Beruflich Dokumente
Kultur Dokumente
AQUA SEALER
(PART A)
Manufactured By SEA HORSE SERVICES SDN.BHD
PRODUCT NAME
AQUA SEALER (PART A)
MANUFACTURED BY
SEA HORSE SERVICES SDN.BHD
TELEPHONE NO.
+ 606 601 4501
2. HAZARD IDENTIFICATION
INFORMATION IN CLASS REGULATIONS 2013 CLASSIFICATIONS:
EMERGENCY Serious eye damage or eye irritation: Category 2
Skin corrosion or irritation: Category 2
Warning
Hazard statements :
Causes serious eye irritation
Causes skin irritation
HEALTH EFFECT a) Eye contact: Irritation with tearing, pain or blurred vision
b) Skin contact: May cause skin irritation
EYES CONTACT a) Flush eyes with a large amount of water not to stray chemicals at
least for 15 minutes.
b) See a physician if irritation persists.
INGESTION a) Seek medical advice immediately and show the container, label or
this data sheet.
b) Only induce vomiting at the instruction of a person.
c) Never give anything by mouth to an unconscious person.
TITANIUM DIOXIDE
13463-67-7 10 ~ 20
BLACK CARBON
1333-86-4 1 ~ 10
TALC 14807-96-6 20 ~ 30
EYES a) Promptly wash eyes with plenty of water while lifting the eye lids.
b) Continue to rinse for at least 15 minutes.
c) Immediately transport to hospital or eye specialist.
SPECIAL FIRE a) Cool closed container exposed to fire by spraying them with water.
FIGHTING b) Do not allow run water and contaminants from fire fighting to enter
PROCEDURES drains or water courses
HAZARDOUS a) Fire will produce dense black smoke. Decomposition products may be
COMBUSTION hazardous to health.
PRODUCTS b) Could be generated complex mixture like solid and gas containing CO,
SO2. Unidentified organic and inorganic compound.
PERSONAL
a) Wear suitable Personal Protective Equipment (PPE)
PRECAUTION IN
b) Remove sources of ignition. Do not turn lights or unprotected
SPILL
electrical equipment on or off.
PRECAUTIONS
a) Do not allow spills to enter drains or watercourses.
TO PROTECT b) If drains, sewers, streams or lakes are contaminated, inform the
ENVIRONMENT Department of Environment (DOE).
c) Empty containers may contain product residues, including flammable
or explosive vapors.
d) All label warnings must be observed until the containers have been
cleaned or reconditioned.
SPILL CLEAN UP
a) Ventilate the area and avoid breathing vapors.
METHODS
b) Stop flow of gas or liquid if possible.
c) Remove ignition sources.
d) Absorb spillage with non-combustible materials such as sand, earth
or vermiculite and place into containers.
e) Flush with plenty of water to clean spillage area.
HANDLING a) Solvent vapors from this product are heavier than air and may spread
PRECAUTIONS along floors.
b) Vapors may form flammable mixtures with air.
c) Areas of storage, preparation and application should be ventilated to
prevent the creation of flammable concentrations of vapor in air.
IN USE a) Avoid skin and eye contact. Avoid inhalation of vapors and spray mists.
b) Observe label precautions. Use appropriate personal protective
equipment as stipulated in Section 8.
c) Smoking, eating and drinking should be prohibited in all preparation
and application areas.
d) All sources of ignition (hot surfaces, sparks, open flames etc.) should
be excluded from areas of preparation and application.
e) Wash hands after handling and before eating, drinking and smoking.
STORAGE a) Store in a well ventilated, dry place away from sources of heat and
PRECAUTIONS direct sunlight.
b) Store on concrete or other impervious floor, preferably with bounding
to contain any spillage. Do not stack more than 3 pallets high.
c) Keep container tightly closed. Containers which are opened must be
carefully resealed and kept upright to prevent leakage. Keep in the
original container or one of the same materials.
EXPOSURE
Chemical Name CAS No. TWA STEL Notes
LIMIT
INFORMATION
10
EPOXY RESIN 25068-38-6 - -
mg/m3
HYDROCARBON RESIN 5
69430-35-9 - -
mg/m3
TITANIUM DIOXIDE 10
13463-67-7 - -
mg/m3
2
TALC 14807-96-6 - -
mg/m3
Form LIQUID
Odour CAMPHOR
Color
ALL RAL,BS COLOUR
Volatiles % 4%
VOC 54gm/lit
Flash Point
94C
Viscosity (25oC)
130 – 150 KU
Not Applicable
Epoxy Resin >5000 mg/kg 20,000 mg/kg
Hydrocarbon Resin
>2000mg/Kg Mildly irritating >2000mg/Kg
6,820mg/m3
Titanum Dioxide 24,000 mg/kg 10,000mg/kg
4 hours /jam
(rat / tikus) (rabbit/arnab)
(rat / tikus)
Talc Not Applicable Not Applicable
12mg/kg (mouse)
ECOLOGICAL
INFORMATION The product should not be allowed to enter drains or watercourses
or be deposited where they can affect ground or surface water.
1) Toxicity:-
Ingredient Result Species Exposure
Epoxy Resin Acute LC50 Daphnia 72hrs
1.3mg/L
Hydrocarbon No ecological information is known on the
resin product.
Titanium Available evidence indicates that Titanium
Dioxide Dioxide does not cause any significant adverse
environmental effects. Titanium Dioxide does
not bio accumulate.
Nonyl Phenol 0.135(0.098~0 Fish 96hrs
.187) mg/L
Talc - - -
2) Persistence and degradability:-
There is no data available on the preparation itself.
3) Bioaccumulative potential:-
Not measured
4) Mobility in soil:-
No data available
5) Results of PBT and vPvB assessment:-
The product contains no PBT and vPvB chemicals
6) Other adverse effects:-
No data available
DISPOSAL METHODS Empty containers should be taken for local recycling, recovery or
waste disposal.
WARNING
ARTICLE OF OCCUPATIONAL Applicable
SAFETY & HEALTH AGENCY
ARTICLE OF HARMFUL Not applicable
CHEMICAL SUBSTANCE
CLASSIFY OF FIRE SERVICE ACT Not applicable
This Information is given without any warranty or representation. We do not assume any legal
responsibility for same, nor do we give permission, inducement, or recommendation to practice
any patented invention without a license.
The data in this Material Safety Data Sheet relates only to the specific material designated
herein and does not relate to use in combination with any other material or in any process.