9x – 10y) of the following pair of counties
Ans. D. A. India-Nepal B. India-China
114. The value of k for which 3x2 – 2x + 3k C. India-Pakistan D. China-Pakistan
= 0 has equal roots is Ans. D.
A. 1/9 B. 9 122. On raising the temperature of the
C. 1/18 D. 18 medium, velocity of light
Ans. A. A. increases
115. The sum of squares of the roots of the
B. decreases
equations x2 – 5x – 6 = 0 is
C. remains the same
A. 26 B. 30
C. 35 D. 37 D. suddenly decrease
Ans. D. Ans. A.
116. Which one of the following animals was 123. Which of the following is a
not represented on seals and terracota paramagnetic
art of the Harappan culture A. nickel B. cobalt
A. Cow B. Elephant C. chromium D. copper
C. Rhinoceros D. Tiger Ans. C
Ans. A. 124. If the length of a simple pendulum
117. A “Forgotten Empire”, written by the increase by 4%, then its time period will
renowned historian Robert Sewell is be
about which of the following Empires A. increased by 3%
A. Mauryan Empire
B. increased by 4%
B. Kushan Empire
C. increased by 2%
C. Vijaynagar Empire
D. increased by 8%
D. Mughal Empire
Ans. C. Ans. C.
8
www.gradeup.co
125. The India legislature was made bi- 133. Which oe of the following is not obtain
cameral for the first time by from stem?
A. Indian Council Act 1892 A. Sunhemp B. Jute
B. Indian Council Act 1909 C. Hemp D. Cotton
C. The Government of India Act 1919 Ans. D.
134. Plant which grow in saline soil are
D. The Government of India Act 1935
A. Xerophytes B. Hydrophytes
Ans. C.
C. Halophytes D. Succulents
126. Recommendations to the president of Ans. C.
India on the specific Union state fiscal 135. What are the type of bonds present in
relations are made by the- CuSO4. 5H2O
A. Finance Minister A. Electrovalent and covalent
B. Reserve Bank of India B. Electrovalent and co-ordinate
C. Planning Commission C. Electrovalent, covalent, co-ordinate
D. Finance Commission and hydrogen bond
Ans. D. D. Covalent and co-ordinate covalent
127. Who had estimated National income in Ans. C.
India first 136. Match List-1 with List-2 and select the
correct answer using the codes given
A. Dadabhai Naoroji
the lists.
B. R.C Dutt
List – 1 List -2
C. M.G. Ranade A. Blue vitriol 1.Sodium bicarbonate
D. W. Hunter B. Epsom salt 2. Sodium hydroxide
Ans. A. C. Baking soda 3. Magnesium sulphate
128. Match the Dams and the States in which D. Caustic soda 4. Copper sulphate
they are situated A. A-3 B-4 C-2 D-1
List-1(Dam) List-2 (State) B. A-4 B-3 C-2 D-1
1. Tungabhadra 1. Kerala C. A-3 B-4 C-1 D-2
2. Lower bhawani 2. Andhra Pradesh D. A-4 B-3 C-1 D-2
Ans. D.
3. Idukki 3. Tamil Nadu
137. Which one of th following is not an
4. Nagarjuna Sagar 4. Karnataka
essential micronutrient for plants?
A. A-3 B-2 C-4 D-1 A. Boron B. Zinc
B. A-2 B-4 C-3 D-1 C. Sodium D. Copper
C. A-4 B-3 C-1 D-2 Ans. C.
D. A-1 B-4 C-1 D-3 138. A renowed Hindi poet who received the
Ans. C. sahitya, Akedemi award for his work
129. Which one of the following was the ‘Hawa mein hastakshar ‘passed away
Chairman of the Committee on Pricing on April 1, 2015 is
and Taxation of Petroleum Products? A. Ajit Kumar
A. Raja J. Chelliah B. C. Rangrajan B. Kailash Vajpayi
C. Y.V. Reddy D. Abid Hussain C. Harishankar Parsai
D. Ravindra Kalia
Ans. B.
Ans. B.
130. The first Commonwealth Games were 139. The 99th constitution Amendment Act
held in year 1930 at was in news recently. It is related to
A. London (UK) A. National Judicial Appointments
B. Sydney (Australia) Commission
C. Hamilton (Canada) B. Right to work
D. Auchland (New Zealand) C. Reservation of women in police
Ans. C. services
131. Which of the following is currently D. Police action in Naxal-prone areas.
matched Ans. A.
A. Nehru trophy – Table tennis 140. Who has bee declared the best actor
and the best actress at the 62nd national
B. Holkar trophy - Bridge
film awards announced on March 24,
C. Ruia trophy - Kabaddi 2014 in new Delhi?
D. B.C. Roy Trophy-Lawn Tennis A. Sanjari Vijay and Kangana Ranaut
Ans. B. B. Sanjari Vijay and Baljinder Kaur
132. The disease Athlete foot is caused by C. Bobby Simhaa and Kangana Ranaut
A. Bacteria B. Fungi D. Bobby Simhaa and Baljinder Kaur
C. Protozoa D. Nematod Ans. A.
Ans. B.
9
www.gradeup.co
10
www.gradeup.co
11