Beruflich Dokumente
Kultur Dokumente
** ON A/C ALL
TASK 32-41-12-400-002-A
Installation of the Axle Sleeve
WARNING: BE CAREFUL WHEN YOU USE CONSUMABLE MATERIALS. OBEY THE MATERIAL
MANUFACTURER'S INSTRUCTIONS AND YOUR LOCAL REGULATIONS.
REFERENCE DESIGNATION
(Material No. 03GBB1) Synthetic Oil base Grease-General Purpose Clay Thickened -
(Material No. 03GCB1) Synthetic Oil base Grease-Landing Gear Wheel Bearing Lithium
Thickened -
(Material No. 08BBB1) Non Aqueous Cleaner-- Petroleum Based -
B. Referenced Information
REFERENCE DESIGNATION
(Ref. 32-41-12-400-001-A). Installation of the NLG Wheel
Axle Sleeve SHEET 1
A
A
1
A 2660GM
2659GM
N_MM_324112_4_BAM0_01_00
3. Job Set-up
Subtask 32-41-12-640-052-A
A. Preparation for Installation
(1) Clean the axle (1) with Non Aqueous Cleaner-- Petroleum Based - (Material No. 08BBB1). Dry it with
filtered compressed air .
(2) Lightly lubricate the axle (1) and the axle protective sleeve (2) with Synthetic Oil base Grease-
General Purpose Clay Thickened - (Material No. 03GBB1) or as alternative Synthetic Oil base
Grease-Landing Gear Wheel Bearing Lithium Thickened - (Material No. 03GCB1).
4. Procedure
(Ref. Fig. Axle Sleeve SHEET 1)
Subtask 32-41-12-420-051-A
A. Installation of the Axle Sleeve
(1) Install the axle sleeve (2).
(2) Install the retaining ring (3).
5. Close-up
Subtask 32-41-12-410-050-A
A. Close access
(1) Install the related wheel (Ref. AMM TASK 32-41-12-400-001) .
(2) Make sure that the work area is clean and clear of tools and other items.
End of document