Beruflich Dokumente
Kultur Dokumente
com/K58WEBMR/web/controller
Appliance(s) implicated:
The warning light D049 comes on (D048: "STOP" warning light ; D049: "SERVICE" warning light).
Recording of the fault code by the ECU G051.
A demand for automatic acceleration of the vehicle is impossible.
The warning light D049 comes on (D048: "STOP" warning light ; D049: "SERVICE" warning light).
Only the cartridge and the exhaust pipe can be subjected to maintenance.
In order not to damage the equipment, the repair steps should be carried out in the correct order.
General checks:
● The wiring harnesses and the fluids routing pipes are sound.
● The connectors are neither oxidized nor physically damaged.
● The connecting arrangement is not damaged.
● The connectors are properly plugged into their equipment.
Key: in the illustration above, the unit G001 is identified by item "A".
The location (see illustration above) is given as an indication only, for more precision, refer to the appropriate vehicle repair manual.
Turn the ignition key to the "stop" position. Turn the master switch to the "OFF" position. Turn the master switch to the "ON" position. Erase the fault code then restart the engine. Check whether the code
is again recorded. If so, turn the ignition key to the "stop" position, turn the master switch back to the "OFF" position and wit for 30 seconds before undertaking any troubleshooting.
Note down and process all the fault codes recorded in the appliances listed below.