Beruflich Dokumente
Kultur Dokumente
3505
Piping DSME Doc. 3505DR372P004
Revision 0
Color Coding
Procedure Page 1 of 12
2009. 07.20
NONE 3505DR372P004 0
Topside Project No. 3505
Piping DSME Doc. 3505DR372P004
Revision 0
Color Coding
Procedure Page 3 of 12
CONTENTS
PAGE
1.0 GENERAL---------------------------------------------------------------------------- 3
1. GENERAL
This procedure covers minimum requirements of color code for line identification on
Topside piping systems for TRANSOCEAN OFFSHORE INC. DISCOVERER INDIA
PROJECT.
Piping will be identified with the help of pipe maker labels in accordance with guideline
given in this procedure.
The purpose of the color coding is to easy identification of lines for operation and
maintenance. Placement of color coding bands shall be marked near the operation and
maintenance items such as valves, equipment, pumps, etc.
2. APPLICABLE SPECIFICATION.
A) Below & Above the Deck penetrations & on both sides of all
Wall/Bulkhead penetrations no matter what their height is,
B) At inlet and outlet of package.
C) Near each main valve
D) At Pipe connection, such as tees.
E) Each 15M on all straight runs no matter what height the straight run is
above the deck.
4.2 Above Color code identification shall be applied to the pipe above the deck by
2.5M and the service platform surrounded 2.5M for easy identification of the
lines to operate and to maintain the valves, equipment etc., it is not
necessities on not seen the line like just below the deck on behind lines.
Note:
1. Color marking shall be applied inside of hatching area.
4.3 The Color code band tapes shall be marked approximately 1.5m from the deck or
platforms for the vertical pipes.
4.4 The Color code band tapes are marked on the insulation jacket after insulation
but personnel protected lines are to be installed on pipe inside of personnel
protections.
4.5 The Color code band tapes are marked side by side for the two or more in a
group of pipes to scan easy at one time.
Topside Project No. 3505
Piping DSME Doc. 3505DR372P004
Revision 0
Color Coding
Procedure Page 6 of 12
DRAINS,
BG/BS DBOW BLACK YELLOW DBOW
BILGE/OILY WATER
DRAINS,SCUPPER,
SP/BS DSC WHITE DSC
OPEN DRAIN BLACK
DRAINS, WASTE
OD/BS/CD DWO BLACK ORANGE DWO
OIL/DO/CLOSED
FRESH WATER,
WW FWHP GREEN FWHP
HIGH PRESSURE BLUE
FRESH WATER ,
HC/FW FWP BLUE WHITE FWP
POTABLE
FRESH WATER,
HT FWT BLUE YELLOW FWT
TECHNICAL
Topside Project No. 3505
Piping DSME Doc. 3505DR372P004
Revision 0
Color Coding
Procedure Page 8 of 12
VR/HH/LH/
DT